Professional Documents
Culture Documents
Aces Objectives 5 EE
Aces Objectives 5 EE
a.overload protection
b.rum placed at the bottom of the tank to store oil
c. an air-tight metal dnm fixed at the top of the tank to store oil
d none of these
4. Which of the following is used for tuning an amplitude modulation (AM) signal.
a.varactor
b.termistor
c.resonator
d.pin dioid
a.inductor
b.capacitor
c.transformer
d.rectifier
a.conductor
b.insulator
c.semi-conductor
d.dielectric
7.The phenomenon of rise in voltage at the open circuited or slightly loaded line is called,
a.Raman effect
b.Ferranti effect
c.Seebeck effect
d. Skin effect
9.The color used to indicate grounding conductor larger than 14 mnr^2 are .
and
I-yellow
II-white
III-gray
IV-any color with 3 stripes except green
a.I,II,III
b.1,11,IV
c.II,III,IV
d.I,III,IV
a.February
b.April
c.June
d.May
11.In dwelling units at least one receptacle outlet shall be installed in hallways.
meters or more.
a.4
b.2
c.3
d.1.8
a 42%
b.50%
c.60%
d.80%
13.Which of the following electrodes are not permitted for grounding purposes?
a.aluminum electrode
b.metal underground metal pipes
concrete encased electrode
d.metal frame of thc building structure
14.Three 12kW electric ranges are supplied by a feeder.What is the demand load of the
feeder in kW?
a.12
b.14
c.11
d.18
15. In dwelling units, receptacle outlets shall be located not more than
min above countertop of kitchen.
a.300
b.250
c.500
d.150
16. A permanent joining of metal parts to form an electrical conductive path that ensures
electrical continuity and the capacity to conduct safety any current likely to be
imposed on these metal parts.
a.counterpoise
b.air terminal
c.interlink
d.bonding
17.A ground ring shall be buried at a depth below the earth's surface not less than
mm
a.750
b.600
c.1,000
d.500
18.Determine the minimum ampacity of the feeder for a group of single phase motors with
the following full load currents 28A, 40A. and 50A.
a.193
b.130
c.118
d.205
a.resistance heating
b.Eddy current heating
c.dielectric heating
d.induction heating
22. What is the minimum length and size of grounding electrode bare copper conductor in
concrete encased electrode?
23.What is the minimum ampere rating of the disconnecting means of a hcrmctic motor
having 30A rated current?
a.75
b.34.5
c.52.5
d.37.5
a.medium voltage
b.high voltage
c.low voltage
d.extra high voltage
a less than
b.equal to
c.1.732
d.0.577
26.A watt meter is installed in a balanced 3 phase system with current coil at line a and
voltage coil across lines b and c. The watt meter will measure
power.
a.total
b.active.
c.reactive
d.real
27. A 20 μF capacitor is charged to a 12V battery. What is the energy stored in the
capacitor?
a.12mJ
b.24mJ
c.2.88mJ
d.1.44ml
28.Resistance R1 and R2 are connected in parallel across 18V battery. The resulting current
in RI is 6A. When the two resistances are connected in series across the
same battery, the voltage drop across R2 is 12V. Find R2 in ohms.
a.6
1.3
c.12
d.4
29. If p= number of pairs of poles, f= frequency in Hz and N = speed in rpm the relationship
between the three for synchronous alternators is given as
a.f=pN/120
b.p=fN/120
c.f=pN/60
d.N=fp/120
30. A coil having a resistance of 0.05 ohm is connected to a cell with emf of 1.5V. Find the
current flowing in amperes if the cell has and internal resistance of 0.01
ohm.
a.2.5
b.20
c.50
d.25