Professional Documents
Culture Documents
1. We want to measure frequency of a sine wave, which of the following instrument should we use
7 1 4 6
4. Output of a/an ________ gate is high only if both of its inputs are same.
X-OR X-NOR NAND NOR
5. Name the circuit shown below:
Page 1 of 8
ME 243 Electronics and Instrumentation Lab Final Exam Fall 2021
3V 2V -2V 0.5V
8. Beta is the ratio of ________ to Base current
Emitter current Source current Emitter voltage collector current
9. If someone wants to remove unwanted high frequency from a signal which filter will you refer
Low pass filter High pass filter Band stop filter Notch filter
10. For a certain signal, we allow frequencies from 10 kHz to 100 kHz which filter we should use
Low pass filter High pass filter Band stop filter Bandpass filter
Information is not
enough
13. The time period of an acceleration signal from spring mass system is 0.1 sec. Calculate its spring
stiffness if mass attach to spring is 100 g.
394 N/m 1000 N/m 100 N/m 248 N/m
14. LabVIEW software has following number of main panels or windows.
1 2 4 Depends on layout
15. Which type of sensor can be used to find force on an object.
Distance Sensor Strain Gauge Hall-effect Encoder
16. A thermocouple is heated from room temperature (25°C) to Boiling temperature (100°C) as
shown in figure below. What will be its approximate time constant?
Page 2 of 8
ME 243 Electronics and Instrumentation Lab Final Exam Fall 2021
0.9 2.1 3 10
17. If a matrix “num” is having the following values
−1 −6 10
num =
8 4 3
An if “num (: , 1)” command is entered in MATLAB what will be printed in command window
-1 −1 −1 −6 10 −1 −6
8 8 4
18. A sensor output “m” needs to be plotted against time “t” in MATLAB, which of the following
command will be used
figure(m,t) plot(t,m) plot(m,t) Plot(mt)
19. if stiffness of a spring with natural frequency ω is increase 4 times and mass is same, what will be
new natural frequency.
ω 2ω 4ω 8ω
20. Which one of the following is made from a combination of two metals
Thermistor Thermocouple RTD None of these
Page 3 of 8
ME 243 Electronics and Instrumentation Lab Final Exam Fall 2021
Q1: A pressure sensor output is shown in table 1. Find a mapping equation and calculate pressure value
from that equation if output voltage is 4.25V. (3 marks)
Table 1.
Page 4 of 8
ME 243 Electronics and Instrumentation Lab Final Exam Fall 2021
Q2: Answer the questions given below based on the encoder as shown in figure below.
(3 marks)
Page 5 of 8
ME 243 Electronics and Instrumentation Lab Final Exam Fall 2021
Page 6 of 8
ME 243 Electronics and Instrumentation Lab Final Exam Fall 2021
Q4: Design a circuit using resistors and operational amplifier (Op-Amp) which performs following
operation:
𝑉𝑂𝑈𝑇 = −(𝑉1 + 𝑉2 )
Where V1 and V2 can be of any value. (3 mark)
Page 7 of 8
ME 243 Electronics and Instrumentation Lab Final Exam Fall 2021
Page 8 of 8