Professional Documents
Culture Documents
PERIODIC DEICR
Client Job No Date of Previous
Estimated age
Client Details: test
Post Code
Address Of Installation: Evidence of Estimate age of
Ateration
Y/N alteration in Yrs
YRS
TT A
Current Rating
Ώ Maximum Zs permitted
Reference method (see
S Max disconnectiontime
Number of points served
RCD Ring final circuits All Circuits Insulation Resistance
(see
Circuit Conductors Overcurrent protective devices RCD operating times
appendix 4 of BS 7671)
Circuit No
permitted by BS7671
Polatrity
Maximum
Type of Wiring
mA Operating
measured
kA Capacity
by BS 7671
earth fault
at 51∆n
A Rating
Line / Line / Netral /
Type No
loop (if
Circuit
code)
at 1∆n
ü
Line / Neutral Earth Earth impedance Zs applicable)
Circuit Designation 2
Live mm cpc mm
2
BS (EN) r1 Line rn Neutral r2 CPC R1 + R2 R2 Line MΏ MΏ MΏ MΏ MΏ ms ms
- -
- -
- -
- -
- -
- -
- -
- -
- -
- -
Comments
Limitations - No access to suppliers main protective device. 10% inspection of accessories.
Fans boiler heater inspected/tested to isolators only (delete as nessacery)
SATISFACTORY / UNSATISFACTORY
\\WILLEC-SRV\daniwoolley$\Desktop\EICR FRONT DANI
Further
Outcome investigation
No Description Comments Y/N
Tick/Code
5.5 Adequacy of cables for current-carrying capacity with regard for the type and nature of installation
5.6 Coordination between condutors and overload protective devices
5.7 Adequacy of protective devices: type and rated current for fault protection
5.9 Wiring system(s) appropriate for the type and nature of the installation and external influences
5.1O Concealed cables installed in prescribed zones (see extent and limitations)
Concealed cables incorportating earthed armour or sheath, or run within earthed wiring system, or
5.11 otherwise protected against mechanical damage from nails, screws and the like (see extent and
5.12 Provision of additional protection by RCD not exceeding 30mA:
*For all socket outlets of rating 20A or less provided for use by ordinary persons unless an
exception is permitted
* For supply to mobile equipment not exceeding 32A rating for use outdoors / Concealed in walls
5.14 Band II cables segregated/separated from Band I
5.17 Terminations of cables at enclosures - indicate extent of sampling in Extent and Limitations of the
*Connections soundly made and under no undue strain / Burnt connections
*Adequately connected at point of entry to enclosure (glands, bushes etc.)
5.18 Condition of accessories including socket-outlets, switches and joint boxes
5.19 Suitability of accessories for external influences
Isolation and switching (isolation, switching off for mechanical maintenance, emergency
6 switching/stopping and functional switching
6.1 *presence and condition of appropriate devices and correct operation verified
6.2 For isolation and switching for maintenance capable of being secured in OFF position
6.3 For isolation only warning label where live parts cannot be isolated by a single device
6.4 For emergency switching readily accessible for operation where danger might occur
7 Current-using equipment (permanently connected)
7.1 Condition of equipment in terms of IP rating
7.7 Recessed luminaires no signs of overheating to building fabric and connections
8 Location(s) containing a bath or shower
8.2 Where used as a protective measure, requirements for SELV or PELVE met
8.4 Presence of supplymentary bonding conductors, unless not required by BS 7671:2008
8.6 Suitability of eqpment for external influences from installed location in terms of IP rating
Observations :
Non amendment 3 Consumer unit C3