Professional Documents
Culture Documents
Upper clamp
Lower clamp
Upper clamp
Lower clamp
Ball
Clamp
Upper clamp
Lower clamp
Clamps for Normal Test in ASTM D5034
Back jaw
Front jaw
Jaws for Modified Test in ASTM D5034
Range-Number-Gauge-Speed-Fun-Intv-Slack-Yarn-Poise-Ret-Sret
Standard Test type Range Number Specimen size Gauge Speed Fun Intv Slack Yarn Ret Sret
ISO 13934-1 Strip H 5 300*50mm 200mm 100 Con speed 5 2N for ≤200g/m2 fabric Leave it alone; not need
tensile mm/min 5N for >200g/m2 to set
&≤500g/m2 fabric
10N for >500g/m2
fabric
Grab 50
ISO 13934-2 H 5 200*100mm 100mm Con speed 5 Not required
tensile mm/min
ISO 13937-1 Another machine, that is, Elmendorf Tearing Strength Tester, not tensile strength tester
100 100 Leave it alone; not need
ISO 13937-2 Single tear L 5 200*50mm Tearing 5 Not required
mm mm/min to set
Seam
ISO 13936-1 Can only perform on PC through test software
slippage
Upper clamp
Lower clamp
Jaw 4inch width
Upper clamp
Lower clamp
Clamps for Normal Test in ASTM D5034
Upper clamp
Lower clamp
Jaw 4inch width
200cm width Jaw for 200mm width specimen
Test piece size: 100*200mm, two, one without seam while one with seam
Upper clamp
Lower clamp
Clamps for Normal Test in ASTM D5034