Professional Documents
Culture Documents
OTV‐EP16 (24 HDMI input)
OTV‐EP16 (12 HDMI input)
A、Front Panel Illustration:
1. LCD Display
2. Indicators Area
3. Key
4. ASI In
5. ASI OUT
B、Rear Panel Illustration:
1. HDMI input
2. Power switch
3. Power Socket
4. Grounding Wire
The device is connected to the input signal, connected to the
address:192.168.0.136)
2、Username and password(default address:admin)
3、Enter the Device->Status bar to clearly detect the running status
of the device
for the first, second, and third boards of the lower rear panel (4
interfaces for each board). H1H2H3 indicates the first, second, and
third boards of the upper layer of the rear panel (4 interfaces each).
5、Program Mux menu (Mainly for the code program reuse,
parameter modification and other settings)
this program。
click“ASI input 1”,in the input area, switch to the ASI input bar,
program
A、Input IP stream:click“+”,to Input IP Stream Config Area,
parameters。And click“Edit”。
C、Delete Input IP Stream:select input IP strea,click“ⅹ”,and
Editing parameters,click “Apply”.
TS config and PID Pass:
Editing parameters,click“Apply”.
equipment
7、MPTS output
MPTS output,address parameter,click "Edit All"
8、SPTS output
SPTS output,address parameter,click "Edit All"
9、Equipment upgrade
Select upgrade program,click “upgrade”。After the upgrade is
10、Save Menu
A、Can be saved quickly from the top right of the page,click
"Save Config"
10.4 Save To PC
10.6 Clear
In the this area, click“Save Config”,Save parameters quickly。
as not to set the device parameter again after the power is off