Professional Documents
Culture Documents
Aces Objectives 17 ESAS
Aces Objectives 17 ESAS
a.melts
b.vaporizes*
c.condenses
d.is compressed
2. Which band of light wavelengths arcs too short to be seen by the human eye?
a.visible
b.ultraviolet*
c.infrared
d.x-ray
3.Which of the following has the characteristics of both metals and non-metals?
a.conductors
b.insulators
c.metalloids*
d.meteors
4.Which of the following materials is used for making coils of standard resistances?
a.copper
b.platinum
c.nichrome
d.Manganin*
5.An establishment or a system for the production and modification of electric energy is an
a.substation
b.electrical system
c.electric plant*
d.electric supply
6.Article II, Section 5- Code of Ethics states that: An Electrical Engineer. shall honestly
advice his clients or employer if specialized work is called for to engage ______ the of
competent experts and specialist, and once engaged be shall cooperate with them I the
interests of his client or employer.
a.information
b.cooperation
c.experience
d.services*
7. Files of data and programs are located in many places of your hard disk and other
secondary storage devices. What keeps track of
where thcy are?
a.references*
b.supervisor·
c.operating system
d.cues
8. What is the step by step drawing that will represent a specific procedure of algorithm?
a.machine code
b. flowchart
c.assembler diagram*
d.block diagram
a.porcelain*
b.asbestos
c.slate
d.glass
10. The heat transfer due to motion of matter caused by a change in density is called
a.radiation
b.convection*
c.conduction
d.absorption
a.proprietorship
b.assets
c.equity*
d.liability
12. It refers to the fractional change in the volume of a fluid per unit change in pressure at
constant temperature process..
a.bulk modulus
b.proportional limit
c.capillarity
d.compressibility*
a.alkali
b.actinons*
c.earth metals
d.transition element
a.alkynes
b.alkenes
c.alkanes*
d.alkali
a.Henry's Law
b.Charles'Law*
c.Gay Isaac's Law
d.Boyle's Law
a.titanium
b.iron
c.cobalt
d.tungsten*
17.The temperature at which vapor pressure of a liquids equal to the atmospheric pressure
is?
a.distillation
b.surface tension
c.boiling point*
d.vaporization
18.Which gas law states that the total volume occupied by a mixture of gasses is equal to
the sum of their pure component volume at
constant temperature and pressure?
a.Amagat*
b.Dalton
c.Graham
d.Charles
a.ion
b.electron*:
c.proton
d.anode
a.acceleration
b.impulse
c.kinetic energy*
d.potential energy
25. If a disturbance is parallel to the direction of travel of a wave, the wave is classified as
a.longitudinal*
b.electromagnetic
c.transverse
d.torsional
26. What element improves the strength and fatigue properties of copper?
a.berkelium
b.americium
c.barium
d.beryllium*
27. Share of participation is called
a.stock*
b.partnership
c.corporation.
d.franchise
28.A measure of how it emits radiant energy in comparison with a black body at the same
temperature.
a.absorptivity
b.reflectivity
c.emissivity*
d.conductivity
a.specific weight
b.dead weight
c.column of liquid*.
d.leverage pressure
a.mass
b.mole*
c.volume
d.weight
31.Part of a program that makes decisions about the data, whether it is valid or should be
sent to the.database.
32.What.is the present worth of cost associated with an asset for an infinite period of time?
a.incremental cost
b.operating cost
c.capitalized cost*
d.annual cost
33.The techniques of finding the intensity and phase of light at any point, only when
a portion of wave front is exposed.
a.quantum theory
b.Brewster's law
c.Huygens principle*
d.polarization theory
a.velocity of sound
b.amplitude
c.frequency*
d.wavelength of sound.
a.commission*
b.IIEE
c.POEA
d.Bureau of Immigration
a.CHED
b.Commission
c.Board of EE*,
d.TESDA
a.open wiring*
b.circuit homerun
c.underground wiring
d. emergency wiring
a.gasoline engine*
b.diesel engine
c.gas turbine
d.Carnot engine
a.formic acid
b.nitric acid
c.hydrochloric acid
d.sulfuric acid*
40. Car A has a mass of 1000 kg and a speed of 60 km/h and car B has a mass of 2000 kg
and a speed of 30 km/h.The kinetic energy.
of car A is
41. A written acknowledgement by a carrier that he has received the goods for shipment.
a.crate bill
b.bill of lading*
c.ticket
d.contract to ship
42.It is a process of mixing water with air by spraying water or diffusing air through it.
a.aeration*
b.coagulation
c.infiltration
d.evaporation
43.A device used to keep moisture from passing through the system is called
a.trap
b.aerator
c.humidifier
d.dehydrator*
a.temperature*
b.pressure
c.density
d.temperature and pressure
a.ion
b.electron*
c.proton
·d.anode
a.Pascal
b.John Napier
c.Charles Babbage*
d.Abacus
47. Gross profit,sales lcss cost of goods sold, as a percentage of sales is called
a.ROI ratio
b.profit margin*
c.gross margin
d.price earnings
48.An object weighs 100 N in air and 25 N when submerged in water. Its specific gravity is
a.1.11
b.1.22
c.1.33*
d.1.44
49. It is the price a buyer is willing :c piuy a,willing seller for the stock.
a.bond value
b.scrap value
c.market value*
d.stock value
a.splicing
b.clearances
c.penciling of insulation*
d.none of these
a.vacuum*
b.negative gage
c.negative vacuum
d.pressure head
a.safe*
b.neutral
c.ambivalent
d.risky
a.OS
b.cache memory
c.BIOS*
d. IO
56. What is a substance that speeds up a chemical reaction without itself undergoing
a chemical change?
a.ingredients
b.reactants
c.solvent
d.catalyst*
a.creep
b.lustre*
c.fatigue
d.crystal
a.Charle's law
b.Boyle's law
c. Joule's law
d.Dalton's law*
59.The speed with which a liquid escapes from a vessel through an orifice is given by
a.Archimedes principle
b. Torricelli's theorem*
c.Bernoulli's theorem
d.Flow equation
60.When oxygen combines with an element to form a compound,the resulting compound is
called
a.a salt
b.an oxide*
c.oxidation
d.an oxalate
61.Prefix 10^-15 is
a.Pico
b.Atto
c.nano
d.femto*
62. A conduit bend needed if thé conduit end is running through an outlet box for connection
of lighting fixture, convenience outlet etc.
a.Gooseneck bend
b.Saddle bend
c.ZCorner bend
d.offset bend*
a.bone black
b.graphite and clay*
c.lead oxide
d.lead peroxide
a.unloading
b.downloading
c.reading*
d.accesing
65: Which of the following is not a method of non-destructive testing of steel castings and
forgings?
a.radiography
b.magnetic particle
c.ultrasonic
d.chemical analysis
a.commission
b.commissioner
c.DECS
d.Board*
a. Professional Life
b.Penal Provisions
c.Effectivity*
d.Relations with Client and Employer
69. Which of the following is used to capture real and moving objects and displays it into a
computer?
a.scanner
b.video player
c.electronic recorder
d.digital camera*
70.The Electrical Engineering shall observe such a system of moral principles and values as
a set of dynamic standards to guide his conduct and way of life.It is his____to practice his
professional according to this Code of Ethics.
a.manner
b.right
c.way
d.duty*
a.COBOL
b.FORTH*
c.ADA
d.RPG
72. A process where.a physical mixture of carbide and powdered metal is heated in order to
solidify the powder into a single piece.
a.Vitrification
b.bonding
c.alloying
d.sintering*
a.pressure head*
b.velocity head
c.datum head
d.total head
74.What refers to a document that shows proof of legal ownership of a financial security?
a.bond
5.bank note
c.coupon*
d.check
75. What refers to. the negotiable claim issued by a bank in lieu of term deposit?
a.time deposit
b.bond
c.capital gain Certificate
d.certificate of deposit*
76.During a complete or partial neutralization of acids, what is the ionic compound formed?
a.vinegar
b.potassium
c.salt*
d.sulfur
77.The____of a property is the amount in which a willing huyer will pay to a willing seller for
the property neither one is under
compulsion to buy or sell.
a.estimate value
b.recovered value
c.market value*
d.assessed value
78.The _____ states that in a given atom,no two electrons can have exactly the same set of
quantum numbers.
a.Dalton's theory
b.Pauli Exclusion Principle*
c.Boyle's theory
d. Bohr's theory
79. A crystal of solute is added to a solution, and the crystal remains undissolved. Thé
solution is best classified as
a.dilute
b.unsaturated
c.saturated*
d.supersaturated
80.The mass moment of inertia of a cylinder about its central axis perpendicular to a circular
cross section is
a.Boyle's Law
b.Gay-Lussac's Law
c.Boyd's Law
d.Charles's Law
82.When an object exerts a force on another force,the.second object exerts on the first a
force of the same magnitude but opposite direction.This statement is in accordance to
83.A graphical device used to convert true table to.its corresponding lögic circuit in a simple,
orderly process
a.state table
b.state diagram
c.Karnaugh map*
d.truth table
84.The product of force and the time during which it acts is known as
a.momentum
b.impact
c.impulse*
d.work
85.A type of annuity where the payments are made at the start of each period,beginning
from the first period.
a. annuity due*
b.ordinary annuity
c.perpetuity
d.deferred annuity
86.Which of the following refers to the diffusion of a solvent into a stronger solution in
attempt to equalize the two concentrations?
a.purification
b.electrolysis
c.osmosis*
d.hydrolysis
87.An elevator is pulled by cable at a constant speed. The tension in the cable is equal to
a.the weight*
b.twice the weight
c.thrice the weight
d. half the weight
a.copper
b.Manganin*
c.Kanthal
d.nichrome
a. return of investment
b.hurdle rate
c.return of capital
d.rate of return*
91. The uncovered depreciation results due to poor estimate as. the life of equipment.
a.sunk cost*
b.economic life
c.in-place value
d.annuity
92. The length of time usually in years, for the cumulative net annual profit to equal the initial
investment is called
a.oxygen
b.carbon
c.nitrogen*
d.sulfur
a.paddle wheel.
b.compressing a gas*
c.melting an ice cube
d.a burst membrane
95. The loss of zinc in the presence of certain corrosive media or at high ihe temperature is
known as
a.perzincification
b.dezincification*
c.loszincificatin
d.brazincification
96. The bounded (cables) or unbounded (air) mechanism for connecting the transmitter to
the receiver.
a.transmitter
b.receiver
c.medium*
d.information data
a.Brayton cycle,
b.Reversed Carnot Cycle
c.Rankine cycle*
d.Otto cycle
99.What is the term used to describe the moving of software from another computer to your
own computer?
a.surfing
b.downloading*:
c.uploading
d.accessing
100. In the periodic table of elements, which one of the following is a light metals?
a.gold
b.mercury
c.potassium*
d.silver
101.What do you call a framework composed of members joined at their ends to form a rigid
structure?
a.machine
b.truss*
c.joist
d.purlin
a.scrap value
b.value
c.use value*
d.book value
103.The ratio of the velocity of light in vacuum to its velocity of another material is
a.Specific index
b. Poisson's ratio
c.Refractive index*
d.Modulus ratio of Elasticity
104. Any equipment which produces, modifies, regulates, or controls the supply of electric
energy is the
a.transformer
b.substation
c.generator set
d.Electric supply equipment*
a.2*
b.4
c.6
d.8
106.The machine that is employed for converting the energy of flow in a pipeline into
mechanical work is called.
a.turbine*
b.pump
c.nozzle
d.motor
a.21*
b.23
c.24
d.25
108. An annuity where the påyments are made at the beginning of each period.
a.ordinary annuity
b.deferred annuity
c.annuity due*
d.perpetuity
109.Every object continues in its states of rest or of uniform velocity in a straight line, as long
as no net force acts on it.This
statement is in accordance to
110.What is the form of the moment diagram of a beam supported at both ends and carrying
a uniform distributed load?
a.triangle
b.hyperbola
c.parabola*
d.rectangle
111.Cash money and credit necessary to establish and operate on enterprise
a.capital*
b.funds
c.assets
d.liabilities
a.electron*
b.proton
c.ion
d.anode
113. Spark plug makes use of which of the following materials for insulation?
a.porcelain*
b.asbestos
c.slate
d.glass
114. The most important element that controls the physical properties of steel is
a.silicon
b.tungsten
c.manganese
d.carbon*
a.nuclear*
b.wind
c.solar
d.geothermal
119. Which of the following is not part of the requirements to take RME?
120. Two sky divers jump at the same time and want to play catch. Where should one aim if
he wants the other to catch it?
a.below
b.above because all falls faster
c.above because ball falis slower
d. straight because there's no air resistance*
a.entropy
b.enthalpy*
c.energy
d.electric field
124. Car travelled 20m/s south in 3 min, 25m/s east in 2 min and 39 m/s northeast in 1 min.
Find the average velocity in 6 minutes.
a.15.31m/s
b.13.51m/s
c.32.33 m/s
d.23.33 m/s*
125. It requires Q of heat to make a cup of coffee. How much energy is needed to make 3
cups of coffee?
a.3Q*
6.2Q
c.Q
d.4Q
126.This principle states that “Where the velocity of a fluid is high, the pressure is Iow, and
where the velocity is low, the pressure is
high”
a.Archimedes Principle
b.Torricelli's Theorem
c.Flow Principle
d.Bernoulli's Principle*
a. Alkalinity*
b.Turbidity
c.Acidity
d.Solubility
a.gases
b.liquids
c.woods
d.metals*
129.Those fund that are required to rnake the enterprise or project a going concern
a.accumulated amount
b.banking
c.working capital*
d.present worth
a.supply
b.distribution
c.generation
d.system operation*
a.Acetylene*
b.ethylene
c.propylene
d.methane
132. In RA 9136, what do you called a market that there is no choice to select a supplier of
electrical energy?
a.captive market
b. industrial and commercial section .
C.residential section
d.contestable market
133.The engines on a commercial jet aircraft operate on which of the basic cycles?
a.Otto
b.diesel
c.Carnot
d.Brayton*.
134. What is the temperature when water and vapor are in equilibrium with the atmospheric
pressure?.
a.ice point
b.steam point*
c.critical point
d. freezing point
135._____is formed when a pair of elect: ons are shared between two atoms.
a.triple bond
b.molecular orbital bond
c. covalent bond*
d.ionic bond
138. Network particle allow two or more pc to communicate unto network with the same
language then commercially accepted
standard.
a.OSI*
b.LAN
c.TCP/IP
d.WAN
a.baffle resonance
b. maximum amplitude
c.pressure amplitude*
d. ultrasonic frequency
141. Waves that -travel through some material medium as it displaced from an equilibrium,
state is?
a.elastic wave
b.periodic wave
c.mechanical wave*
d. longitudinal wave
a.Doppler's effect
b.interference
c.vibration
d.resonance*
143. Carbon or alloy steel are capable of being hardened and tempered are used for?
a.machining steel
b: galvanized steel
c.tool steel*
d.stainless steel
144.The maximum potential gradient that the material can withstand without rapture
a.allowable voltage
b.dielectric strength*
c. interrupting capacity
d.breaker capacity
145.The distance between two successive maxima or between any two successive points in
the same phase is?
a.wave guide
b.wave length*
c.amplitude
d.speed propagation
146. Adding more solute to an already saturated solution will cause the excess solute to
settle down to the bottom of the container.What is this process called?
a.saturation
b.hydration
c.precipitation
d.dehydration
147. Deviation edge from edge straightness. It is usually the maximum deviation of an edge
from a straight line of given length. What will this be?
a.lay
b.out of line
c.camber*
d.surface ripple
148.What is the term used to describe hydrocarbons containing single covalent bonds
between carbon atoms.
a.alkenes
b.alkynes
c.alkanes*
d.allotrope
149.A_____is one in which all microcomputers and other communication devices are
connected in a continuous loop.
a.star network
b.ring network*
c.bus network
d.hybrid network
a.radio
b.telephone
c.telecommunication*
d.cellular phone
151.A_____is programmable multi-uoe machine that accepts data-raw and figures, and
processes, or manipulates. If into information we can use such as summaries or totals.
a.cash register
b.calculator
c.adding machine
d.computer*
a.Boyle's law
b.Charles's law*
c.Henry's law
d.Gay Lussac's law
153.Metal that.contains both cermentite and graphite and is between the gray and white
irons. in composition and performance.
a.ductile iron
b.white iron
c.malleable iron
d.mottled iron*
·
154.Silicate mineral having the characteristic properties of fibrous structure and fire
resistance.
a.graphite
b.silicon
c.asbestos*
d.ceramic
155.Following the production of condensation of a region are formed in which the pressure
are lower than the equilibrium value.What will this be?
a.Reflection
b.rarefaction*
c.refraction
d.convection
156. During chemical reactions, bonds-between atoms are broken and new bonds are
usually formed. What do you call the starting
substance?
a.catalyst
b.product
c.ingredient
d.reactants*
a.nitrates
S.carbonates.
c.hydrates*
d.chlorates
158. What do you call the treating of an ore with aqueous reagent to dissolve component
selectively.
a.calcinations
b.leaching*
c.roasting
d.smelting
159.What is the distance between two consecutive points in phase on a wave called?
a.frequency
b.period
c.amplitude
d.wavelength*
160. If An object is moving north, the direction of the frictional force is?
a.north
b.south*
c.east
d.west
a.force
b.momentum
c.mass
d.energy*
162. Funds supplied and used by owhers of an enterprise in the expectation that a. profit will
be earned.
a.equity capital*
b.credit
c.save
d.investment
163. A substance existing the gaseous phase but relatively near its saturation temperature is
known as
a.gas
b.water
c.steam
d.vapor*
a.3
b.4*
c.5
d.6
165. When the velocity of an object is tripled, another quantity which is tripled at the same
time is the objects
a.momentum*
b.potential energy
c.kinetic energy
d.mass
166. A fluid property which refers to the intermolecular attraction by which the separate
particles of the fluid are held together
a.cohesion*
b.Adhesion
c.capillarity
d.tension
a.force
b.energy*
c.displacement
d.velocity
169. The most important element that controls the physical properties of steel is,.
a.silicon
b.tungsten
c.manganese
d.carbon*
170.Accounting book in which are recorded the credits and debits of commercial
transactions
a.ledger*
b.journal
c.balance
d.clerk's book
a.cohesion
b.surface tension
c.capillarity*
d.adhesion
a.aluminum*
b.silver
c.gold
d.iron
a.aluminum
b.magnesium
c.tin
d.zinc*
a.moment of inertia
b. mass moment of inertia c.location of centroid*
d. moment of area
175.Which one of the following elements has the largest atomic radius?
a.lithium
b.sodium*
c.beryllium
d.magnesium
a.parabola*
b.ellipse
c.part of a circle
d.hyperbola
a.temperature*
b.pressure
c.density
d.temperature and pressure
178. A substance formed by the union of two or more chemical elements in a definite
proportion that can be only be separated by chemical means.
a.mixture
b.molecules
c.ion
d.compound*
a.joules/second
b.Newton-seconds*
c.watts
d.calories/second
a.manometer
b.barometer*
c.pycnometer
d.hydrometer
182. It is a responsible for the procurement and administration of funds with the view of
achieving the objectives of business.
a.capital
b.budget
c.finance*
d.funds
a.50
b.1500*
c.225
d.110
185.The external pressure applied to & confined fluid increases the pressure of every point
in the fluid by an amount equal to the external pressure. This is known as
a.Pascal's Principle*
b.Archimedes Principle
c.Torricelli's Theorem
d. Bernoulli's Theorem
186. A processing system is a processor limiter when sorting of small tables in memory
would speed up computations?
a.files
b.DIR
c.storage
d.Menu Drive Interface*
a.sodium
b.fluorine*
c.phosphorus
d.hydrogen
189. In fluid flow, if.the fluid travels parallel to the adjacent layers and the paths of individual
particles do not cross, the flow is said to be
a.laminar*
b.turbulent
c.dynamic
d.uniform
a.process
b.availability
c.properties*
d.temperature and pressure
a.internal energy
b.entropy
c.temperature*
d.pressure
a.PRC Commissioner*
b.Chairman of the board of EE
c.Civil Service Commission
d.IIEE President
204. Ifa fluid “fails” in a piping system, the “failure” is related to which of the following
properties?
a.sulfur tension
b.bulk modulus
c.viscosity
d.vapor pressure*
205.The element that provides the electrical power to the components in the computer box is
a.power button
b.power cord*
c.power supply
d.ups
206. When gases expand and mix with other gases to fill available space, it is called
a.vaporization
b.evaporation
c.solidification
d.diffusion*
207. In a single phase, 3 wire electrical systems, the middle conductor must be?
a. ungrounded
b.out of phase
c.hot
d.grounded*
a.carbon*
b.nitrogen
c.oxygen
d.phosphorus
209. The amount of lateral strain in a tension member can be calculated using
210. Which of the following cycle is used in vapour cycle power plant?
a.Brayton Cycle
b.Rankine cycle*
c.diesel cycle
d.Ericson cycle
211.The phenomenon of melting under pressure and freezing again when the pressure is
reduces is known as
a.sublimation
b.condensation
c.deposition
d.regelation*
a.acceleration
b.impulse
c.kinetic energy*
d. potential energy
215.A substance that when added to a solution, makes changing pH of the solution more
difficult.
a.catalyst
b.solute
c.solvent
d.butter*
a.coal
b.oil*
c.natural gas
d.uranium
217. The equipment grounding conductor of a branch circuit shail be identified by what
color?
a.green*
b.black
c.white
d.gray
a.oxygen
b.helium
c.ozone*
d.water vapour
a.critical*
b.continuous
c. laminar
d.turbulent
a. instillation design
b.manufacturing design*
c. wiring design
d.construction design
222. The capacity of the fuse should be 125% of the continuous load current is covered by
a. instillation design
b.manufacturing design
c. wiring design*
d. construction design
223.What refers to the case hardening process by which the carbon content of the steel near
the surface of a part is increased?
a.carburizing*
b.annealing
c.normalizing
d.tempering
224. It is the interest earned by the principal which is added to the principal will also earmi an
interest for the succeeding period.
a.compound interest*
b.simple interest
c.discount
d.interest rate
a.steam
b.gas
c.reversible*
d.well lubricated
226.Pluto travels from perihelion to aphelion.What is the work done by gravity on Pluto?
a.zero*
b.negative
c.positive
d. undetermined
227. A device intended for the protection of personnel that functions to de -energize a circuit
or portion thereof within an established period of time when a current to ground exceeds
some predetermined value that is less than that required to operate the over current
protective device of the supply circuit.
a.grounding conductor
b. grounding-fault circuit interrupter*
c. grounding conductor equipment
d. ground-fault protection of equipment
228.The conductor used to connect the grounding electrode to the equipment grounding
conductor to the grounded conductor or to both of the circuit at the service equipment or at
the source of separately derived system.
a.grounding conductor
b..grounded conductor
c.grounding electrode conductor*
c.grounding equipment
a.granite
b. sedimentary rocks
c.igneous rocks*
d.metamorphic rocks
230._____ is an operating system 'for multiple users, with built-in networking capability to run
multiple task at one time and
version that can run on all kinds of computers. .
a.UNIX*
b.windows
c.MS DOS
d.BASIC
231.What do you call the hearting of an ore to bring about its decomposition and the
elimination of a volatile product?
a.leaching
b.calcinations*
c.roasting
d.smelting
232._____is a treatment in which the steel is heated over the critical temperature and
allowed to cool in still air.
a.air blasting*
b.normalizing
c.cool storage
d.water cooling
233.A______ is a devie that merges several low speed transmissions into high speed
transınission.
a.server
b.voltage regulator
c.multiplexer*
d.mainframe
234.This refers to energy consuming equipment including motors, heaters, furnaces, light
sources and other devices which utilize electric energy, for any purpose.
a.industrial plant
b.utilization equipment*
c.processing plant
d.transformer.
235. In toll steels, what dóes the prefix letter P stands for?
a.concentrated
b.mold*
c.special purpose
d.high carbon
236.A method of identifying the location of a given data record by its name
a.tracking
b.linker
c.signature
d.hashing*
237.It is the present worth of all future profits that are to be received through ownership of
the property.
a value*
b.Sirst cost
c.fixed cost
d.resale value.
a.continuity equation
b.Newton's sccond law
c.conservation of energy
d.conservation of mass
a.constant volume
b.constant temperature
c.constant pressure*
d.constant entropy
240.The element in thc present Periodic table are arranged according to their
a.atomic numbcrs*
b.atomic masses
c.oxidation states
d.mass numbers
a.aluminum*
b.silver
c.copper
d.steel
a.purification
b.clectrolysis
c.osmosis*.
d.hydrolysis
244. It is a general name to a wide range of alloys containing iron, carbon, and silicon and to
a lesser extent, manganese, phosphorus and sulfur.
a.wrought iron
b.cast iron*
c.hard iron
d.smooth iron
245. Which of the following is the busiest bus and the one that carrics that actual data?
a.address bus
b.data bus*
c.control bus
d.microprocessor
246. When a source of sound or a listener or both in motion relative to the air, the pitch of the
sound heard by the listener is not the same as when source and listener are at rest.This
phenomenon refers to?
a.carrier wave
b.reverberation effect
c.delay effect
d.Doppler effect*
247.When a close coded helical spring is subjected to an axial load, it is said to be under
a.bending
b.shear
c.torsion*
d.tension
a.time
b.displacement*
c.work
d.distance
249.______is a process of using a microcomputer, mousc, scanner, laser printer that
combines highly digital text and image to produce a high quallty output.
a.CAM
b.Desktop Publishing*
c.CAD
d.CAE
250. Two liquids of diffcrent densities ( pl = 1,500 kg/m', p2 = 500 kg/m') are poured together
into a 100-L tank, filling it. Ifthe resulting density of the mixture is 800
kg/m3,find the respective quantities of liguids used.
a.50 kg,49 kg
b.45 kg,35kg
c.46kg.32kg
d.50 kg,30kg
251.Determine the outside diameter of a hallow stecl tube that will carry a tensile load of 500
kN at a stress of. 140 MN/㎡. Assume that wail thickness to be the one
tenth of the outside diametcr.
a.112mm*
b.714mm
c.412mm
d.214mm
a.448 m/sec
b.568 ra/scc
c.479m/sec*
d.864 n/sec
253.RISC mcans?
a. mix atom
b.chemical compound*
c.element
d.molecule
255.Is the worth of the property which is equal to the original cost less the amount which has
been charged to depreciation?
a.scrap value
b.book value*:
c.fair value
d.use value
a.nucleons*
b.nuclei
c.nucleic
d.nuclide
a.bit
b.byte*
c.cell
d.character
259. What is the most undesirable of all the elements commonly found in steel?
a.sulfur
b.phosphorus*.
c. silicon.
d.manganese
260. When exposed to the atmosphere, which of the following liquid is coldest?
a.oxygen
b.argon
c.nitrogen
d.helium*
261. Is the present worth of all future profits that are to be received through ownershir of the
property?
a.value*
b.first cost
c.fixed cost.
d.resale value
262. Specifies a definite portion of ownership of the capital of the corporation, all each being
alike in value.
a.stock
b. fair value
c.same value
d.common stock*
263.A _____ is a group of bits, that may be manipulated or stored at one time by the CPU.
a.programs
b.address
c.word*
d.software
264. Refers to the loss of electrons by an aiom, which is theıcase when the metallic
elements reacts with oxygen.
a.movement of molecules
b.oxidation*
c.clearing of. molecules
d.reduction
a.commission
b.CHED
C.DECS
d.IIEE
266.What combination of elements has high elecrical resistance, high corrosion resistance
añd high strength at re leat temperatures, making it useful in resistance
heating?
a alnico
b.nichrome*
c.aluminum bronze
d.hastelloy
267. The mass of certain object is 1 gnu. Is the expression F = w a/g valid or. mars?
a.yes
b.100 times
c.1000 times
d.no*
270. If a disturbance is parallel to the directida of travel of a wave, the wave is classified as,
a.longitudinal*
b.electromagnetic
c.transverse
d.torsional
271.What s the substance that can no! be decomposed into simpler substances during
ordinary chemical reactions?
a.atom
b.elcment*
c.molecule
d.compound
272._____is a secondary storage medium, generally non removable disc made out of metal
and covered with a magnetic recording surface. It holds data in the form
of magnetized spots and are usually built in to the computer systein cabinet.
a. hard disk*
b.floppy dick
c.compact disk
d.CD ROM