Professional Documents
Culture Documents
---------------------------------------------------------------------------------------------------------------------
PHILIPPINE ELECTRICAL CODE
INSTRUCTION: Select the correct answer for each of the following questions. Mark only
one answer for each item by shading the box corresponding on the letter
of your choice on the answer sheet provided. STRICTLY, NO
ERASURES ALLOWED. Use pencil No. 1 only.
MULTIPLE CHOICES
2. Calculate the resistance of 200 m of 1.5 mm2 copper cable if the resistivity of
copper is taken as 17.5 _ 10_9 m.
a. 1.3 Ω b. 2.3 Ω c. 233 Ω d. 1312 Ω.
7. An electronic circuit resistor is color coded green, blue, brown, gold. It has a
value of:
a. 56 Ω_10% b. 65 Ω_5%
c. 560 Ω_5% d. 650 Ω_10%.
8. An electronic device which will allow current to flow through it in one direction
only is a:
a. light dependent resistor (LDR)
b. light-emitting diode (LED)
c. semiconductor diode
d. thermistor.
10. An electronic device which emits red, green, or yellow light when a current of
about 10 mA flows through it is:
a. light dependent resistor (LDR)
b. light-emitting diode (LED)
c. semiconductor diode
d. thermistor.
11. An electronic device whose resistance changes as a result of light energy falling
upon it is a:
a. light dependent resistor (LDR)
b. light-emitting diode (LED)
c. semiconductor diode
d. thermistor.
12. The method most frequently used when designing an interior lighting scheme is
the:
a. cosine law b. inverse square law
c. lumen method d. reflective index method.
13. The most suitable cable for a hazardous or high-temperature installation is:
a. PVC insulated and sheathed cables
b. PVC cable
c. PILCSWA cables
d. MI cables
14. The part of the cable which sometimes requires some means of mechanical
protection is the:
a. conductor b. cable insulation
c. outer sheath d. PVC
15. The most suitable cable for wiring underground when some mechanical
protection is required is:
a. PVC insulated and sheathed cable
b. PVC cable
c. FP cable
d. MI cable
16. The most suitable cable for wiring domestic installations is:
a. PVC insulated and sheathed cable
b. PVC cable
c. FP 200 cable
d. MI cable .
17. A 12 V mini-spot lamp transformer has 1400 turns on the primary winding. When
connected to the 230 V mains supply the number of secondary turns will be
approximately:
a. 2 b. 73 c. 386 d. 4000
26. Which of the following is not a purpose of the motor starter connected to an
electric motor?
a. to start the motor
b. to reduce high starting currents
c. to provide overload protection
d. to provide no-volt protection
31. For electrical test results to be valid the test instruments used:
a. must be new
b. must be efficient
c. must have a calibration certificate
d. must have a digital readout
33. When testing a 230 V installation an insulation resistance tester must supply a
voltage of:
a. less than 50 V
b. 500 V
c. less than 500 V
d. greater than twice the supply voltage but less than 1000 V
34. The value of a satisfactory insulation resistance test on each final circuit of a 230
V installation must be:
a. less than 1 Ω
b. less than 0.5 MΩ
c. not less than 0.5 MΩ
d. not less than 1 MΩ
36. To ensure that all the systems within a building work as they were intended to
work ’ is one definition of the purpose of:
a. testing electrical equipment
b. inspecting electrical systems
c. commissioning electrical systems
d. isolating electrical systems.
37. Which of the following procedure shown below is not correct when diagnosing
and finding electrical faults?
a. isolate the whole system
b. use a logical and methodical approach
c. carry out the relevant tests recommended
d. recognize his own limitations and seek help and guidance where necessary.
38. A fault is not a natural occurrence, it is not planned and occurs unexpectedly.
Which of the following is not a cause of fault?
a. regular maintenance
b. negligence
c. misuse
d. abuse
39. The main lighting in a room having only one entrance would probably be
controlled by:
a. pull switch b. intermediate switch
c. two-way switch d. one-way switch
40. The main lighting in a room having two entrances would probably be controlled
by:
a. pull switch b. intermediate switch
c. two-way switch d. one-way switch.
41. A final circuit feeding socket outlets with a rated current of less than 20 A and
used by ordinary persons for general use must always have:
a. overcurrent protection
b. over voltage protection
c. splash proof protection.
d. incorporate an industrial type socket outlet
43. Which of the following should not be used to cover splices and the
free ends of conductors?
a. Electrical tape
b. Electrical cover
c. Any approved means
d. Safety cover
47. Branch circuits rated in excess of 20 amps require the use of heavy-duty
type lamp holders.
a. True b. False
48. Three kitchen unit loads in a restaurant have a demand factor of 90%.
a. True b. False
49. A school with electric space heating or air conditioning shall not have the
feeder or service load calculated
by using the optional calculation method.
a. True b. False
50. The maximum voltage drop for combined branch circuits and feeders
shall not exceed 3% of the circuit
voltage.
a. True b. False