Professional Documents
Culture Documents
Cylinder Head
Illustration 1 g00819698
The dowel pins in the cylinder block hold the cylinder head gasket in the correct position when the
cylinder head is installed.
Table 1
Selection of Head Gasket for the C0.5, C0.7, C1.1/3011C and C1.6 Engines
Table 2
Selection of Head Gasket for the C1.5/3013C Engines
Table 3
Selection of Head Gasket for the C2.2/3024C Engine
Table 4
Selection of Head Gasket for the C2.2/3024CT Engine
(3) The stamped marking on the cylinder head gasket must face upward. This ensures that the cylinder
head gasket is installed correctly.
Use the following procedure in order to tighten the bolts for the cylinder head.
1. Put clean engine oil on the threads of the bolts. The bolts are tightened in the numerical
sequence that is shown in Illustration 2.
2. Repeat the procedure in Step1 to ensure that all of the bolts are tightened to the correct torque.
Use the following procedure in order to tighten the bolts for the cylinder head.
1. Put clean engine oil on the threads of the bolts. The bolts are tightened in the numerical
sequence that is shown in Illustration 3.
2. Repeat the procedure in Step 1 to ensure that all of the bolts are tightened to the correct torque.
Use the following procedure in order to tighten the bolts for the cylinder head.
1. Put clean engine oil on the threads of the bolts. The bolts are tightened in the numerical
sequence that is shown in Illustration 4.
2. Repeat the procedure in Step 1 to ensure that all of the bolts are tightened to the correct torque.
Typical example
Distortion of the cylinder head ... 0.00 to 0.05 mm (0.000 to 0.002 inch)
Note: Use a straight edge and a feeler gauge to check the six positions for distortion.
Refer to Testing and Adjusting, "Cylinder Head - Inspect" for the procedures for measuring the
cylinder head.
Note: If the cylinder head has been machined, check the valve depth below the cylinder head face.
Refer to Specifications, "Cylinder Head Valves" for valve depth.