Professional Documents
Culture Documents
About the exam
Dear Student,
Greetings!
You have completed the "Network_Assessment_12Jan" exam.
At this juncture, it is important for you to understand your strengths and focus on them to achieve the best results.
We present here a snapshot of your performance in "Network_Assessment_12Jan" exam in terms of marks scored by you in each
section, questionwise response pattern and difficultywise analysis of your performance.
This Report consists of the following sections that can be accessed using the left navigation panel:
Overall Performance: This part of report shows the summary of marks scored by you across all sections of the exam and the
comparison of your performance across all sections.
Sectionwise Performance: You can click on a section name in the left navigation panel to check your performance in that section.
Sectionwise performance includes the details of your response at each question level and difficultywise analysis of your performance
for that section.
NOTE : For Short Answer, Subjective, Typing and Programing Type Questions students will not be able to view Bar Chart Report in the
Performance Analysis.
Section Questions Attempted Correct Score
Assessment 25/25 16 64
NOTE : Subject having negative marks are not considered in the pie chart. Pie chart will not be shown if all the subject contains 0 marks.
Marks Obtained Subject Wise
Assessment
Assessment
The Assessment section comprises of a total of 25 questions
Question wise details
Please click on question to view detailed analysis
= Not Evaluated
= Evaluated
= Correct
1/5
12/01/2017
= Incorrect
= Not Attempted
= Marked for Review
= Answered
= Correct Option
= Your Option
Question Details
Q1.Switch has _________ broadcast domain.
Response : 1
Status : Correct
Option 1 : Single
Option 2 : Multiple
Option 3 : Double
Option 4 : Parallel
Q2.what is the translation scheme used for converting all private ip in a domain to a single public ip.
Response : 1
Status : Correct
Option 1 : PAT
Option 2 : SAT
Option 3 : HTTP
Option 4 : NAT
Q3.Enter the first valid host on the network that the host 192.168.238.155/25 is a part of:
Response : 1
Status : Incorrect
Option 1 : 192.168.238.254
Option 2 : 192.168.238.129
Option 3 : 192.168.238.255
Option 4 : 192.168.238.140
Q4.You need to set up passwords on all your default Telnet lines. What command would you start with?
Response : 1
Status : Incorrect
Option 1 : Router1(config)#telnet configuration
Option 2 : Router1(config)#line interfaace vty 1 5
Option 3 : Router1(config)#line vty 0 4
Option 4 : Router1(config)#interface Ethernet 0/1
Q5.How many collosion domain are there in switch ?
Response : 4
Status : Correct
Option 1 : Two Collision Domains interconnected.
Option 2 : A single collision domain
Option 3 : Collision Domain is not supported in a switch.
Option 4 : Multiple Collision Domains.
Q6.Which of the following commands will return your router to a previously saved configuration?
Response : 3
2/5
12/01/2017
Status : Incorrect
Option 1 : Router1#reload
Option 2 : Router1#copy startupconfig runningconfig
Option 3 : Router1#copy runningconfig startupconfig
Option 4 : Router1#setup
Q7.Which of the following eliminates switching loops?
Response : 2
Status : Correct
Option 1 : time to live
Option 2 : spanning tree protocol
Option 3 : split horizon protocol
Option 4 : poison reverse
Q8.You have configured a description on your serial interfaces. Which of the following commands will display the description?
Response : 2
Status : Incorrect
Option 1 : Show ip protocols
Option 2 : Show flash
Option 3 : Show runningconfig
Option 4 : sh ip route
Q9.What is a characteristic of Store and Forward switches?
Response : 1
Status : Correct
Option 1 : They read the entire frame and check CRC before forwarding.
Option 2 : They read the entire frame before forwarding.
Option 3 : They read the entire frame as soon as it is forwarded.
Option 4 : They read the entire frame and check CRC as soon as it is forwarding.
Q10.A network administrator is removing several VLANs from a switch. When the administrator enters the no vlan 1 command, an error is
received. Why did this command generate an error?
Response : 4
Status : Correct
Option 1 : VLAN 1 can not be deleted until all ports have been removed from it.
Option 2 : VLAN 1 can not be deleted until another VLAN has been assigned its responsibilities.
Option 3 : VLAN 1 can only be deleted by deleting the vlan.dat file.
Option 4 : VLAN 1 can never be deleted.
Q11.When a switch receives a frame and the source MAC address is not found in the switching table, what action will be taken by the
switch to process the incoming frame?
Response : 3
Status : Correct
Option 1 : The switch will request that the sending node resend the frame.
Option 2 : The switch ends an acknowledgement frame to the source MAC of this incoming frame
Option 3 : The switch will map the source MAC address to the port on which it was received
Option 4 : The switch will issue an ARP request to confirm that the source exists.
Q12. Which command will configure a switch port to use the IEEE standard method of inserting VLAN membership information into
Ethernet frames?
Response : 1
Status : Incorrect
Option 1 : switchport trunk encapsulation ietf
Option 2 : switchport trunk encapsulation ILM
3/5
12/01/2017
Option 3 : switchport trunk encapsulation isl
Option 4 : switchport trunk encapsulation dot1q
Q13.Which transmission medium is used in internet backbone?
Response : 2
Status : Correct
Option 1 : Wireless Medium
Option 2 : Optical Fibre Medium
Option 3 : Twisted Pair Cable Medium
Option 4 : Satellite Medium
Q14.Your boss is concerned about security on your network. She wants to make sure that no one can identify passwords if they happen
to view a configuration on your router. What command will encrypt all passwords on your router?
Response : 1
Status : Incorrect
Option 1 : Router1(config)#enable secret password
Option 2 : Router1(config)#service passwordencryption
Option 3 : Router1#enable secret password encryption
Option 4 : Router1#service passwordencryption
Q15.Which wired transmission medium is most prone to interference / cross talk?
Response : 3
Status : Correct
Option 1 : Roll over cable
Option 2 : Coaxial Cable
Option 3 : twisted pair
Option 4 : Optical Fibre Cable
Q16.frame check sequence is use for
Response : 2
Status : Correct
Option 1 : to check that particular packet is valid or not
Option 2 : to check that particular frame is valid or not
Option 3 : Read that particular frame
Option 4 : to make a particular frame valid
Q17.What is the purpose of issuing the command switchport mode access on a switch interface?
Response : 2
Status : Correct
Option 1 : make the port operational
Option 2 : force the port to be a part of a single vlan
Option 3 : disable port security
Option 4 : override the default port behavior
Q18.Which of the following is an IOS command that can be used to increase the security of unused switch ports?
Response : 1
Status : Incorrect
Option 1 : Firewall
Option 2 : Port security
Option 3 : Shutdown
Option 4 : Macsecure
Q19.What is the maximum size of payload field in ethernet frame ?
Response : 1
4/5
12/01/2017
Status : Correct
Option 1 : 1500 bytes
Option 2 : 1200 bytes
Option 3 : 1300 bytes
Option 4 : 1000 bytes
Q20.You are configuring your Cisco router and need to go back to User EXEC mode. What command will take you back to User EXEC
mode?
Response : 1
Status : Correct
Option 1 : Router1#disable
Option 2 : Router1#configure terminal
Option 3 : Router1#exit
Option 4 :
Q21.onetoone mapping of private and public addresses is called as?
Response : 2
Status : Correct
Option 1 : PAT
Option 2 : NAT
Option 3 : SAT
Option 4 : HTTP
Q22.Enter the last valid host on the network that the host 172.24.80.65/24 is a part of:
Response : 4
Status : Incorrect
Option 1 : 172.24.80.128
Option 2 : 172.24.80.1
Option 3 : 172.24.80.254
Option 4 : 172.24.80.129
Q23.Which of the following commands sets a trunk port on a 2960 switch?
Response : 2
Status : Incorrect
Option 1 : switchport mode trunk
Option 2 : switchport mode access trunk
Option 3 : switchport access mode trunk
Option 4 : switchport mode access
Q24.What type of cabling scheme is used to connect computers to a switch ?
Response : 4
Status : Correct
Option 1 : Coaxial Cable
Option 2 : Paired Cable
Option 3 : Roll over cable
Option 4 : Straight cable
Q25.What is the Subnet Mask corresponding to a CIDR value of /14?
Response : 4
Status : Correct
Option 1 : 255.240.0.0
Option 2 : 255.225.0.0
Option 3 : 255.260.0.0
Option 4 : 255.252.0.0
5/5