Professional Documents
Culture Documents
Illustration 1 g01017007
The tightening sequence
Lubricate the threads and the underside of the head bolts with clean engine oil.
Tighten the bolts in the sequence that is shown in illustration 1 to the following torque. ... 50 N·m (37 lb ft)
Tighten the bolts again to the following torque. ... 100 N·m (74 lb ft)
Illustration 2 g00905621
Head bolts
The head bolts require an additional torque turn procedure. The numbers (1, 3, 4) are three long cylinder head bolts. All the other bolts are short
bolts. The tightening sequence is shown in illustration 1.
Place an index mark on the top of each bolt head. Tighten the short bolts for the additional amount. ... 225 degrees
Place an index mark on the top of each bolt head. Tighten the long bolts for the additional amount. ... 270 degrees
Thickness of the cylinder head ... 117.95 to 118.05 mm (4.643 to 4.647 inch)
Table 1
PPS-0005D9FE
2022/02/01
17:56:34-06:00
i02450394
© 2022 Caterpillar Inc.
Caterpillar:
Confidential Green