compressed sheet material based on a blend of aramid and inorganic fibres with a nitrile rubber binder system.
Service Physical properties
Novus 30 is a general purpose material Thickness 1.5mm suitable for use in a wide range of applications, including hot and cold Density 2.0g/cc water, steam, oils, fuels, gases and a Tensile Strength ASTM F152 12MPa wide range of general chemicals. Compression ASTM F36 9%
Approvals / Compliance Recovery ASTM F36 50% min
WRAS Potable Water: Residual Stress BS 7531 (300oC) 23MPa Registration No. 1510515 DIN 52913 29MPa Complies with BS Specification 7531 Gas Leakage BS 7531 <1.0cc/min Grade Y ASTM Oil 1 Thickness increase 2.0% TA-LUFT (in accordance with VDI IRM 903 Oil Thickness increase 5.0% Guideline 2440) ASTM Fuel B Thickness increase 4.0% GL Approval 37702 - 12HH
AS/NZS 4020:2005 Novus 30 Pressure/Temperature Limits
As the company’s products are used 120 for a multiplicity of purposes and as Availability 100 the company has no control over 3 the method of their applications or Thickness range: 80 use, the company excludes all 0.4mm to 6.0mm conditions or warranties, expressed 60 or implied by statute or otherwise, Standard sheet sizes: as to their products and/or their 2.0m x 2.0m 40 2 fitness for any particular purpose. Pressure (Bar)
1 Any technical co-operation between
2.0m x 1.5m 20 the company and the customer is 2.0m x 1.0m given for customers assistance only, 1.5m x 1.5m 0 and without liability on the part of the company. 1.5m x 1.0m 0 50 100 150 200 250 300 350 400 450 Standard roll sizes: Temperature (oC) Up to a maximum size of 6.0m x 2.0m 1 Suitable subject to chemical compatibility. Available with fine mesh mild steel 2 Suitable in some cases but check your application requirements reinforcement: Novus 30 Metallic or with Flexitallic. gauze mild steel wire reinforcement: 3 Contact the Technical Team for applications with higher temperatures and pressures. Applicable to 1.5mm and below. Novus 30 GWI. The operating temperature of non-asbestos sheet material is It can also be supplied with anti-stick related to the thickness of materials selected. Thinner materials give better temperature and pressure properties. coating and graphite coating. DSNOV30-0119-Rev08