You are on page 1of 4

<< PROJECT NAME >>>

BILL OF QUANTITY SUMMARY

REMEDIAL AND RESURFACING WORKS

Road Name:
MARRIS ID:
Road Type:
Length:
Affected CH:

BILL NO. Description BQ Amount (RM)

1 Preliminaries and General Item

2 Emergency and associated works

NOTE: 1. All the quantity are provisional due to actual site conditions
2. S.O.R referring to JKR Schedules of Rate
<<PROJECT NAME>>

Bill No.1 : PRELIMINARIES AND GENERAL ITEM

Item S.O.R Description Unit Rate Amount BQ Amount (RM)

1.0 PRELIMINARIE AND GENERAL ITEM

1.1 1A-9.c Mobilisation - per project where value of project is:


Exceeding RM 1,000,000.00 but not exceeding RM L.S
1,500,000.00

1A - 6 Detailed Engineering Design Based on Board of Engineer


Malaysia's Scale of Fees
(Per Project)

1A - 7 Engineering Survey Based on Board of Surveyor's


Scale of Fees

SUB TOTAL CARRIED FORWARD TO SUMMARY 0.00


<<PROJECT NAME>>>

Bill No.2: Resurfacing Work

RATE
Item Description Unit Qty Amount (RM)
(RM)
RESURFACING WORK
Scarify Work
Mark, scarify, remove and dispose 10mm thick of existing m2
pavement surface including clean and prepare the surface to
receive tackcoat

Breaking up of Existing Pavement


Mark, cut, break up , remove existing pavement and cart away m2
spoil to designated dumping ground

Resurfacing
Supply and apply bituminous tack coat uniformly to surface of m2
binder course including cleaning the surface of pavement prior to
application (ave 0.2-0.5 litres/m2)

Supply, lay and compact ACWC (Asphaltic Concrete Wearing MT


Course)

RECONSTRUCTION
Cut, excavate and dispose unsuitable materials other than rocks to m3
a designated dumping area within site

Supply, lay, spread, level and compact suitable earth fills to the m3
required formation level and profile to receive subbase

Supply, lay, spread, level and compact subbase material to the m3


required formation level

Supply, lay, level and compact crushed aggregate to the formation m3


level

Supply and apply bituminous prime coat uniformly to surface of m2


binder course including cleaning the surface of pavement prior to
application (ave 0.5-2.0 litres/m2)

m3
Supply, lay and compact ACBC (Asphaltic Concrete Binding Course)

Supply and apply bituminous tack coat uniformly to surface of m2


binder course including cleaning the surface of pavement prior to
application (ave 0.2-0.5 litres/m2)

Supply, lay and compact ACWC (Asphaltic Concrete Wearing m3


Course)

m3
Supply, lay, spread, level and compact shoulder materials to the
required formation level to Seal Roads (for Earth Shoulder only)
TRANSPORTATION COST
m3/km
Transportation Cost for Agg. for every km excess of 1st 10km

Transportation Cost for Asphaltic Concrete for every km excess of m3/km


1st 10km

Transportation Cost for imported earth for every km excess of 1st m3/km
5km

ROAD MARKINGS
Painting of New Markings
Prepare and apply 3.0mm thick white or yellow reflective m2
thermoplastic pavement markings of size 100mm to 150mm wide
single continuous edge line marking

100mm wide intermittent center line and lane marking m2

200mm wide intermittent give way line wide, with 300mm length m2
each and at 200mm gap

All Weather Thermoplastic Pavement Markings (Spraying)


m2
Prepare and apply not less than 1.5 mm thick high-reflective hot
spray all weather thermoplastic pavement markings for road
carriageway, tollway demarcation, intersections, traffic junctions,
pedestrial crossing, school crossings, speed zones, car park ramps,
bus and bicycle lanes, bus stops and railway crossings

Prepare and apply not less than 1.5 mm thick high-reflective hot m2
spray all weather thermoplastic pavement markings for "AWAS"
or other lettering and directional Arrow

NEW SIGNAGE
Installation of New Sign
Supply erect and install new G.I. Pipe Class AA of inner diameter m
50mm as specified. The rate shall include mounting frames, clips,
bolts and nuts, ledge angle, U-bolts, painting , concrete footing
and excavation

Supply and install 1.5mm thick Aluminium Composite sign plates No.
inclusive of fabrication, mounting frames, clips, Ubolts, spot
welding to post and ancillary material with high intensity
reflective sheeting (600mm Regulatory and Warning / Mandatory
Sign)

SUB TOTAL CARRIED FORWARD TO SUMMARY 0.00

You might also like