Professional Documents
Culture Documents
22
23
project completed
24
could be measrued
47
using Mentor tool
49
Core side or using DT Core side or using DT
Attach Failure Ratio [%]
15
16
Core side or
using DT
17
Core side or using
DT
18
RAN Core side
sampling or using
DT
19
data(DT)
The transmitter power output as received by a reference Mobile Service Coverage Signal
antenna at a distance from the transmitting antenna Strength = Field Strength measurements
The PDP context activation failure ratio denotes the PDP context Activation Failure Ratio [%] =
probability that the PDP context cannot be activated. It is the (Unsuccessful PDP context activation
proportion of unsuccessful PDP context activation attempts attempts/All PDP context activation
and the total number of PDP context activation attempts. attempts)X100%
The PDP context activation time is the time period needed for
activating the PDP context.
The PDP context cut-off ratio is the probability that a PDP PDP context cut-off Ratio [%] = (PDP
context is deactivated without being initiated intentionally by context losses not initiated by the user/all
the user, allowing the network to deactivate the context after successfully activated PDP contexts) X
user idle time. 100%
Target Result
Urban Rural Urban Rural
195.06 Kbps
108.13 ms
0%
16.13 Mbps
≥ 1 Mbit/s (4G) ≥ 512 Kbit/s (4G)
≤ 3%
≥98% of successful
attach attempts
Should be completed
within 2 seconds
≤ 1%
Total Attempt #
Signal strength is done by taking represntative drive test data from Addis Ababa.It is also possible to do it by ment
can reduce cost and time.Currently we take data from Mexico Square to Torhailoch
• The measurement is to be done by DT and it can be done by Argela and other CM tools.
• Drive test is done in Addis Ababa by selecting representative route.
• Drive test done on auto mode.
Signal strength is done by taking represntative drive test data from Addis Ababa.It is also possible to do it by mentor which can
cost and time.Currently we take data from Mexico Square to Torhailoch
Signal strength is done by taking represntative drive test data from Addis Ababa.It is also possible to do it by mentor which can
cost and time.Currently we take data from Mexico Square to Torhailoch
Signal strength is done by taking represntative drive test data from Addis Ababa.It is also possible to do it by mentor which can
cost and time.Currently we take data from Mexico Square to Torhailoch
- for Huawei &ZTE calculated as: (1-(Attach success excluding User Behavior))*100 for 2G/3G/4G
- for Ericsson calculated as: ttach failure Rate both for 2G&3G(failure ratio denotes the probability that a GPRS attac
for Huawei &ZTE average time delay is calculated as: Total attach time/successfully attached users: for 2G/3G/4G
-for Ericsson no counter avilable
for Huawei &ZTE calculated as: (1-(PDP activation success exclusing user Behavior))*100 for 2G/3G
- for Ericsson calculated as: PDP activation failure Rate both for 2G&3G