Professional Documents
Culture Documents
Service Manual
Microwave oven
AVM 954 WH
Model AVM 954 WH
Version 8538 954 12291 Page
Introduction safety 2
Wiring diagram 10 - 11
This documentation is only intended for qualified technicians who are aware of the respec-
tive safety regulations.
Date: 25.03.1996 Subject to modification
Document-No.: 4812 714 10793
25.03.1996 / Page 2 Whirlpool Europe
Doc. No: 4812 714 10793 Customer Service SERVICE
Introduction safety
INTRODUCTION
Despite all the steps taken to make the oven safe, the safety is dependent on the correct installation and the fact
the user understands how to use and maintain the oven.
The information in this section should be used as a reminder that the oven is safe and that anyone who uses it must
first read the instructions for use in order to be able to use the oven correctly and obtain best results.
SAFETY
To avoid injury to yourself and damage to the appliance always work to the following rules when servicing an oven.
Always disconnect the plug from the mains before starting work.
If there is no plug switch off the electric supply at the control box.
When you have finished servicing an oven before you reconnect it to the mains, make sure that:
- all the internal connections are correct
- the wires are insulated and not touching the door or the cabinet or anything sharp
- all the earth connections are electrically and mechanically sound
- do not modify or anyway interfere with the safety devices built-in to the oven
- make sure that each replacement part you use conforms to the manufacturer´s specifications
Do not start a repair if you have any doubt as to your ability to complete it.
PERSONNEL SHOULD NOT BE EXPOSED TO THE MICROWAVE ENERGY WHICH MAY RADIATE FROM THE MAGNETRON,
WAVEGUIDE OR ANTENNA IF THEY ARE IMPROPERLY USED OR CONNECTED. ALL INPUT
AND OUTPUT MICROWAVE CONNECTIONS, WAVEGUIDES, FLANGES AND GASKETS MUST BE SECURE.
NEVER OPERATE THE DEVICE WITHOUT A MICROWAVE ENERGY ABSORBING LOAD ATTACHED.
NEVER LOOK INTO AN OPEN WAVEGUIDE OR ANTENNA WHILE THE DEVICE IS ENERGIZED.
NEVER OPERATE AN OVEN WITH CABINET OFF WITHOUT MEASURING THE MICROWAVE LEAKAGE
AROUND MAGNETRON AND VISIBLE MICROWAVE CONNECTIONS (WELDING JOINTS).
Avoid operating the oven if known components in the interlock system, oven door or microwave
generating assembly are known defective. They must be replaced.
IT IS POSSIBLE TO COME IN CONTACT WITH LETHAL HIGH VOLTAGE WHEN WORKING WITH
HV TRANSFORMER, HV CAPACITOR AND MAGNETRON. THEREFORE NEVER TRY TO MEASURE
THE HIGH VOLTAGE. ALWAYS TAKE UTMOST CARE WHEN PERFORMING ELECTRIC
MEASUREMENTS INSIDE THE OVEN.
Whirlpool Europe 25.03.1996 / Page 3
SERVICE Customer Service Doc. No: 4812 714 10793
Technical data
Technical Requirements
ELECTRICAL
Operating voltage
50Hz
Single phase
2 - phase (CH / DK)
MW 7A
Grill 4,2 A
Crisp 11 A
Crisp 10 A (CH / DK)
Cooker hood 2,3 A / 2,2 A (glow lamps / PL - lamp)
Total 13 A / 12,5 A (cold unit), 11,7 / 11 A (warm unit)
(glow lamps / PL - lamp)
25.03.1996 / Page 4 Whirlpool Europe
Doc. No: 4812 714 10793 Customer Service SERVICE
Fuse (domestic)
DE 16 AL
16 AH
UK 13 A
CH / DK 10 A
SE 16 A
Internal fuse marking T8 A special
Cooker hood characteristics (at rated input voltage) acc to DIN 44971
Timer
90 minutes
Cavity lamp
Long life lamp 1000 hrs, 240 V max 25 W, not replaceble by the customer
MECHANICAL
Weight
Gross 40 kg
Net 36 kg
Installation
40 g
Cavity material
Stainless steel
Functional requirements
TECHNICAL
Noise level
Cooktop illumination
Pos. No. 12NC Code Description Pos. No. 12NC Code Description
001 0 4819 453 49875 Recipe guide Europe n.shown 485 2 4819 466 98742 Guide paper
002 0 4819 442 38359 Cabinet MW 490 0 4819 321 18231 Cable,mains cpl. with clamp
002 2 4819 440 59444 Cover plate upper 493 0 4819 418 79249 Box DA
002 2 4819 442 38357 Cover plate lower MW 493 1 4819 462 79832 Cover DA
005 0 4819 442 38362 Drawer DA 493 2 4819 290 68375 Plate,connector DA
005 1 4819 460 89435 Trim inner le. DA 502 1 4819 209 88041 Microprocessor
005 2 4819 460 89434 Trim inner ri. DA 502 4 4819 101 48142 Potentiometer
005 3 4819 460 89433 Trim outer le. DA 521 0 4819 214 78517 Control unit MW
005 4 4819 460 89432 Trim outer ri. DA 521 1 4819 113 88001 Resistor 100 Ohm
005 5 4819 462 48457 Flap 522 0 4819 214 78545 Unit,electrical
005 6 4819 466 89273 Spacer DA 561 0 4819 282 48247 Thermostat magnetron 145 C
022 0 4819 442 38361 Side panel MW 562 0 4819 282 48248 Thermostat 165 C
024 0 4819 462 38776 Air guide MW 564 0 4819 282 48217 Thermostat grill 120 C
025 0 4819 466 89272 Bar MW 567 0 4819 282 48301 Thermostat
100 0 4819 442 38358 Door cpl. MW 615 0 4819 280 68323 Relay 24V
111 0 4819 462 79886 Cover,handle 617 0 4819 280 68319 Relay
111 1 4819 498 78123 Handle 622 0 4819 276 18273 Switch
111 2 4819 462 79887 Cover 623 0 4819 271 38245 Microswitch DA
111 3 4819 498 78071 Handle DA 623 1 4819 528 38433 Excenter le. DA
124 0 4819 458 58627 Grid MW 623 2 4819 535 98564 Lever le. DA
130 0 4819 271 38148 Unit,pushbutton 623 3 4819 492 58133 Spring DA
130 1 4819 404 78492 Lever 623 4 4819 528 38434 Excenter ri. DA
130 2 4819 466 89172 Clip 623 5 4819 404 79041 Support ri. DA
244 0 4819 458 19898 Stand high 623 6 4819 535 98565 Lever ri. DA
245 0 4819 466 98731 Stand optional 623 7 4819 404 79039 Support le. DA
246 0 4819 466 89065 Crisp plate 623 8 4819 271 38249 Microswitch not shown
246 1 4819 498 69875 Grip crispplate 633 0 4819 271 38145 Microswitch
255 0 4819 466 78218 Turntable glass 651 0 4819 134 28029 Lamp cavity 240V - 25W
263 0 4819 462 38637 Rail 651 0 4819 134 88185 Lamp DA
264 0 4819 535 78131 Crosspiece for turntable 652 0 4819 255 18173 Holder,lamp
301 0 4819 410 28806 Button,push assy. MW 652 1 4819 404 49892 Holder f.lamp holder
301 1 4819 381 18217 Lens MW 652 2 4819 404 79038 Support DA
305 0 4819 404 78851 Holder 652 3 4819 462 79833 Cover,lamp DA
320 0 4819 453 58209 Control panel MW 652 4 4819 466 98985 End block pair DA
334 0 4819 412 58404 Knob WH 652 5 4819 255 18213 Support DA
334 1 4819 413 38126 Clip Knob inner 727 0 4819 515 28248 Fan wheel
352 0 4819 130 38072 Display 727 1 4819 515 28249 Fan wheel
352 1 4819 450 69947 Glass display MW 741 0 4819 442 38363 Conveyor DA
354 0 4819 130 38064 LED 762 0 4819 480 48261 Filter,grease DA
355 0 4819 280 18019 Buzzer 762 1 4819 418 79251 Tray DA
401 0 4819 361 18405 Motor 763 1 4819 458 58628 Grid DA
401 1 4819 361 18406 Motor 765 0 4819 480 48262 Carbon filter MO,DA
401 2 4819 404 79037 Support DA 765 1 4819 404 79043 Support DA
401 3 4819 505 18246 Nut motor 781 0 4819 530 28917 Connect.piece DA
404 0 4819 131 58019 Magnetron 781 1 4819 462 58164 Cover DA
404 2 4819 462 38789 Air guide magnetron 901 0 4819 401 18494 Clamp
406 0 4819 361 78238 Motor 971 0 4819 253 38019 Fuse T8 A
406 2 4819 532 68686 Gasket ring 972 0 4819 253 38006 Fuse T100mA
411 0 4819 148 68076 Transformer 990 0 4819 310 39265 Mounting kit
412 0 4819 145 78181 Transformer,HT MW 993 0 4819 404 79042 Bracket DA
412 1 4819 462 38791 Air guide transformer 993 1 4819 535 38132 Hook DA
420 0 4819 121 48016 Capacitor HT 993 2 4819 466 89274 Insert DA
420 1 4819 404 78491 Clamp 993 3 4819 532 28266 Bushing DA
421 0 4819 121 18197 Filter
426 0 4819 130 38078 Diode HV MW
Exploded view
25.03.1996 / Page 8 Whirlpool Europe
Doc. No: 4812 714 10793 Customer Service SERVICE
Exploded view
Whirlpool Europe 25.03.1996 / Page 9
SERVICE Customer Service Doc. No: 4812 714 10793
Exploded view
Wiring diagram
SERVICE
1003 Control system 1130 Thermostat cavity WHITH DOOR CLOSED
1010 Magnetron 1140 Thermostat magnetron
1030 Mainsfilter 1160 Thermostat gril
1040 Doorswitch secondary 1180 Heatingelement grill
1050 Doorswitch monitor 2000 HT capacitorr
1060 Doorswitch primary 5000 HT transformer
1070 Motor fan 6000 HT diode
1080 Motor turntable
Whirlpool Europe 25.03.1996 / Page 11
SERVICE Customer Service Doc. No: 4812 714 10793
Wiring diagram
S1
S2
BL Blue
BLK Black
BR Brown
GY Grey
RD Red
WT White
Y/G Yellow - green