Professional Documents
Culture Documents
This question paper is the property of the City and Guilds of London
Institute and is to be returned after the examination.
1 a b c d
If you want to change your answer, cancel your first choice by filling in the lower half
of the box like this
1 a b c d
Then mark the answer which you have now decided is correct.
• Any calculations or rough working can be done on this paper.
• Attempt all questions. If you find a question difficult, leave it and return to it later.
This paper contains 30 questions. Answer them using the ‘boxes’ numbered
1 to 30 on the answer sheet.
2 Details of the wiring requirements for the controls of a condensing boiler would be found in
3 A spur is a
a) three phase
b) design current
c) direct current
d) single phase.
6129-208 Version C
1
7 Equipotential bonding is a method of
8 A plumber discovers damage to the main supply cable to a consumer unit during installation
work. Which one of the following would be the most appropriate action?
10 Which one of the following cable types would be used on domestic and general wiring, where
a circuit protective conductor is required for all circuits?
a) an immersion heater
b) a consumer unit
c) a gas valve
d) a central heating pump.
6129-208 Version C
2
13 The wires in a modern three core flex are colour coded brown, yellow and green, and
a) blue
b) red
c) black
d) white.
14 When the main bonding of metalwork in a dwelling takes place, the minimum size of earth wire
that should be used is
a) 1.5 mm²
b) 2.5 mm²
c) 6 mm²
d) 10 mm².
15 When bending PVC cable around corners, the radius of the bend should be such that the
cable or conductor
16 The best method of ensuring that surface mounted cable is given protection when being
installed on a wall surface, is by
17 The safest type of circuit protection device, at the consumer unit, for a pump to a Jacuzzi in a
bathroom is a
18 When cables pass through timber joists, the main reason that a 50 mm gap is required
between the top of the cable and the underside of the floorboards, is to
6129-208 Version C
3
19 The connection of the cable end into a fitting is known as a
a) closure
b) termination
c) connection
d) fitment.
20 When a connection is being made to an immersion heater, the consumer controls should
include a
Figure 1
a) claw washer
b) strip connection
c) pillar terminal
d) screw head.
Figure 2
6129-208 Version C
4
23 Which one of the following types of test would be conducted to ensure that in the event of an
electrical fault, the current would be leaked to earth, automatically disconnecting the supply?
a) Polarity.
b) Insulation resistance.
c) Reverse current.
d) Earth continuity.
Figure 3
25 Refer to Figure 3. The item of equipment shown is used for testing for
a) earth continuity
b) polarity
c) safe isolation
d) insulation resistance.
26 What is the capacity of the overload protection device required for an 8 kW instantaneous
electric shower operating at 240 volts?
a) 5 amps.
b) 16 amps.
c) 32 amps.
d) 40 amps.
27 Before isolating a supply at the consumer unit in an occupied domestic dwelling, the plumber
should advise the
a) Local Authority
b) power supply company
c) NICEIC inspector
d) customer.
6129-208 Version C
5
28 The most important safety precaution, when working on a macerator WC, is to ensure that the
supply is
6129-208 Version C
6