Professional Documents
Culture Documents
Page: 1/11
BASF Safety data sheet
Date / Revised: 18.03.2021 Version: 5.0
Product: Retinol 50 C
(30054549/SDS_COS_PH/EN)
Date of print 19.03.2021
Retinol 50 C
Use: cosmetic ingredient
Manufacturer/supplier:
BASF Philippines, Inc.
Upper Penthouse CTP ASEAN Tower
Asean Drive, Spectrum District
Filinvest Corporate City, Alabang,
Muntinlupa City, 1781, Metro Manila
PHILIPPINES
Telephone: +63 2 811-8000
E-mail address: psr.ph@basf.com
Emergency information:
National emergency number:
+63 2 8831 5576
International emergency number:
Telephone: +49 180 2273-112
2. Hazard identification
M-factor acute: 10
M-factor chronic: 10
Page: 2/11
BASF Safety data sheet
Date / Revised: 18.03.2021 Version: 5.0
Product: Retinol 50 C
(30054549/SDS_COS_PH/EN)
Date of print 19.03.2021
Pictogram:
Signal Word:
Danger
Hazard Statement:
H315 Causes skin irritation.
H317 May cause an allergic skin reaction.
H360 May damage the unborn child.
H400 Very toxic to aquatic life.
H410 Very toxic to aquatic life with long lasting effects.
3. Composition/information on ingredients
Chemical nature
(30054549/SDS_COS_PH/EN)
Date of print 19.03.2021
Preparation based on: retinol, Sorbitan, monododecanoate, poly(oxy-1,2-ethanediyl) derivs.
Hazardous ingredients
retinol
Content (W/W): >= 30 % - <= 50 % Acute Tox.: Cat. 5 (oral)
CAS Number: 68-26-8 Skin Corr./Irrit.: Cat. 3
Eye Dam./Irrit.: Cat. 2B
Skin Sens.: Cat. 1
Repr.: Cat. 1B (unborn child)
Aquatic Chronic: Cat. 4
2,6-di-tert-butyl-p-cresol
Content (W/W): >= 1 % - <= 5 % Aquatic Acute: Cat. 1
CAS Number: 128-37-0 Aquatic Chronic: Cat. 1
M-factor chronic: 1
4. First-Aid Measures
General advice:
First aid personnel should pay attention to their own safety. Remove contaminated clothing.
If inhaled:
After inhalation of vapor: fresh air.
On skin contact:
Wash thoroughly with soap and water
On ingestion:
Rinse mouth and then drink 200-300 ml of water.
Note to physician:
Symptoms: Information, i.e. additional information on symptoms and effects may be included in the
GHS labeling phrases available in Section 2 and in the Toxicological assessments available in
Section 11., (Further) symptoms and / or effects are not known so far
Hazards: Allergic skin reaction, bronchospasms and anaphylactic shock possible.
Treatment: Symptomatic treatment (decontamination, vital functions).
5. Fire-Fighting Measures
Suitable extinguishing media:
water spray, carbon dioxide, dry powder, foam
Page: 4/11
BASF Safety data sheet
Date / Revised: 18.03.2021 Version: 5.0
Product: Retinol 50 C
(30054549/SDS_COS_PH/EN)
Date of print 19.03.2021
Specific hazards:
harmful vapours
Evolution of fumes/fog. The substances/groups of substances mentioned can be released in case of
fire.
Further information:
Dispose of fire debris and contaminated extinguishing water in accordance with official regulations.
Personal precautions:
Do not breathe vapour/spray.
Environmental precautions:
Do not discharge into drains/surface waters/groundwater.
Handling
Processing machines must be fitted with local exhaust ventilation. Avoid contact with the skin, eyes
and clothing.
Suitable materials for containers: High density polyethylene (HDPE), Low density polyethylene
(LDPE), Aluminium
Further information on storage conditions: Keep container tightly closed and dry; store in a cool
place. Keep under inert gas. Protect contents from the effects of light. Keep at temperature not
exceeding 20 °C.
Storage stability:
Page: 5/11
BASF Safety data sheet
Date / Revised: 18.03.2021 Version: 5.0
Product: Retinol 50 C
(30054549/SDS_COS_PH/EN)
Date of print 19.03.2021
Storage temperature: 2 - 8 °C
2,6-di-tert-butyl-p-cresol, 128-37-0;
TWA value 2 mg/m3 (ACGIHTLV), Inhalable fraction and vapor
Hand protection:
Suitable chemical resistant safety gloves (EN 374) also with prolonged, direct contact
(Recommended: Protective index 6, corresponding > 480 minutes of permeation time according to
EN 374): E.g. nitrile rubber (0.4 mm), chloroprene rubber (0.5 mm), butyl rubber (0.7 mm) etc.
Supplementary note: The specifications are based on tests, literature data and information of glove
manufacturers or are derived from similar substances by analogy. Due to many conditions (e.g.
temperature) it must be considered, that the practical usage of a chemical-protective glove in
practice may be much shorter than the permeation time determined through testing.
Eye protection:
Safety glasses with side-shields (frame goggles) (e.g. EN 166)
Body protection:
Body protection must be chosen depending on activity and possible exposure, e.g. apron, protecting
boots, chemical-protection suit (according to EN 14605 in case of splashes or EN ISO 13982 in case
of dust).
(30054549/SDS_COS_PH/EN)
Date of print 19.03.2021
pH value:
substance/mixture is non-soluble (in
water), not relevant
Viscosity, dynamic:
not determined
Viscosity, kinematic:
not determined
Page: 7/11
BASF Safety data sheet
Date / Revised: 18.03.2021 Version: 5.0
Product: Retinol 50 C
(30054549/SDS_COS_PH/EN)
Date of print 19.03.2021
Other Information:
If necessary, information on other physical and chemical parameters is indicated in this section.
No further information available.
Substances to avoid:
oxidizing agents
Hazardous reactions:
No hazardous reactions if stored and handled as prescribed/indicated.
Acute toxicity
Experimental/calculated data:
LD50 rat (oral): > 2,000 mg/kg (BASF-Test)
The product has not been tested. The statement has been derived from substances/products of a
similar structure or composition.
Irritation
Experimental/calculated data:
Skin corrosion/irritation: (Epiderm Corrosivity Test)
Respiratory/Skin sensitization
Assessment of sensitization:
May cause sensitization by skin contact.
Experimental/calculated data:
Open epicutaneous test (OET) guinea pig: (OECD Guideline 406)
(30054549/SDS_COS_PH/EN)
Date of print 19.03.2021
Assessment of mutagenicity:
The substance was not mutagenic in bacteria. The substance was not mutagenic in mammalian cell
culture.
Experimental/calculated data:
Ames-test
Bacteria: negative (Modified OECD Guideline 471)
Carcinogenicity
Assessment of carcinogenicity:
Results from a number of long-term carcinogenity studies are available. Taking into account all of the
information, there is no indication that the substance itself is carcinogenic. Literature data.
Reproductive toxicity
Developmental toxicity
Assessment of teratogenicity:
The substance caused malformations/developmental toxicity in laboratory animals. Literature data.
Experiences in humans
Experimental/calculated data:
There are indications of coherence between the incorporation of high doses during pregnancy and
deformations at humans (newborn child).
Repeated dose toxicity and Specific target organ toxicity (repeated exposure)
Aspiration hazard
Ecotoxicity
Page: 9/11
BASF Safety data sheet
Date / Revised: 18.03.2021 Version: 5.0
Product: Retinol 50 C
(30054549/SDS_COS_PH/EN)
Date of print 19.03.2021
Aquatic invertebrates:
EC50 (48 h) 0.018 mg/l, Daphnia magna (OECD Guideline 202, part 1, static)
The statement of the toxic effect relates to the analytically determined concentration.
Mobility
Elimination information:
40 - 50 % BOD of the ThOD (28 d) (OECD 301F; ISO 9408; 92/69/EEC, C.4-D) (aerobic, activated
sludge, domestic)
Bioaccumulation potential
Contaminated packaging:
Uncontaminated packaging can be re-used.
Packs that cannot be cleaned should be disposed of in the same manner as the contents.
Sea transport
IMDG
Page: 10/11
BASF Safety data sheet
Date / Revised: 18.03.2021 Version: 5.0
Product: Retinol 50 C
(30054549/SDS_COS_PH/EN)
Date of print 19.03.2021
Packing group: III
ID number: UN 3082
Transport hazard class(es): 9, EHSM
Marine pollutant: YES
Proper shipping name: ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID,
N.O.S. (contains RETINOL, SORBITAN, MONOLAURATE,
ETHOXYLATED)
Air transport
IATA/ICAO
Packing group: III
ID number: UN 3082
Transport hazard class(es): 9, EHSM
Proper shipping name: ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID,
N.O.S. (contains RETINOL, SORBITAN, MONOLAURATE,
ETHOXYLATED)
Other regulations
2. DAO 2015-09 "Rules and Procedures for the Implementation of the Globally Harmonized System
(GHS) of Classification and Labelling of Chemicals in Prepration of Safety Data Sheet (SDS) and
Labelling Requirements of Toxic Chemical Substances”
3. Republic Act No. 6969, “Toxic Substances and Hazardous and Nuclear Wastes Control Act of
1990”
The regulatory information is not intended to be comprehensive. Other regulations may apply to the
material
Registration status:
(30054549/SDS_COS_PH/EN)
Date of print 19.03.2021
16. Other Information
Information on intended use: This product is of industrial quality and unless otherwise specified or
agreed intended exclusively for industrial use. This includes the mentioned and recommended
usage. Any other intended applications should be discussed with the manufacturer. In particular this
concerns the application for products that are the object of special standards and regulations.
Vertical lines in the left hand margin indicate an amendment from the previous version.
The data contained in this safety data sheet are based on our current knowledge and experience and
describe the product only with regard to safety requirements. This safety data sheet is neither a
Certificate of Analysis (CoA) nor technical data sheet and shall not be mistaken for a specification
agreement. Identified uses in this safety data sheet do neither represent an agreement on the
corresponding contractual quality of the substance/mixture nor a contractually designated use. It is the
responsibility of the recipient of the product to ensure any proprietary rights and existing laws and
legislation are observed.