Professional Documents
Culture Documents
PD042-07
Title:
TIRE PRESSURE WARNING
Technical Service VALVE/SENSOR ACTIVATION
Information Bulletin Models:
Introduction 2008 model year IS 250/350 vehicles are equipped with a direct-type Tire Pressure
Warning System (TPWS). Each tire has a tire pressure warning valve/sensor, and the
measured tire pressure data is transmitted to the Tire Pressure Warning System
antenna/receiver to the Tire Pressure Warning System ECU.
During Pre-Delivery Service (PDS), the tire pressure warning valves/sensors must be
activated according to the procedure in this bulletin.
NOTE:
Additional Techstream units may be ordered by calling Approved Dealer Equipment
(ADE) at 1–800–368–6787.
Page 2 of 4
TIRE PRESSURE WARNING VALVE/SENSOR ACTIVATION – PD042-07 Revised August 14, 2007
Activation 3. Press and hold either the right or left side of the satellite switch until the
Procedure multi-information display for “TIRE SELECT” appears. Check that “MAIN” is selected.
(Continued)
NOTE:
If “2ND” is selected, press the “ON/OFF” button until “MAIN” is selected.
NOTE:
This operation is required for the
system to be activated and must be
performed for each tire, one at a time.
Core
5. Using TIS Techstream, check for
TPWS DTCs.
S If NO DTCs are stored, go to step 6.
S If DTCs C2111 – C2114 are stored, repeat step 4.
HINT:
If the tire inflation pressure is NOT reduced by 6 psi (0.4 kgf/cm2, 40 kPa), or more,
within 30 seconds, the tire pressure warning valves/sensors will NOT be activated and
DTCs C2111 – C2114 will be stored in the TPWS ECU.
NOTE:
If DTCs C2111 – C2114 are present after repeating step 4, lift the vehicle and turn each
tire 90 to 270 degrees. Then repeat step 4.
Page 3 of 4
TIRE PRESSURE WARNING VALVE/SENSOR ACTIVATION – PD042-07 Revised August 14, 2007
NOTE:
It is necessary for the ignition to be
in the “IG-ON” mode AT LEAST
5 minutes for initialization to
complete correctly.
9. Check the tire pressure values of all the tires using TIS Techstream.
TPWS ECU / DATA LIST / TIREPRESS 1–4
NOTE:
It can take 2 – 3 minutes for the tire pressure values to be displayed on the TIS
Techstream Data List.
10. Adjust all tires to the standard tire inflation pressure, as indicated on the Tire and
Loading Information label located inside the driver’s door jamb.
NOTE:
If there is great difference between the current temperature of the tire and wheel (for
example: shop temperature) and expected temperature (for example: outdoor
temperature), this needs to be considered when adjusting the tire pressure.
Page 4 of 4