Professional Documents
Culture Documents
Contents 2
2. Training Area Setup with S7-1200 ......................................................................... 2-2
2.1. Configuration of the S7-1200 Training Device ...................................................................... 2-3
2.2. Simulator Setup..................................................................................................................... 2-4
2.3. Conveyor Model Setup ......................................................................................................... 2-5
2.4. Training Area as Plant with Distribution Conveyor and Touchpanel .................................... 2-6
Modules
The module addresses shown in the picture will be assigned in the chapter "Devices and
networks".
4711
DI 0V
I 0.0 S_Operat.ON
I 0.1 S_Operat.OFF -10V +10V
(NC) Poti
I 0.2 S_Right
I 0.3 S_Left
DO
P_Operation Q 4.1
Simulator Setup:
Together with the touchpanel, the simulator is used to operate the plant. It contains the following
components:
• 14 switches, whereby the switch "S_OperationOFF" (I 0.1) is an NC contact
• 10 LEDs
• Potentiometers for specifying or simulating analog input signals
• Voltmeter for displaying the voltage set on the potentiometer
Addressing
For the addressing shown in the picture, the relevant address settings must be made in the
device configuration.
"Horn"
(Q 8.7)
"B_Bay1" "B_Bay2" "B_Bay3" "B_BayLB"
(I 8.5) (I 8.6) (I 8.7) (I 8.0)
"K_Left" (Q 8.6)
"K_Right" (Q 8.5)
Setup
The picture shows the sensors and actuators of the conveyor model as well as the I/O addresses
to which they are connected.
DI 0V
I 0.0 S_Operat.ON
I 0.1 S_Operat.OFF -10V +10V
(NC) Poti
I 0.2 S_Right
I 0.3 S_Left
DO
PN
P_Operation Q 4.1
AI / AO DI/ DO
Industrial
Ethernet