Professional Documents
Culture Documents
Aces Objective 10 EE
Aces Objective 10 EE
a.inclined break
b.horizontal break
c.gravity open
d. gravity close
2.The capacitor in a capacitor start induction run ac motor is connected in series with
winding.
a.compensating
b.squirrel cage
c.starting
d.running
a series
b.shunt
c.cumulative.compound
d.differential compound
4.This is a lighting system wherein the percentage of upward and downward brightness are
the saruc.
a.general diffuse
b.direct
c.indirect
d.semi direct
5.Porcelain insulators are protected against creepage of surge current by the use of,
a.surge gap
b.arcing homs
c.ground conductors
d.surge arresters
a. fast acting
b.dual clcment
c.expulsion
d.cartridge
a.Vertical
b.Linear
c.semi-linear
d.Truck type
a.deion gaps.
b.overhead ground
c.choke oil
d.arc.horns
9.As load p.f of.an alternator becomes more leading,the value of the generated voltage
required to give rated terminal voltage
a.deceases
b increases
c.remains unchanged
d.varies w/ rotor speed
a.ampere turns
b.amperm tum/Weber
c.ampere/meter
d. dimensionless.
a.no-load test
b.schort-circuit
c.blocked-rotor test
d.polarity test
a.64
b.56
c.60
d.59
·
13.Moving coil instruments are used
a.permittivity
b.permeance
c.energy Ioss per cycle
d.magnetic flux
16.Which one of the following is not one of the relays of transmission line?
17.An alternator running in parallel with other alternators all having automatic voltage
regulators is to be taken off the bus. The usual procedure before opening the switch is to.
a.red,green,orange
b.red,green,blue
c.blue,green,magenta
d.yellow,green,cyan
a.(diameter of conductor)^2
b.diameter of conductor
c.(diameter of conductor)^3
d.(diameter of conductor)^(½)
a.insulation
b.cooling
c.cooling and insulation
d.lubrication
21.fone of the resistors in a parallel circuit is removed, what happens to the total resistance
a decreases
b.increases
c.exactly doubles
d.remains.constant
a.pulsating dc
b.pure dc
c.rectified dc
d.alternating current
23.The gas inside the immer discharge tube of a sodium vapor lamp is
a.argon
b.neon
c.nitrogen
d.helium
a.degreasing
b.degaussing
c.degrading
d.demagnetizing
a.mutual flux
b.fux factor
c.leakage factor
d. magnetic factor
a.induced emf
b.slip
c.supply voltage
d.rotor resistance
a.windage 1083.
b.core 103s
c.copper loss
d.friction loss
a.diamagnetic
b.paramagnetic
c.ferromagnetic
d.non-magnetic
a.substations
b.capacitor banks
c.induction motors.
d.generators
31.This is the least prevalent shunt fault among transmission and distribution lines:
a.LG
b.LL
c.LLG
d.LLL
a.1.16
b.0.82
c.1.36
d.1.46
a.communication system?
a.Atmosphere
b.Manufactured electrical equipment
c.Another communication signal
d.Thermal agitation in electronic component
35. A receptacle outlet is required aboye show window every linear meters.
a.5
b.4
c.2
d.3