Professional Documents
Culture Documents
Cert. Of conformity/test
Destruction sample cert
These may vary slightly
BS EN12079 1999
(see note 4)
Refer to I.L.O.188
Calibration certificate
Prior to first usage
% above swl excess manufactures
Stress calculation
S.I 1890
load (t)
5- yearly
Swl x2,2
Swl x2,5
4-yearly
others
Months
4½: 1
3½: 1
Manufacuring
10: 1
Others
yearly
4: 1
Other
Equipment type
8: 1
7: 1
6: 1
5: 1
Codes /standards 10 25 50 100 300 3 5 10 6 12 12 12
1 Cranes pedestal/ mobile < 20t EN13001
2 Cranes pedestal/ mobile 20-50t EN13001
3 Cranes pedestal/ mobile > 50t EN13001
4 Elec overhead traveling crane EN13001
5 Crane hook block ≤ 25t EN13157
6 Crane hook block > 25t EN13157
7 Single sheave block ≤ 25t NEN-3320
8 Single sheave block > 25t NEN-3320
9 Multi-sheave block ≤ 25t NEN-3318
10 Multi-sheave block > 25t NEN-3318
11 Marine lifeboat davits BS MA41
12 Davit blocks & assoc equipment BS MA41
13 Winch (davit) BS MA 55:1975
14 Winch (Pneumatic) ISO3078
15 Winch (manriding) EN 10204
16 Winch (Manual) EN13157
17 Forklift trucks ISO.5057 /EN 1726-1
18 Pallet stackers ISO,5766 /BS 5777
19 Pallet trucks ISO,509
Lifting appliance
EN 10002
45 Load cells EN 10002
46 Safe load indicators / RCI's EN 10002-3
Legend Note 1: Lifting support steelwork such as runway beams, lifting beams, lifting frames,
Statutory requirements padeyes etc., with no moving parts shall have their periodicity extended to
Company polici 12 montths as long as :
Refer to specific design codes 1) They are not used for supporting personnel
Initial factory test 2) Their use is infrequent to extent that wear is not an adverse factor
Function test only 3) They are adequately coated/ protected so that corrssion is not an adverse factor
American pattern blocks
Refer to L.R.O.S./DNV Procedure Note 2: In addition to the annual examination, safe workload indicators must be function
Descent rate must fall between 90-180ft/min checked on a daily basis and checked for calibration weekly
At the discretion of the inspection body
Accepted practice Note 3: For lifting, lowering or supporting personnel, lifting equipment, I.E lifting appliances
Must be calibrated annually and liftin accessories must be visua; examined by a competent person, at intervals
Sample to be destructed to verify materials not exceeding 6 months and by the user immediately before use.
F.O.S. Varies- refer to BS6555/PD6500 (lifts)
Metal end fittings only Note4: SI2006 NO 2184 (Marine version of LOLER) requires that all ship's lifting equipment
Plus N.D.T. Report must be tested by competent person every 5 years.