You are on page 1of 6

1.What is the maximum output power of a cellular transmitter?

a.60 watts
b.3 watts
c.6 watts
d.30 watts

2.A plate electrode must expose not less than_____sq.m.of surface to the soil.

a.1/2
b.1/4
c.1/3
d.1/5

3.Which of these is not an objective of GRID planning?

a.generating capacity
b.timing
c.type of circuit
d.voltage

4.In the differential current protection system,the current transformer secondaries of


wyo-delia power transformers will be in

a.delta-wye
b.delta-delta
c.wye-wye
d.wye-delta

5.The amount of frequency.deviation from the camricr center of frequency in an FM


transmitter is proportional the

a.shape
b.amplitude
c.frequency
d.phase

6._____time is the total time it takes a fuse to interrupt a circuit at a certain fault current
level.

a.melting
b.arcing
c.total cleaning
d.closing

7.The varmeter, in conjunction with other meter device can be used to determine the factor.

a.load
b.diversity
c.power
d.capacity

8. Which device automatically trips and recluses a preset number of times to clear temporary
faults or isolate permanent faults?

a.sectionalizer
b.oil switch
c.circuit breaker
d. circuit recloser

9.An electromagnetic device used for finding short circuited coil is called a/am

a hi-pot
b.ohmmeter
c.growler
d.megger

10.Dwelling receptacles located


m above floors are NOT counted in the required number of receptacles along the wall.

a.1.7
b.1.8
c.1.6
d.1.5

11.The branch circuit conductors for a resistance heater and motor unit must be rated at
what percent of the load?

a.115% of the total load


b.125% of the total load
c.125% of the motor Íoad plus 10% of the heating load
d.100% of the total load

12.Which of the following is not type of the contactor for circuit breaker?

a.pneumatic
b.vacuum
c.electro-pneumatic
d.electromagnetic

13.An energy of 10.152 x10" J is equal to


quad.

a.9.623
b.96.23
c.962.3
d.9623

14.An antenna that transmits,or receives equally well in all directions is said to be

a. omnidirectional
b.bidirectional
c.unidirectional
d.quasi directional

15.Prior to starting of fluorescent lamp,heating of electrode is done by

a. starter
b.ballast
c.filament
d.heater

16.A type of communication that uses light rather than electricity to communicate is called

a laser carrier
b.microwave
c.powerline carrier
d.fiber optic

17.Instrument transformers are used in indicating and metering and with protective devices,
they are used for

a.measuring
b.detecting
c.relaying
d.sensing

18. It refers to a device that merely boosts a signal and passes it on.

a amplifier
b.booster
d.repeater
c.op-amp

19. What do you call an impedance that when a line to ground fault occurs,produces fault
currents that are equal and in-phase?

a.positive sequence
b.third sequence
c.negative sequence
d.zero sequence

20. In a series or parallel LC circuit, the resonant frequency is attained when


a.Xc is 1/10 of XL
b.XL is 1/10 of Xc
c.power factor angle is 90°
d.Xc=XL

21. What is the equivalent of the collector terminal of transistor ir. a FET?

a.grid
b.gate
c.source
d.drain

22. What is the percent slip of the synchronous motor when running?

a.3
b.2.5
c.1.
d.0

23.What is the mit of electrical resistance?

a volt
b.ampere
c.ohm
d.watt

24.What category do 115 kV-230kV belong?

a. low voltage
b.medium voltage
c.high voltage
d.extra high voltage

25. An ideal full wave rectifier with non-inductive load has zero transformation losses. What
is the applied voltage?

a.100
b.90
c.80
d.70

26.What is the most common cause of failure in cable termination and splicing?

a.tracking
b.poor shielding
c.wrong clearance
d. improper insulation pencilling

27. What is the device that converts DC power to AC?


a.converter
b.inverter
c.SCR
d.rectifier

28.Three of the following terms in magnetic induction are identical. Which is distinct among
the following?

a.maxwells
b.lines
c. flux
d.gauss

29.When luminaries direct 90 to100 % of their output downward is considered a

a.direct lighting
b.local lighting
c.indirect lighting
d.luminaries

30.An instrument having a voltage coil and aa curnent coil would be a?

a.wheatstone bridge
b.voltmeter
C.wattmeter
d.ammeter

31.The function of saturable reactor is to provide variable inductance which can be


increased by

a saturating the core


b.decreasing ac switch
c.increasing the current in the do winding
d.decreasing,the current in the de winding

32.The material which is not a semiconductor is?

a.selenium
b.gallium-arsenide
c.carborundum
d.silica

33.A device which connects conductor to the earth to discharge the charge on the conductor
on the earth is called?

a.grounding electrode
b.isotator
c.carthing switch
d.surge arrester

34. Freshly paint layer may be dried electronically by.


heating

a.emmissive
b.dielectric
c.induction
d.convection

35.Branch circuit larger than_____amperes should only supply non-lighting outlet load.

a.20
b.50
c.30
d.15

You might also like