Professional Documents
Culture Documents
WPHS
Chemistry
Unit 5 Packet
Stoichiometry
Bergmann-Sams
-1-
Name
-2-
Name
Unit 5: Vocabulary
Stoichiometry
Theoretical yield
Actual yield
Percent yield
-3-
Name
Representative
Particles of A Stoichiometry Flowchart Representative
Particles of B
Avogadro’s # Avogadro’s #
Grams of A Grams of B
22.4 L 22.4 L
L of gas A at L of gas B at
STP PV = nRT STP
PV = nRT
Gas B not at
Gas A not at
STP
STP
-4-
Name
Ingredients:
To a 2-L jacketed round reactor vessel (reactor #1) with an overall heat-transfer coefficient of about 100
Btu/F-ft2-hr add one, two, and three with constant agitation.
In a second 2-L reactor vessel with a radial flow impeller operating at 100 rpm add four, five, six, and seven
until the mixture is homogeneous.
To reactor #2 add eight followed by three equal portions of the homogeneous mixture in reactor #1.
Additionally, add nine and ten slowly with constant agitation. Care must be taken at this point in the reaction
to control any temperature rise that may be the result of an exothermic reaction.
Using a screw extrude attached to a #4 nodulizer place the mixture piece-meal on a 316SS sheet (300 x 600
mm). Heat in a 460K oven for a period of time that is in agreement with Frank & Johnston's first order rate
expression (see JACOS, 21, 55), or until golden brown.
Once the reaction is complete, place the sheet on a 25ºC heat-transfer table allowing the product to come to
equilibrium.
Conversion Factors
1 teaspoon = 5cm3
235 cm3 = 1 cup
ºC = 9/5ºF +32
-5-
Name
To Receive Credit: You must have a signed note from your parent/guardian that indicates that you made the
cookies –you can even bring in a sample to your friendly Chemistry Teacher.
-6-
Name
PROBLEMS: Use dimensional analysis to set up the problem. Please show your work!
1. Show your work here for how much of each item you need to measure out at home:
3. If you only have 100cm3 of unrefined C12H22O11, how much gluten will you need?
4. You have decided with a group of friends to make these cookies for a fund raiser. It is your job to
make 1000 cookies. How many calcium carbonate-encapsulated avian albumen-coated protein will
you need to buy?
5. Adjust the recipe for 3 calcium carbonate-encapsulated avian albumen-coated protein and determine
how much of each reactant you need in the recipe.
-7-
Name
SAFETY
2M sulfuric acid can cause burns. Avoid skin and eye contact. Rinse spills with plenty of
water.
PROCEDURE
1. Obtain a beral pipet containing 2M H2SO4.
2. Obtain a clean, dry flask. Measure and record its mass.
Place approximately 0.30g of NaHCO 3 into the flask.
Find the combined mass of the flask and sodium
bicarbonate and record.
3. Determine the exact mass of sodium bicarbonate by
subtraction. This mass must be between 0.20 and 0.40
g. Record the mass of sodium bicarbonate in a data
table.
4. Record the TOTAL mass of all the components of the
lab: sodium bicarbonate, flask, dropper and sulfuric
acid.
5. SLOWLY, drop by drop, add the sulfuric acid to the
sodium bicarbonate to generate carbon dioxide gas.
Continue releasing the acid in this manner until gas
production ceases.
6. Measure and record the TOTAL mass of all the
components again (like in step 4).
7. Return the beral pipet with the remainder of the sulfuric
acid. Rinse the contents of the flask down the drain
with water. Clean up your lab station.
DATA
Construct a data table for each reaction to display your laboratory measurements. Make sure that
each value is clearly labeled.
-8-
Name
ANALYSIS
1. Write a balanced equation for the reaction.
3. Using the balanced equation, calculate the mass of carbon dioxide that should be produced
from the mass of sodium bicarbonate that you used (“theoretical yield”).
CONCLUSIONS
Calculate the percent yield of the carbon dioxide using the equation below (show your work).
experimental yield
% yield = 100
theoretical yield
A perfect percent yield would be 100%. Comment on your degree of accuracy and suggest
possible sources of measurement error. How could these errors be reduced in the future?
-9-
Name
Introduction:
In this lab you will do a cool reaction, make some measurements, make a graph, and then
write down some observations. The reaction that you will do is the reaction between
vinegar and baking soda. In this reaction, carbon dioxide, CO2 will be produced. Chemists
use chemical symbols to show the reaction. The reaction is:
Materials:
Apparatus as pictured below
Vinegar
Baking Soda
To simplify: Here is a picture of what you will need:
Procedure:
Follow this procedure as closely as possible.
1. place 0.25 g into a paper towel
2. Get the appropriate amount of vinegar into the flask
3. Set-up the apparatus—and mix.
4. Record the amount of CO2 collected
- 10 -
Name
Data
Fill out the following data table:
Amount of vinegar Amount of baking Vol CO2
soda
1 1 mL 0.25g
2 2 mL 0.25g
3 3 mL 0.25g
4 4 mL 0.25g
5 5 mL 0.25g
6 6 mL 0.25g
Questions
1. Describe in detail what occurred (your observations) when the vinegar was
mixed with the baking soda. Some descriptive words that you should probably
use are, but not including (gas given off, fizzing, foaming, balloon expanding)
2. Describe the pattern of how much carbon dioxide, CO2 was formed as you
added more and more vinegar. Relate this to the graph.
3. For each trial: explain which substance was the limiting and excess reagent.
Explain how you were able to determine this.
4. You should have noticed that as you increased the amount of vinegar eventually
you got the same amount of carbon dioxide, CO2. Explain why that occurred.
- 11 -
Name
- 12 -
Name
- 13 -
Name
Chemistry
Limiting Reactant Lab
Introduction
A limiting reactants is defined as one of the reactants in a chemical reaction that will be
used up first. The purpose of this lab is to determine the amount of precipitate that will be
produced when a given amount of calcium chloride and sodium sulfate are mixed.
Once you have massed the calcium chloride and the sodium sulfate you will need to do
each of the following before you proceed with the rest of the experiment.
Write the balanced chemical reaction noting the states of matter for all substances.
(See solubility chart to determine which substance precipitates.)
Determine which reagent, calcium chloride or sodium sulfate, is limiting.
Predict the amount of the precipitate that will be produced.
Once you have done these three things, show them to your instructor. Then you may begin
the experiment.
Procedure
1. Label and mass a test tube. The test tube must be completely dry
2. Obtain about 0.30 grams of each reagent (It doesn’t matter how much you get just
as long as you know exactly how much you obtain), and determine both which
reagent is limiting and how much precipitate you will discover.
3. Dissolve the calcium chloride into 3 mL of deionized water by carefull flicking the
test tube (Your instructor will show you how to do this. Dissolve the sodium sulfate
into 3-mL of deionized water.
4. Pour the sodium sulfate solution into the test tube with calcium chloride in it.
Take care to get all of the sodium sulfate into the calcium chloride test tube.
5. Remove the stopper and then place your sample into a centrifuge and spin out the
precipitate. (Caution should be used in using this device. Your teacher will instruct
you on proper use of a centrifuge)
6. Decant, or pour off, the liquid (supernatant) above the precipitate. Be careful not to
allow any of the precipitate to be poured out.
7. Add about 10-mL of deionized water to your precipitate and spin it again. Decant
again and repeat this step two more times for a total of four centrifuges
8. SHOW YOUR PRODUCT TO YOUR TEACHER AND GET HIS SIGNATURE.
Set your labeled test tube into a drying oven overnight.
9. Weigh your test tube and determine the mass of the precipitate that you have.
SHOW YOUR PRODUCT TO YOUR TEACHER AND GET HIS SIGNATURE
AGAIN. Compare this amount to what you expected to get from your calculations.
- 14 -
Name
Calculations
Show all calculations needed to determine the expected amount of precipitate
required to do the experiment. This should include the balanced chemical reaction and all
appropriate stoichiometric calculations.
Questions
1. Why did you have to mass the test tube prior to beginning the experiment?
2. Why did you need to add water to the solid calcium chloride and solid sodium
sulfate to cause the reaction to occur?
5. Draw a picture of the two test tubes prior to adding the two chemicals. What had
happened to the calcium chloride? What happened to the sodium sulfate.
6. Now draw a picture of the test tube once you have mixed the two chemicals.
Where are all of the chemicals now? Label this in your diagram.
- 15 -
Name
b. How many moles of carbon are needed to react with 7.24 moles of SO2
4. Car batteries are called lead storage batteries because of their use of large quantities of
lead. These batteries utilize the following equation.
Pb + PbO2 +2H+ + 2HSO4- 2PbSO4 + 2 H2O
Assuming the same mass of PbO2, how many grams of PbSO4 will be formed?
- 16 -
Name
5. Ammonia, (NH3) is produced by reacting its elements with each other according to the
following equation:
___N2 + ___H2 ___NH3
Balance the equation.
If 34.3-L of nitrogen is reacted with hydrogen, how many liters at STP of
ammonia will be formed?
6. 32.5-g of ZnSO4 reacts to form how many grams of BaSO4 according to the following
equation. Don’t forget to balance the equation.
___ZnSO4 + ___BaCl2 ___BaSO4 + ___ZnCl2
7. When sodium metal is added to water the resulting gas, Hydrogen can often explode.
How many Liters of hydrogen gas is produced when 41.2-g of sodium is dropped into
water. Again, you must balance the equation in order to solve the problem.
___Na + ___HOH ___NaOH + ___H2
8. Propane is a gas used often for backyard grills. How many Liters of CO2 is produced
when 54.9-L of propane (C3H8) is burned according to the following equation. Again, you
must balance the equation in order to solve the problem.
___C3H8 + ___O2 ___CO2 + ___H2O
- 17 -
Name
1. How many moles of Carbon dioxide is formed when 44-mol of CH4 is burned?
2. 43.5-grams of barium sulfate is formed from the reaction of barium nitrate and
sodium sulfate. How many moles of sodium sulfate reacted?
4. 22.8-g of NaOH is reacted with hydrochloric acid. How many grams of water is
formed?
5. 32.5-grams of iron III chloride reacts with silver nitrate. How many grams of silver
chloride are formed?
- 18 -
Name
6. 43.5-grams of copper II sulfate is reacted with barium nitrate. How many grams of
precipitate are formed?
7. How many liters of hydrogen gas is formed when 13.5-grams of calcium reacts with
sulfuric acid (H2SO4)?
8. Calculate the mass of silver needed to react with chlorine to produce 84 g of silver
chloride.
9. A volume of 7.5 L of hydrogen gas was produced from the single replacement
reaction of zinc and nitric acid (HNO3). Calculate the mass of zinc needed for this
reaction.
10. How many molecules of chlorine are needed to react with 5.6 g of iron to form iron
III chloride?
- 19 -
Name
d. How much excess reagent is left over at the end of the experiment?
d. How much excess reagent is left over at the end of the experiment?
- 20 -
Name
d. How much excess reagent is left over at the end of the experiment?
4. 22.5 grams of lithium reacts with 33.5 grams of aqueous aluminum sulfate. This is a
single replacement reaction.
a. Write a balanced equation.
d. How much excess reagent is left over at the end of the experiment?
- 21 -
Name
5. 33.6 grams of sulfur dioxide reacts with 55.3 grams of water to form sulfurous acid
(H2SO3).
a. Write a balanced equation.
d. How much excess reagent is left over at the end of the experiment?
d. How much excess reagent is left over at the end of the experiment?
- 22 -
Name
1. 15.5-g of NH4Cl reacts with an excess of AgNO3. In the reaction 35.5-g AgCl is
produced. NH4NO3 is the other product. What is the percent yield?
3. Nitrogen gas reacts with hydrogen gas to make ammonia (NH3). 15.5-L of N2 reacts at
STP to make 30-L of ammonia. What is the percent yield?
4. What is the percent yield of oxygen gas if 54L of O2 can be obtained from the
thermal decomposition of 500.0 g of potassium chlorate?
KClO3 KCl + O2
- 23 -
Name
6. When black gunpowder explodes, potassium nitrate, carbon, and sulfur react with each
other to form nitrogen gas, carbon dioxide gas, and solid potassium sulfide. If the original
mixture contains 50.0 g of potassium nitrate, if the total volume of the gases is 20L, then
what is the percent yield for this process?
7. Very hot zinc will react with steam to form zinc oxide and hydrogen. 5.4L of H2 was
used to use up 20.0 g of zinc completely? What is the percent yield of this process?
- 24 -
Name
1. 2.35g of metal with a charge of +2 reacts with hydrochloric acid to produce 0.598 L
of gas at STP. What metal do you have?
M + HCl MCl2 + H2
3. 3.45g of a metal hydroxide with charge + 1 reacts with excess Iron III Chloride to
make 0.82g of Iron III hydroxide. What is the identity of the metal hydroxide?
- 25 -
Name
Unit 5 Reviewsheet
1. How many grams of water are formed when 12.5-g of hydrogen reacts with oxygen?
2. How many liters of carbon dioxide are formed when 12.3-g of sodium carbonate reacts
with 2.0-L of hydrogen chloride. The reaction is printed below:
___Na2CO3 + ___HCl ___NaCl + ___H2O + ___CO2
3. How many grams of precipitate are formed when 24.3-g of zinc nitrate reacts with 20.5-
g of sodium phosphate?
4. How many liters of oxygen are produced when 3.25-g of KClO3 decomposes into KCl
and O2?
- 26 -
Name
5. When 2.25-g of sodium chloride reacts with excess silver nitrate, 3.45-g of precipitate is
formed. What is the percent yield of the precipitate?
7. 3.0-g of zinc reacts with silver nitrate to form how many grams of zinc nitrate?
8. 8.2-mol of barium carbonate decomposes into how many moles of barium oxide. The
other product is carbon dioxide.
- 27 -
Name
9. 4.5-g of sodium hydroxide reacts with 2.0-g of sulfuric acid (H2SO4). How many grams
of water are formed?
10. 8.0-L of butane (C4H10) reacts with oxygen to make 50-g of carbon dioxide. What is
the percent yield?
12.A 2.25-g sample of aluminum sulfate reacts with 3.25-g of sodium phosphate to make
1.0-g of precipitate. What is the percent yield?
- 28 -
Name
- 29 -
Name
4. Car batteries are called lead storage batteries because of their use of large quantities of
lead. These batteries utilize the following equation.
Pb + PbO2 +2H+ + 2HSO4- 2PbSO4 + 2
H2O
34.3g
g?
If 34.3-g of PbO2 react how many grams of water will be formed?
Assuming the same mass of PbO2, how many grams of PbSO4 will be formed?
5. Ammonia, (NH3) is produced by reacting its elements with each other according to the
following equation:
N2 + 3H2 2NH3
34.3L L?
Balance the equation.
If 34.3-L of nitrogen is reacted with hydrogen, how many liters at STP of
ammonia will be formed?
6. 32.5-g of ZnSO4 reacts to form how many grams of BaSO4 according to the following
equation. Don’t forget to balance the equation.
- 30 -
Name
7. When sodium metal is added to water the resulting gas, Hydrogen can often explode.
How many Liters of hydrogen gas is produced when 41.2-g of sodium is dropped into
water. Again, you must balance the equation in order to solve the problem.
8. Propane is a gas used often for backyard grills. How many Liters of CO2 is produced
when 54.9-L of propane (C3H8) is burned according to the following equation. Again, you
must balance the equation in order to solve the problem.
- 31 -
Name
Stoichiometry WS B Name
Period
1. How many moles of Carbon dioxide is formed when 44-mol of CH4 is burned?
+4
2. How many moles of calcium phosphate is formed when 32.5-mols of calcium nitrate
reacts with sodium phosphate?
3. 43.5-grams of barium sulfate is formed from the reaction of barium nitrate and sodium
sulfate. How many moles of sodium sulfate reacted?
- 32 -
Name
5. 2.5-mol of water is made from its elements. How many particles of hydrogen reacted?
6. 22.8-g of NaOH is reacted with hydrochloric acid. How many grams of water is
formed?
7. 32.5-grams of iron III chloride reacts with silver nitrate. How many grams of silver
chloride are formed?
8. 34.5-grams of Lithium reacts with Chromium III chloride. How many grams of lithium
chloride is formed?
- 33 -
Name
9. 43.5-grams of copper II sulfate is reacted with barium nitrate. How many grams of
precipitate are formed?
10 How many liters of hydrogen gas is formed when 13.5-grams of calcium reacts with
sulfuric acid?
11. 45.6-L of H2 is formed when zinc is reacted with nitric acid. How many grams of zinc
reacted?
- 34 -
Name
12. 14.5-g of cesium explosively reacts with water to form hydrogen and cesium
hydroxide. How many molecules of hydrogen were formed?
13. Calculate the mass of silver needed to react with chlorine to produce 84 g of silver
chloride.
2Ag + Cl2 2AgCl
? 84g
14. A volume of 7.5 L of hydrogen gas was produced from the single replacement reaction
of zinc and nitric acid (HNO3). Calculate the mass of zinc needed for this reaction.
Zn + 2HCl ZnCl2 + H2
g? 7.5L
15. How many molecules of chlorine are needed to react with 5.6 g of iron to form iron III
chloride?
3Cl2 + 2Fe 2FeCl3
Molec? 5.6g
16. What mass of ammonia, NH3, is necessary to react with 2.1 x 1024 molecules of oxygen
when ammonia (NH3) reacts with oxygen to form water and nitrogen dioxide?
4NH3 + 7O2 4NO2 + 6H2O
g? 2.1 x 10 molec
24
- 35 -
Name
17. Calculate the volume of carbon dioxide produced when 250 g of pentane, C5H12, burn.
Assume the carbon dioxide is cooled to STP.
C5H12 + 8O2 5CO2 + 6H2O
250g ?L
18. Nitrogen gas reacts with oxygen to form dinitrogen trioxide. How many molecules of
oxygen are needed to make 5.5 L of N2O3 at STP?
2N2 + 3O2 2N2O3
molec? 5.5L
19. Silver Nitrate reacts with sodium chloride to make the silver chloride and sodium
nitrate. When 2.53 grams of silver nitrate is reacted. How many grams of silver chloride
are formed?
AgNO3 + NaCl AgCl + NaNO3
2.53g ?g
- 36 -
Name
20. Methane (CH4) is burned in air. When 50.6 L of methane is burned how many grams
of carbon dioxide will be formed?
CH4 + 2O2 CO2 + 2H2O
50.6L ?g
21. Calcium Carbonate decomposes into calcium oxide and a common gas. When 45.5
grams of calcium oxide is formed how many liters of gas is also formed from this reaction.
CaCO3 CaO + CO2
45.5g ?L
22. When 3.25 g of copper II nitrate reacts with ammonium hydroxide. How many grams
of the precipitate will form.
Cu(NO3)2 + 2NH4OH Cu(OH)2 (s) + 2NH4NO3 (aq)
3.25g ?g=ppt
+88
- 37 -
Name
1. When 114.0 g of iron and 292.7 g of chlorine gas reacts, iron(III) chloride is formed.
a. Write a balanced equation
b. What is the limiting reactant?
c. How many grams of Iron (III) chloride is formed
a. How much excess reagent is left over at the end of the experiment?
- 38 -
Name
4. 22.5 grams of lithium reacts with a 33.5 grams of aqueous aluminum sulfate according
to a single replacement reaction.
a. Write a balanced equation.
b. What is the limiting reactant?
c. How many grams of lithium sulfate will be formed?
d. How much excess reagent will remain?
- 39 -
Name
5. 33.6 grams of sulfur dioxide reacts with 55.3 grams of water to form sulfurous acid.
a. Write a balanced equation.
b. What is the limiting reactant?
c. How many grams of sulfurous acid will be formed?
d. How much excess reagent will remain?
- 40 -
Name
- 41 -
Name
1. 15.5-g of NH4Cl reacts with an excess of AgNO3. In the reaction 35.5-g AgCl is
produced. NH4NO3 is the other product. What is the percent yield?
NH4Cl + AgNO3 AgCl + NH4NO3
15.5g 35.5g
3. Nitrogen gas reacts with hydrogen gas to make ammonia (NH3). 15.5-L of N2 reacts at
STP to make 30-L of ammonia. What is the percent yield?
N2 + 3H2 2NH3
15.5L 30L
- 42 -
Name
4. The Haber and Caude processes are methods by which ammonia (NH3) is synthesized
from its elements (H2 and N2) What is the percent yield if 5.0-kg of ammonia (in
Kilograms) is to be expected when 4000.0 L of nitrogen are used in these procedures?
5. What is the percent yield of oxygen gas if 54L of O2 can be obtained from the thermal
decomposition of 500.0 g of potassium chlorate?
- 43 -
Name
7. When black gunpowder explodes, potassium nitrate, carbon, and sulfur react with each
other to form nitrogen, carbon dioxide, and potassium sulfide. If the original mixture
contains 50.0 g of potassium nitrate, if the total volume of the gases is 20L, what is the
percent yield for this process?
8. Very hot zinc will react with steam to form zinc oxide and hydrogen. 5.4L of H2 was
used to use up 20.0 g of zinc completely? What is the percent yield of this process?
- 44 -
Name
1. 2.35g of metal with a charge of +2 reacts with hydrochloric acid to produce 0.598
L of gas at STP. What metal do you have?
- 45 -
Name
3. 3.45g of a metal hydroxide with charge + 1 reacts with excess Iron III Chloride to
make 0.82g of Iron III hydroxide. What is the identity of the metal hydroxide?
- 46 -
Name
1. How many grams of water are formed when 12.5-g of hydrogen reacts with oxygen?
2H2 + O2 2H2O
12.5g ?g
2. How many liters of carbon dioxide are formed when 12.3-g of sodium carbonate reacts
with 2.0-L of hydrogen chloride. The reaction is printed below:
Na2CO3 + HCl NaCl + H2O + CO2
Na2CO3 + 2HCl 2NaCl + H2O + CO2
12.3g 2.0L L?
3. How many grams of precipitate are formed when 24.3-g of zinc nitratre reacts with
20.5-g of sodium phosphate?
3Zn(NO3)2 + 2Na3PO4 Zn3(PO4)2 + 6NaNO3
24.3g 20.5g ?g (ppt)
- 47 -
Name
4. How many liters of oxygen are produced when 3.25-g of KClO3 decomposes into KCl
and O2?
2KClO3 2KCl + 3O2
3.25g L?
5. When 2.25-g of sodium chloride reacts with excess silver nitrate, 3.45-g of precipitate is
formed. What is the percent yield?
NaCl + AgNO3 AgCl + NaNO3
2.25g 3.45g
7. 3.0-g of zinc reacts with silver nitrate to form how many grams of zinc nitrate?
Zn + 2AgNO3 Zn(NO3)2 + 2Ag
3.0g ?grams?
- 48 -
Name
8. 8.2-mol of barium carbonate decomposes into how many moles of barium oxide. The
other product is carbon dioxide.
BaCO3 BaO + CO2
8.2mol ?mol
9. 4.5-g of sodium hydroxide reacts with 2.0-g of sulfuric acid (H2SO4). How many grams
of water are formed?
2NaOH + H2SO4 2HOH + Na2SO4
4.5g 2.0g G?
10. 8.0-L of butane (C4H10) reacts with oxygen to make 50-g of carbon dioxide. What is
the percent yield?
2C4H10 + 13O2 8CO2 + 10H2O
8.0L 50g
- 49 -
Name
12. ** 2.25-g of aluminum sulfate reacts with 3.25-g of sodium phosphate to make 1.0-g
of precipitate. What is the percent yield?
Al2(SO4)3 + 2Na3PO4 2AlPO4 + 3Na2SO4
2.25g 3.25g 1.0g
- 50 -
Name
Chapter 10 Review
EHS Chemistry
2. In the reaction:
Na2CO3 + H3PO4 Na3PO4 + H2O + CO2
How many grams of Na2CO3 react with the H3PO4 to produce 100L of CO2 at STP?
3. Mercury (II) oxide decomposes to form liquid mercury and oxygen gas. If 5.4 g of
mercury (II) oxide decomposes, how many grams of mercury is formed? (Hint: You must
start with a correctly balanced chemical reaction)
4. 2.5-g of C4H10 reacts with 0.59-L of O2 at STP to form CO2 and H2O.
a. Write the balanced equation.
b. How many grams of H2O will be formed?
c. How much excess reactant remains?
6. 32.5-g of Hg(NO3)2 reacts with NH4Cl to make HgCl2 and NH4NO3. When the
chemicals were mixed it was discovered that 20.0-g of HgCl2 was formed. What is the
percent yield?
7. BONUS: 2.52x1025 atoms of sodium react with 325-L of phosphoric acid gas (H3PO4)
at STP. 302.5-L of a gas is given off. What is the percent yield of the reaction?
- 51 -
Name
2. In the reaction:
Na2CO3 + H3PO4 Na3PO4 + H2O + CO2
How many grams of Na2CO3 react with the H3PO4 to produce 100L of CO2 at STP?
3Na2CO3 + 2H3PO4 2Na3PO4 + 3HOH + 3CO2
?g 100L
3. Mercury (II) oxide decomposes to form liquid mercury and oxygen gas. If 5.4 g of
mercury (II) oxide decomposes, how many grams of mercury is formed? (Hint: You must
start with a correctly balanced chemical reaction)
2HgO 2Hg + O2
5.4g ?g
- 52 -
Name
4. 2.5-g of C4H10 reacts with 0.59-L of O2 at STP to form CO2 and H2O.
a. Write the balanced equation.
b. How many grams of H2O will be formed?
c. How much excess reactant remains?
2C4H10 + 13O2 8CO2 + 10H2O
2.5g 0.59L ?g
6. 32.5-g of Hg(NO3)2 reacts with NH4Cl to make HgCl2 and NH4NO3. When the
chemicals were mixed it was discovered that 20.0-g of HgCl2 was formed. What is the
percent yield?
- 53 -
Name
7. BONUS: 2.52x1025 atoms of sodium react with 325-L of phosphoric acid gas (H3PO4)
at STP. 302.5-L of a gas is given off. What is the percent yield of the reaction?
6Na + 2H3PO4 2Na3PO4 + 3H2
2.52E25 325L 302.5L
- 54 -
Name
2. 2.35g of metal with a charge of +2 reacts with hydrochloric acid to produce 0.598
L of gas at STP. What metal do you have?
- 55 -
Name
3. 3.45g of a metal hydroxide with charge + 1 reacts with excess Iron III Chloride to
make 0.82g of Iron III hydroxide. What is the identity of the metal hydroxide?
- 56 -