Professional Documents
Culture Documents
com
PROPRIETARY NOTE
THIS SPECIFICATION IS THE PROPERTY OF BOE OT AND SHALL NOT BE
REPRODUCED OR COPIED WITHOUT THE WRITTEN PERMISSION OF BOE OT
AND MUST BE RETURNED TO BOE OT UPON ITS REQUEST
HT140WXB-501
Preliminary Product Specification
Rev. P0
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
REVISION HISTORY
REV. ECN NO. DESCRIPTION OF CHANGES DATE PREPARED
P0 - Initial Release 2010.7.22 Xue Hailin
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
Contents
No. Items Page
20
2.0 Absolute Maximum ratings 6
13 0
13.0 Handling & Cautions.
Cautions 26
14.0 Label 27
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
1.1 Introduction
HT140WXB-501 is a color active matrix TFT LCD module using amorphous silicon TFT's
(Thin Film Transistors) as an active switching devices. This module has a 14.0 inch
diagonally measured active area with WXGA resolutions (1366 horizontal by 768 vertical
pixel array). Each pixel is divided into RED, GREEN, BLUE dots which are arranged in
vertical Stripe and this module can display 262,144 colors. The TFT-LCD panel used for this
module
d l iis a llow reflection
fl ti and d hi
higher
h color
l ttype. Th
Therefore,
f thi
this module
d l iis suitable
it bl ffor
Notebook PC. The LED Driver for back-light driving is built in this model.
All input signals are LVDS interface compatible.
LVDS Rx
LVDS
+
Gate Driver
Input
Connector 1
Signal T/CON
+ TFT LCD Panel
BACK LIGHT (Fluorescent Lamp)
Mini-LVDS Tx 1366 ശ768
VDD
DC/DC
Gamma
Vcom Source Driver
1.2 Features
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
1.3 Application
The followings are general specifications at the model o{X[W~iT\WX. (listed in Table 1.)
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
The followings are maximum values which, if exceed, may cause faulty operation or
damage to the unit. The operational and non-operational maximum voltage and current
values are listed in Table 2.
Notes : 1. Permanent damage to the device may occur if maximum values are exceeded
functional operation should be restricted to the condition described under normal
operating conditions.
2. Temperature and relative humidity range are shown in the figure below.
95 % RH Max. ( 40 OC Ta)
Maximum wet - bulb temperature at 39 OC or less. (Ta > 40 OC) No condensation.
Relative Humudity
100
(40, 95)
90
80 (50, 80)
ange
Storage Ra
60
Operating Range
Storage Range
40
(60, 27)
20
-40 -20 0 20 40 60 80
Temperature (ఁ)
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
Positive-going
g g Input
p
VIT+ - - 100 mV
Threshold Voltage
Vcm = 1.2V typ.
Negative-going Input
VIT- -100 - - mV
Threshold Voltage
Notes : 1
1. The supply voltage is measured and specified at the interface connector of LCM
LCM.
The current draw and power consumption specified is for 3.3V at 25ć.
a) Typ : Window XP pattern
b) Max : Vertical 2 line skip pattern
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
PWM High
PWM 20
2.0 50
5.0 V
Level
Control
Level PWM Low
0 0.1 V
Level
2. The LED Life-time define as the estimated time to 50% degradation of initial luminous.
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
4.1 Overview
The test of Optical specifications shall be measured in a dark room (ambient luminance d 1
lux and temperature = 25r2ć) with the equipment of Luminance meter system (Goniometer
system and TOPCON BM-5) and test unit shall be located at an approximate distance
50cm from the LCD surface at a viewing angle of and equal to 0q. We refer to Ø=0
(=3 ) as the 3 o’clock direction (the “right”), Ø=90 (= 12 ) as the 12 o’clock direction
(“upward”), Ø=180 (= 9 ) as the 9 o’clock direction (“left”) and
Ø=270(= 6 ) as the 6 o’clock direction (“bottom”). While scanning and/or Ø, the center
of the measuring spot on the Display surface shall stay fixed. The backlight should be
operating for 30 minutes prior to measurement. VDD shall be 3.3+/- 0.3V at 25qC.
Optimum viewing angle direction is 6 ’clock.
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
Notes : 1. Viewing angle is the angle at which the contrast ratio is greater than 10. The
viewing angles are determined for the horizontal or 3, 9 o’clock direction and the
vertical or 6, 12 o’clock direction with respect to the optical axis which is normal
to the LCD surface (see FIGURE 1).
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
Photo detector
(TOPCON BM-5A)
o
Field = 2
50 cm
TFT-LCD module LCD panel
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
Figure
g 4. Response
p Time Testing
g
TR TF
100%
Optical
90%
Response
10%
0%
Time
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
YA (1195, 384) L0
YB - YA
Cross-Talk (%) = ശ 100
YB
Where:
YA = Initial luminance of measured area (cd/m2)
YB = Subsequent luminance of measured area (cd/m2)
The location measured will be exactly the same in both patterns
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
Note.1
-BIST=
BIST=“H
H (3
(3.3V)
3V)” : Display BIST pattern @ No LVDS CLK or DE
(white->black->red->green->blue->white…)
-BIST=“L(GND or NC)” : Display black pattern @ No LVDS CLK or DE
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
P
100 ohm
Vsync Vsync
DE DE
CLK+
Vdiff=0V
Vdiff 0V
Rin0 GO R5 R4 R3 R2 R1 R0
Rin1 B1 B0 G5 G4 G3 G2 G1
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
y n i y n i y n i y n i
XGwGdGZGk
y n i
y n i y n i y n i y n i
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
tRIP2
tRIP3
tRIP4
tRIP5
tRIP6
tRIP0
tRIP1
RXO/Ez +/ +/- R 3
Rx3 R 2
Rx2 R 1
Rx1 R 0
Rx0 R 6
Rx6 R 5
Rx5 R 4
Rx4 R 3
Rx3 R 2
Rx2 R 1
Rx1 R 0
Rx0
* Z = 0, 1, 2,3
RxECLKIN+ tCdiff
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
oTz
T
Tv
Tvd
MCLK
Th
DE
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
Th
Thd
MCLK
Tc
DE
Tch Tcl
2.0V
MCLK 1.5V
0.8V
Tds Tdh
2.0V
Data Valid Data
0.8V
Tes
DE 2.0V
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
8.0 INPUT SIGNALS,, BASIC DISPLAY COLORS & GRAY SCALE OF COLORS
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
0.9VDD 0.9VDD
Power Supply 0.1VDD 0.1VDD
0V
T1 T9
T10
T2
Valid
Interface Signal
0V
T3 T8
Backlight Power on 0V
T4 T7
̻ T1 d 10 ms ̻ 0 ms d T6
̻ 0 ms d T2 d 50 ms ̻ 10 ms d T7
̻ 200 ms d T3 ̻ 200 ms d T8
̻ 10 ms d T4 ̻ 0 ms d T9 d 50 ms
̻ 10 ms d T5 ̻ 1s d T10
Notes:
1. When the power supply VDD is 0V, keep the level of input signals on
the low or keep high impedance.
2 Do not keep the interface signal high impedance when power is on
2. on.
Back Light must be turn on after power for logic and interface signal
are valid.
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
P
Parameter
t S
Specification
ifi ti U it
Unit
Active Area 309.40 (H) ശ173.95 (V)
Number of pixels 1366 (H) X 768 (V) (1 pixel = R + G + B dots)
Pixel pitch 0.2265 (H) X 0.2265 (V)
Pixel arrangement RGB Vertical stripe
Display colors 262K
Display mode Normally white
Dimensional outline 323.5*192*5.2 (max) mm
Weight 350 (max) gram
Connector : MS24022P10
Back Light
LED Horizontal-LED
LED, Horizontal LED Array type
10.2 Mounting
See FIGURE 6.
The surface of the LCD has an glare coating to maximize readability and hard coating
to reduce scratching.
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
14.0 LABEL
(1) Product label
1 2 3 4 5 6 7
X X X X X X 1 0 0 X X X X X X X X
{ G uG\UGtGOXSGYSGZSG…SG`SGSGSGP
uGXUGjGu uG]UGwGpGOmnP
uGYUGyGVGn uG^UGzGu
u Z s
uGZUGsG
Oivl v{ hVijP
OivlGv{ahVijP
uG[UGGOXW aGYWXWSGXXaGYWXXSG…P
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
HT140WXB-501 38
0000000000000 201X.X.XX
00 0 0 00 0 0000 000000
Type Grade Line Year Month Internal use Serial No
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
15.2 Notes
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com
Global LCD Panel Exchange Center www.panelook.com
TBD
One step solution for LCD / PDP / OLED panel application: Datasheet, inventory and accessory! www.panelook.com