Professional Documents
Culture Documents
Common To
Subject Code 19EC301 Subject Name ELECTRIC CIRCUIT ANALYSIS
I - BME, ECE ,E&I,
Faculty Name Dr. SARANYA A Department ECE Medical electronics
(PART A – 2 Marks)
UNIT - I
Knowledge
Difficulty
Q. No Questions CO Level
Level (1-5)
(Blooms)
Convert the voltage source into Current source in the fig.
QA101 CO1 K3 2
An electrical Appliance consumes 1.2 kWh in 30 minutes at 120 V. What is the current drawn by the
QA102 CO1 K2 2
appliance?
In a network shown below, Find the total resistance across the supply voltage
QA104 CO1 K3 3
QA105 Find the Voltage across the nodes AB in the circuit CO1 K3 2
UNIT - II
Knowledge Difficulty
Q. No Questions CO
Level (Blooms) Level (1-5)
Find Norton’s equivalent of the circuit
QA201 CO2 K3 3
QA202 CO2 K3 3
A star network consists of 3, 6 and 10. Convert it into a equivalent Delta connection
QA203 CO2 K3 3
In the circuit shown in fig., find the total resistance across A-B
QA204 CO2 K3 3
Find the equivalent admittance and impedance in the network
QA205 CO2 K3 3
UNIT - III
Knowledge Difficulty
Q. No Questions CO
Level (Blooms) Level (1-5)
A sinusoidal Voltage is represented by the equation 503sin(100t+30)V. What is the frequency and Time
QA301 CO3 K2 2
Period?
QA302 Give the condition for an RLC circuit to behave as inductive as well as capacitive circuit. CO3 K2 1
QA303 CO3 K3 3
An RLC circuit series circuit with R=10W, XL=20W, XC=20W is excited by a sinusoidal source of 200V.
QA304 CO3 K3 3
What will be the voltage across inductance?
In the circuit shown Source voltage and the current are in-Phase. Find the value of C
QA305 CO3 K3 3
UNIT - IV
Knowledge Difficulty
Q. No Questions CO
Level (Blooms) Level (1-5)
QA401 What is the time constant of a RL circuit with R=10Ω and L=20mH? CO4 K3 4
QA403 An RLC series circuit with R=10Ω and L=2H. Determine the value of C to give critical damping. CO4 K3 3
An RLC series circuit with R=5Ω is excited by a dc source of 10V by closing the switch at t=0. Draw the
QA404 CO4 K3 4
initial and final conditions of the circuit.
An RL series circuit with R=10Ω is excited by dc source of 30V by closing the switch at t=0. Determine the
QA405 CO4 K2 2
current in the circuit at t=2.
UNIT - V
Knowledge Difficulty
Q. No Questions CO
Level (Blooms) Level (1-5)
In the circuit shown below, find the Driving point impedance (Z 11 )
QA501 CO5 K3 2
QA502 CO5 K1 2
List the parameter sets available to model a two port network.
QA503
The admittance parameter matrix of a two port network is given as Y= [ 0.9
0.2 0.6 ]
0.2
.
CO5 K3 3
Determine the parameter(Z22 )of the two port network.
The Y-parameter of a two-port network are Y11=Y22=3 mho, Y12=Y21=2 mho. Determine the h22 of the
QA504 CO5 K3 4
network.
The Z parameters of a two-port network are Z11 = Z22=4Ω; Z12=Z21=1Ω. Determine the transmission
QA505 parameter B of the network. CO5 K2 2
UNIT - I
Knowledge
Difficulty
Q. No Questions CO Level
Level (1-5)
(Blooms)
Solve the currents in various branches of the circuit shown below by mesh analysis.
(Or)
In the circuit shown, find power dissipation at the 4Ω resistor using mesh analysis.
Determine the voltages across various elements of the circuit shown in the fig using the node
QB102 (a) CO1 K4 4
voltage method by applying KCL
(Or)
In the circuit shown, determine Voltage V X and current IX using mesh analysis
(Or)
Obtain the power across 10Ω resistor by nodal analysis method.
UNIT - II
Knowledge Difficulty
Q. No Questions CO
Level (Blooms) Level (1-5)
Determine equivalent resistance at A-B in the network shown in figure.All resistances are 3Ω.
(Or)
Determine the maximum power delivered to R L where RL=100Ω using Norton’s theorem. Also
determine the value of RL for maximum power transfer.
(Or)
Using superposition theorem , find the current through 3Ωresistor in the circuit shown below.
QB203 (a) Demonstrate the reciprocity theorem by interchanging the position of the source and Ix. CO2 K3 2
(Or)
(i)Using source transformation technique, find the current I 0,through 7 Ω resistor in the circuit
below.(6 mark)
UNIT - III
Knowledge Difficulty
Q. No Questions CO
Level (Blooms) Level (1-5)
Two magnetically coupled coils are connected in series have an equivalent inductance of
QB301 (a) 0.8H ,when connected in aiding and an equivalent inductance of 0.4H ,when connected in oppos - CO3 K3 4
ing .Determine the mutual inductance .Calculate the self-inductance of the coils by taking k=0.55
(Or)
An RLC series circuit consists of R=16ohms,L=5mH and C=2µF.Calculate the resonant frequency,
QB301 (b) CO3 K4 4
quality factor, bandwidth & Half-power frequencies.
A series RLC circuit has an impedance of 40Ω at a frequency of 200 rad/s. When the circuit is made
QB302 (a) to resonate by connecting a 10V source of variable frequency the current at resonance is 0.5A and CO3 K5 3
the quality factor at resonance is 10. Determine the circuit parameters.
(Or)
In a RLC parallel circuit, excited by a current source ,having R=40Ω,L=2mH and C=3µF.Determine
QB302 (b) CO3 K3 4
the Resonant frequency, quality factor, bandwidth & cut- off frequencies.
In the coupled circuit shown in Figure, determine the voltage across 10Ω resistor.
(Or)
A transformer with a primary having Rp=3Ω and Lp=0.2H and a secondary having Rs=12Ω and
QB303 (b) Ls=0.4H is connected between source voltage of 220V at 50Hz and a load of 600Ω. Determine the CO3 K4 5
load current if k=0.5
UNIT - IV
Knowledge Difficulty
Q. No Questions CO
Level (Blooms) Level (1-5)
Interpret the source free and step response of RLC circuit determined with transient state. Derive
QB401 (a) the necessary formula and explain. CO4 K4 3
(Or)
QB401 (b) In the RL circuit shown below, the switch is closed at position-1 for a long time and then CO4 K3 4
thrown to position-2 at time t=0.Determine the response i(t).
In the RL circuit of Figure, the switch is closed at t=0. Find the current i(t) and the voltage across
resistance and inductance.
(Or)
In the RC circuit shown below, a charge of Q 0= 100µC is stored in a capacitor before closing the
switch. At t=0, the switch is closed to discharge through 10KΩ resistance. Determine and sketch
vc(t).
In the circuit of Figure given, the switch is closed to position 1 for a long time. At time t=0, the
switch position is changed from 1 to 2. Determine the current response.
(Or)
In the RLC circuit of figure, the capacitor has an initial voltage of 40V, when the switch is closed at
t=0. Find an expression for the current i(t).
UNIT - V
Knowledge Difficulty
Q. No Questions CO
Level (Blooms) Level (1-5)
Determine the h-parameters of the bridged T network shown in figure.
(Or)
Determine g-parameters of the network shown
Solve the two port network to get the h-parameters and represent the h parameters in terms of
QB502 (a) ABCD parameters. CO5 K4 3
(Or)
Determine the driving point impedance and admittance of the network.
(Or)
Determine Admittance parameters of the ∏-network shown.
UNIT - I
Q. No Questions CO Knowledge Difficulty
Level
Level (1-5)
(Blooms)
In the circuit shown in the fig. find the voltage across 5 Ω resistor using source transformation
technique and verify the results using mesh analysis.
(Or)
Find voltages across various elements in the circuit by node method.
UNIT - II
Knowledge
Difficulty
Q. No Questions CO Level
Level (1-5)
(Blooms)
Using the superposition theorem, find the current through the 3 resistor in the circuit.
(Or)
In the circuit shown, determine the maximum power delivered to RL where RL=100 using
Norton’s theorem. Also determine the value of RL for Maximum Power transfer.
UNIT - III
Knowledge
Difficulty
Q. No Questions CO Level
Level (1-5)
(Blooms)
In a single tuned circuit, determine the value of C for resonance at 1200rad/s. Calculate the critical
value of mutual inductance and coefficient of coupling. Also, determine the output voltage at critical
coupling.
(Or)
For the RLC circuit shown in figure, determine the impedance at a) resonant fre-
quency b) 10 Hz below resonant frequency c) 10 Hz above resonant frequency
(Or)
Relate the equivalents of initial and final condition of R,L, C, ; when a circuit is
QC401 (b) CO4 K3 3
excited by DC supply.
UNIT - V
Knowledge
Difficulty
Q. No Questions CO Level
Level (1-5)
(Blooms)
Determine the Admittance parameter from the bridged T-network.
(Or)
QC501 (b) Determine the Open circuit parameters of the lattice network shown in figure. CO5 K4 4
Knowledge Level (Blooms Taxonomy)
Applying
K1 Remembering (Knowledge) K2 Understanding (Comprehension) K3
(Application of Knowledge)