Professional Documents
Culture Documents
AVS0680540T7321000C
PRP LTP
CONTINUOUS POWER: 610 kVA STAND-BY POWER: 665 kVA
PRP “Prime Power” norma ISO 8528-1 LTP “Limited Time Power” norma ISO 8528-1
ENGINE ALTERNATOR
MAKE MODEL MAKE MODEL
Rev.: 19/01/2021
SPAIN INTERNATIONAL
Phone: +34 968 380 129 Phone: +34 968 380 879
Fax: +34 968 380 504 Fax: +34 968 380 400
INMESOL, S.L. E-mail: ventas@inmesol.com E-mail: sales@inmesol.com www.inmesol.com
Ctra. de Fuente Álamo, 2 | 30153 Corvera - Murcia · SPAIN
ENG. These details shown on this data sheet are intended for guidance only. Inmesol reserves the right to change the details without prior notice. The present documents will not be part of any sales contract.
ESP. Estos datos son meramente orientativos y pueden ser cambiados por el fabricante sin previo aviso. Inmesol se reserva el derecho a efectuar cambios en las especificaciones de dicho material. El presente documento no formará parte del contrato de adquisición de bienes.
FRA. Ces données sont purement indicatives et peuvent être modifiées par le constructeur sans préavis. Inmesol a le droit d’apporter des modifications dans les spécifications du matériau. Ce document ne fait pas partie du contrat d’acquisition de biens. 1/8
Code:
AVS0680540T7321000C
ENGINE CHARACTERISTICS
MAKE MODEL
VOLVO TWD1643GE
General Data
Power PRP (kWm) 536
Power LTP (kWm) 596
No. cylinders 6
Cylinder capacity (L) 16.12
Diameter per stroke (mm) 144 x 165
Compression ratio 16.5
Cooling system LIQUID
Injection DIRECT
Suction TURBO-INTERC.
Series regulator ELECTRONIC
Fly wheel coupling 1-14
Lubrication system
Oil capacity (L) 48
Oil consumption (%) 0.08
Min. alarm oil pressure (bar) 2.2
Ventilation system
Air cooling flow (m3/h) 46800
Combustion air flow (m3/h) 2640
Max. back pressure for fan (mbar)
Exhaust system
Exhaust gas flow (m3/h) 6096
Exhaust back pressure (mbar) 100
Temp. exhaust gases (ºC) 450
Electrical system
VDC (V) 24
Battery (Ah) 2 x 180
Engine start-up (kW) 7
Rev.: 19/01/2021
SPAIN INTERNATIONAL
Phone: +34 968 380 129 Phone: +34 968 380 879
Fax: +34 968 380 504 Fax: +34 968 380 400
INMESOL, S.L. E-mail: ventas@inmesol.com E-mail: sales@inmesol.com www.inmesol.com
Ctra. de Fuente Álamo, 2 | 30153 Corvera - Murcia · SPAIN
ENG. These details shown on this data sheet are intended for guidance only. Inmesol reserves the right to change the details without prior notice. The present documents will not be part of any sales contract.
ESP. Estos datos son meramente orientativos y pueden ser cambiados por el fabricante sin previo aviso. Inmesol se reserva el derecho a efectuar cambios en las especificaciones de dicho material. El presente documento no formará parte del contrato de adquisición de bienes.
FRA. Ces données sont purement indicatives et peuvent être modifiées par le constructeur sans préavis. Inmesol a le droit d’apporter des modifications dans les spécifications du matériau. Ce document ne fait pas partie du contrat d’acquisition de biens. 2/8
Code:
AVS0680540T7321000C
ALTERNATOR CHARACTERISTICS
MAKE MODEL
STAMFORD HCI544E
General Data
Power PRP (kVA) 610
Power LTP (kVA) 665
Efficiency Alt. 100 % 94.9
Efficiency Alt. 110 % 94.5
No. Poles 4
Voltage regulator AS440
No. wires 12
Insulation H
Xd (%) 288
X’d (%) 15
X 11
Degree of protection IP23
75% 89
100% 120
DIMENSIONS, CAPACITIES,
APPROXIMATE WEIGHT
Dimensions (mm)
1023 4300
Rev.: 19/01/2021
SPAIN INTERNATIONAL
Phone: +34 968 380 129 Phone: +34 968 380 879
Fax: +34 968 380 504 Fax: +34 968 380 400
INMESOL, S.L. E-mail: ventas@inmesol.com E-mail: sales@inmesol.com www.inmesol.com
Ctra. de Fuente Álamo, 2 | 30153 Corvera - Murcia · SPAIN
ENG. These details shown on this data sheet are intended for guidance only. Inmesol reserves the right to change the details without prior notice. The present documents will not be part of any sales contract.
ESP. Estos datos son meramente orientativos y pueden ser cambiados por el fabricante sin previo aviso. Inmesol se reserva el derecho a efectuar cambios en las especificaciones de dicho material. El presente documento no formará parte del contrato de adquisición de bienes.
FRA. Ces données sont purement indicatives et peuvent être modifiées par le constructeur sans préavis. Inmesol a le droit d’apporter des modifications dans les spécifications du matériau. Ce document ne fait pas partie du contrat d’acquisition de biens. 3/8
Code:
AVS0680540T7321000C
The mobile elements, distribution belt, fan, etc., and those parts which reach high temperatures during operation,
exhaust manifold, etc, include their corresponding protections, in compliance with the requirements of the Machinery
Directive 2006/42.
INMESOL S.L company with ISO 9001 quality certification system for the:
Design, manufacture, marketing and technical assistance of power GENSETS,
lighting towers, welding GENSETS, tractor with PTO GENSET and hybrid generation
systems.
Rev.: 19/01/2021
SPAIN INTERNATIONAL
Phone: +34 968 380 129 Phone: +34 968 380 879
Fax: +34 968 380 504 Fax: +34 968 380 400
INMESOL, S.L. E-mail: ventas@inmesol.com E-mail: sales@inmesol.com www.inmesol.com
Ctra. de Fuente Álamo, 2 | 30153 Corvera - Murcia · SPAIN
ENG. These details shown on this data sheet are intended for guidance only. Inmesol reserves the right to change the details without prior notice. The present documents will not be part of any sales contract.
ESP. Estos datos son meramente orientativos y pueden ser cambiados por el fabricante sin previo aviso. Inmesol se reserva el derecho a efectuar cambios en las especificaciones de dicho material. El presente documento no formará parte del contrato de adquisición de bienes.
FRA. Ces données sont purement indicatives et peuvent être modifiées par le constructeur sans préavis. Inmesol a le droit d’apporter des modifications dans les spécifications du matériau. Ce document ne fait pas partie du contrat d’acquisition de biens. 4/8
Code:
AVS0680540T7321000C
SB STAND-BY
RANGE Scope of supply
Engine/alternator monobloc directly conected and installed via silent blocks on a frame made from high tensile electro welded steel profiles that
are treated with degreasing liquids and aplicated with a phosphate coat and Polyester (QUALICOAT) paint.
Fuel tank integrated in the chassis provided with fuel level gauge and fuel lines to the engine.
Engine with mechanical engine driven pusher fan.
Industrial silencer with -15 db(A) noise reduction and exhaust outlet tube.
Termal and magnetic circuit breaker
Battery charge alternator.
Starter battery complete with cables to the engine and pole protection.
Installation prepared for earthing spike (spike not included).
Security protection for blets and moving parts as well as on electrical component.
External emergency stop push button.
Self excited and auto regulated alternator.
4 Lifting points for gen sets from 450 kVA and bigger.
Base frame preparated for trailer kit
Standard electronic speed governor on engines
Electric control cubicle with digital control module, automatic mains failure, manual start or remote start on signal with change over switch in the
same cabinet.
Battery charger for gen set with 12VCC battery (3A).
Battery charger for gen set with 24VCC battery (5A).
Electric engine coolant preheating.
Control cable of 6 m
OPTIONS
Eearth fault relay
Residential silencer
Rev.: 19/01/2021
SPAIN INTERNATIONAL
Phone: +34 968 380 129 Phone: +34 968 380 879
Fax: +34 968 380 504 Fax: +34 968 380 400
INMESOL, S.L. E-mail: ventas@inmesol.com E-mail: sales@inmesol.com www.inmesol.com
Ctra. de Fuente Álamo, 2 | 30153 Corvera - Murcia · SPAIN
ENG. These details shown on this data sheet are intended for guidance only. Inmesol reserves the right to change the details without prior notice. The present documents will not be part of any sales contract.
ESP. Estos datos son meramente orientativos y pueden ser cambiados por el fabricante sin previo aviso. Inmesol se reserva el derecho a efectuar cambios en las especificaciones de dicho material. El presente documento no formará parte del contrato de adquisición de bienes.
FRA. Ces données sont purement indicatives et peuvent être modifiées par le constructeur sans préavis. Inmesol a le droit d’apporter des modifications dans les spécifications du matériau. Ce document ne fait pas partie du contrat d’acquisition de biens. 5/8
Code:
AVS0680540T7321000C
PROTECTION, DISTRIBUTION AND AUTOMATIC CONTROL panel which starts the generator set when it detects
a mains failure and stops it when the mains is restored with the control unit DSE 7320 MKII. It incorporates change
over switch. The entire assembly is in a steel enclosure separated from the gen set.
3. BATTERY CHARGER
PREWIRED GENSET READY TO GENSET WITH AMF CONTROL PANEL GENSET WITH AMF CONTROL PANEL WHITOUT TRANSFER SWITCH.
INSTALL AMF CONTROL PANEL. WITH TRANSFER SWITCH. READY TO ADD SEPARATED LTS PANEL.
Rev.: 19/01/2021
ESPAÑA INTERNATIONAL
Teléfono: +34 968 380 129 Phone: +34 968 380 879
Fax: +34 968 380 504 Fax: +34 968 380 400
INMESOL, S.L. E-mail: ventas@inmesol.com E-mail: sales@inmesol.com www.inmesol.com
Ctra. de Fuente Álamo, 2 | 30153 Corvera - Murcia · SPAIN
ENG. These details shown on this data sheet are intended for guidance only. Inmesol reserves the right to change the details without prior notice. The present documents will not be part of any sales contract.
ESP. Estos datos son meramente orientativos y pueden ser cambiados por el fabricante sin previo aviso. Inmesol se reserva el derecho a efectuar cambios en las especificaciones de dicho material. El presente documento no formará parte del contrato de adquisición de bienes.
FRA. Ces données sont purement indicatives et peuvent être modifiées par le constructeur sans préavis. Inmesol a le droit d’apporter des modifications dans les spécifications du matériau. Ce document ne fait pas partie du contrat d’acquisition de biens. 6/8
Code:
AVS0680540T7321000C
OTHER CHARACTERISTICS:
Programmer Clock with multiple maintenance
The real-time clock provides events which can be configured for the optimal
Fully configurable via software and PC.
an exact record of events. operation of the engine. Weekly and/or monthly
programming of up to 16 starts and stops per week.
Extensive number of configurable ALTERNATIVE CONFIGURATIONS, which
Modbus RTU
inputs and outputs. open up the working possibilities
Configurable alarms and timers. Possibility of SMS text messages Enhanced PLC functionality.
Ethernet communication and
USB connectivity simultaneous use of RS232 Data logging function
and RS 485 ports
The fuel consumption may be monitored
on the screen and SMS messages with
alarms and reports may be sent.
PREWIRED GENSET READY TO GENSET WITH AMF CONTROL PANEL GENSET WITH AMF CONTROL PANEL WHITOUT TRANSFER SWITCH.
INSTALL AMF CONTROL PANEL. WITH TRANSFER SWITCH. READY TO ADD SEPARATED LTS PANEL.
Rev.: 19/01/2021
ESPAÑA INTERNATIONAL
Teléfono: +34 968 380 129 Phone: +34 968 380 879
Fax: +34 968 380 504 Fax: +34 968 380 400
INMESOL, S.L. E-mail: ventas@inmesol.com E-mail: sales@inmesol.com www.inmesol.com
Ctra. de Fuente Álamo, 2 | 30153 Corvera - Murcia · SPAIN
ENG. These details shown on this data sheet are intended for guidance only. Inmesol reserves the right to change the details without prior notice. The present documents will not be part of any sales contract.
ESP. Estos datos son meramente orientativos y pueden ser cambiados por el fabricante sin previo aviso. Inmesol se reserva el derecho a efectuar cambios en las especificaciones de dicho material. El presente documento no formará parte del contrato de adquisición de bienes.
FRA. Ces données sont purement indicatives et peuvent être modifiées par le constructeur sans préavis. Inmesol a le droit d’apporter des modifications dans les spécifications du matériau. Ce document ne fait pas partie du contrat d’acquisition de biens. 7/8
Code:
AVS0680540T7321000C
5. PROTECTIONS
MAGNETO. PROTECTION (A) EARTH LEAK PROTECTION DISTRIBUTION AMF/ATS PANEL
PREWIRED GENSET READY TO GENSET WITH AMF CONTROL PANEL GENSET WITH AMF CONTROL PANEL WHITOUT TRANSFER SWITCH.
INSTALL AMF CONTROL PANEL. WITH TRANSFER SWITCH. READY TO ADD SEPARATED LTS PANEL.
Rev.: 19/01/2021
ESPAÑA INTERNATIONAL
Teléfono: +34 968 380 129 Phone: +34 968 380 879
Fax: +34 968 380 504 Fax: +34 968 380 400
INMESOL, S.L. E-mail: ventas@inmesol.com E-mail: sales@inmesol.com www.inmesol.com
Ctra. de Fuente Álamo, 2 | 30153 Corvera - Murcia · SPAIN
ENG. These details shown on this data sheet are intended for guidance only. Inmesol reserves the right to change the details without prior notice. The present documents will not be part of any sales contract.
ESP. Estos datos son meramente orientativos y pueden ser cambiados por el fabricante sin previo aviso. Inmesol se reserva el derecho a efectuar cambios en las especificaciones de dicho material. El presente documento no formará parte del contrato de adquisición de bienes.
FRA. Ces données sont purement indicatives et peuvent être modifiées par le constructeur sans préavis. Inmesol a le droit d’apporter des modifications dans les spécifications du matériau. Ce document ne fait pas partie du contrat d’acquisition de biens. 8/8