Professional Documents
Culture Documents
ISO Quality Manual 9001-2015 - Final - 20.07.2017 - Part55
ISO Quality Manual 9001-2015 - Final - 20.07.2017 - Part55
WORK INSTRUCTION
Rev No 00
PROCEDT'R.E FOR FRP LAMINATION Rev. Date: or /04 /2ot7
(HAND LAY-T'P} Page No Page 1 of 1
Sr. No Procedure
1 Purpose To describe the procedure for FRP Lamination
3 Procedure
First of all mould is prepared. The outside diameter of the mould should kept
3.1
as inside diameter of the tank.be
A film of Polyvinyl alcohol (PVA) which acts as a mould release agent is
3.2
applied over the wax polished surface of the mould.
Then a thin layer of resin is applied on the mould surface to give the
c.c moulding a smooth surface and to protect the glass fibre from e)dernal
influences
Then a layer of surface mat is applied on the mould. A resin is applied on the
Surface mat with help of brush. Surface mats are the thin tissues of glass
3.4 fibre which absorbs a high percentage of resin which gives the resin rich
surface and good corrosion resistance. Sometimes a Ethylene tissue is also
used which improves the impact and abrasion resistance of FRP laminate
.E A roller is used to remove the air bubbles from the FRP laminate.
Subsequent layers of chopped strand mat and woven roving are applied
5.b
along with the resin until the required thickness rs achieved
A suitable glass trssue is used as a final layer of reinforcement to have a
37 smooth Surface flnish.
All the FRP laminates can be post cured in accordance with the resin
3.8
suppliers lnshuctions.
End of Document
p)
wy'
Date : Ol lO4l2ol7
Simature: Signature:
Check List No wr/MFG/07
WORK INSTRUCTION
Rev No 00
PROCEDI'RE rlOR FABRICATION OF Rev. Date or /04 /2or7
LINED FRP EQIIIPMETITS Page No: Page 1 of 1
Sr. No Procedure