Professional Documents
Culture Documents
Emergency Overview
Form : liquid
This material is considered hazardous by the OSHA Hazard Communication Standard (29
CFR1910.1200)
1 / 12
Material Safety Data Sheet
or eye irritation.
Reports have associated repeated and prolonged
occupational overexposure to solvents with permanent brain
and nervous system damage.
Excessive inhalation of Xylene has caused hearing loss in
laboratory animals. Hexane used in conjunction w/Xylene
greatly increased this effect. Chronic skin contact w/Xylene
has caused dermatitis. Ingestion of Ethanol can increase
effects of overexposure to Xylene.
Carcinogenicity:
IARC Ethylbenzene 100-41-4
Carbon black 1333-86-4
No component of this product present at levels greater than or equal to 0.1% is identified as a
carcinogen or potential carcinogen by OSHA.
No component of this product present at levels greater than or equal to 0.1% is identified as a known
or anticipated carcinogen by NTP.
ACGIH Ethylbenzene 100-41-4
Environmental Effects
Environmental Effects : No information available.
Chemical nature
RESIN SOLUTION
Hazardous components
2 / 12
Material Safety Data Sheet
Skin contact : In case of contact, immediately flush skin with soap and plenty
of water for at least 15 minutes. Remove contaminated clothing
and shoes. Wash and thoroughly clean contaminated clothing
and shoes before reuse. Consult a physician.
Eye contact : In case of contact, immediately flush eyes or skin with plenty of
water for at least 15 minutes while removing contaminated
clothing and shoes. Consult a physician.
Notes to physician
Flammable properties
3 / 12
Material Safety Data Sheet
Specific hazards during fire : Do not use a solid water stream as it may scatter and spread
fighting fire.
Cool containers / tanks with water spray.
Flash back possible over considerable distance.
The pressure in sealed containers can increase under the
influence of heat.
Cool closed containers exposed to fire with water spray.
Methods for cleaning up : Absorb with inert absorbent material and dispose of in
accordance with applicable regulations.
Handling
Handling : Keep closure tight and container upright to prevent leakage.
Store container out of sunlight and away from heat, sparks and
flame.
Store only in well-ventilated areas.
Containers should be grounded when being emptied.
Never use pressure to empty.
Container is not a pressure vessel.
Do not puncture, drag, or slide container.
ATTENTION: Emptied containers may retain hazardous
residue and explosive vapors. Keep away from heat, sparks
4 / 12
Material Safety Data Sheet
Storage
Advice on common storage : Do not store above 25°C (77 °F).
To minimize the possibility of polymerization and to maintain
product quality, the ideal storage temperature is less than 25
°C. Above 25 °C, this material must be monitored closely.
Exposure Guidelines
Components with workplace control parameters
Components CAS-No. Value Control Update Basis
parameters
Xylene 1330-20-7 TWA 100 ppm 1993-06-30 OSHA P1
435 mg/m3
5 / 12
Material Safety Data Sheet
Engineering measures
Engineering measures : Use with adequate ventilation.
All application areas should be ventilated in accordance with
applicable OSHA regulations. (29 CFR 1910.94)
This product contains a particulate(s) that is considered
hazardous per OSHA (29 CFR 1910.1200) and is listed in
Section III as a precautionary warning.
Under normal conditions of use, this product as supplied does
not pose a health risk from particulate matter.
Physical degradation of the cured product (i.e. sanding,
abrading, etc.) may pose a dust hazard.
Repeated inhalation of such dust may cause lung injury.
6 / 12
Material Safety Data Sheet
Form : liquid
Odor Threshold : no data available
Flash point : 21 °C (70 °F)
Method:
Conditions to avoid : Keep away from open flames, hot surfaces and sources of
ignition.
Materials to avoid : Strong oxidizing agents, free radical initiators, heavy metals
and alloys, strong acids and bases.
7 / 12
Material Safety Data Sheet
8 / 12
Material Safety Data Sheet
SARA 302 Components : SARA 302: No chemicals in this material are subject to the
reporting requirements of SARA Title III, Section 302.
9 / 12
Material Safety Data Sheet
If listed below, this product contains toxic chemical(s) subject to the reporting requirements of Section
313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 and 40 CFR part 372.
SARA 313 Components : Xylene 1330-20-7 48.8%
Ethylbenzene 100-41-4 12.2%
Non-volatile (Wt) : 39 %
If not listed above, this product does not contain HAPs at 1% or 0.1% or greater. Refer to Section 3
for HAP weight percentage.
State Laws
10 / 12
Material Safety Data Sheet
WHMIS Classification : B2
D2A
D2B
11 / 12
Material Safety Data Sheet
Further information
The information provided in this Safety Data Sheet is correct to the best of our knowledge,
information and belief at the date of its publication. The information given is designed only as a
guidance for safe handling, use, processing, storage, transportation, disposal and release and is
not to be considered a warranty or quality specification. The information relates only to the
specific material designated and may not be valid for such material used in combination with any
other materials or in any process, unless specified in the text.
12 / 12