Professional Documents
Culture Documents
The Preassembled Basic Mist Cooling Kit can easily be expanded from the original kit
of 6 nozzles/3.7 m of mist line to 31 nozzles/18.7 m (or more, dependent upon your
local water pressure available. 3.1 Bar minimum needed). Simply unscrew end cap
from last fitting and attach the extension kit.
Remove
End Cap
Preassembled
MIST COOLING KIT
Mist Coupling
Connect
Expansion Kit
USER’S GUIDE
WARNING: Read all instructions and check kit contents before beginning assembly.
ADDITIONAL ACCESSORIES PARTS LIST
Additional supplies can be purchased through a local retailer or distributor. For
contact details, please email info@orbiteurope.com. Part Qty Description
6.7 m Preassembled ⅜-in Flexible Mist Line -
Model 94168: Preassembled Mist Expansion Kit - Expands the Includes 3 m of feed line, 7 fully rotatable fittings
Basic kit by 3 m 1 inserted in tubing at 61 cm increments,
a hose adapter and a threaded end cap
6 Mist Nozzle
1 Filter (optional)
responsible for consequential or incidental cost or damage caused by the product
failure. Orbit liability under this warranty is limited solely to the replacement or
®
PN 94830-24 rB
Orbit ®
Printers are responsible
1.801.299.5555
orbitonline.com K Dieline
Dims./
Callout Fold
Product
Coverage Glue
for meeting print
production requirements.
Any changes must be
PRINTERS ARE approved by Orbit .
®
∙ used, reproduced or
W: 000.000" H: 8.5" ∙ distributed in any way
without their express
SOFTWARE: Adobe Indesign CS6 H: 000.000" permission.
6. Nail mounting clip into place.
End Cap Mist Fitting
NOTE: The first misting nozzle in your mist system should begin
60 cm from any structure.
7. Continue placing a hanging clip 7.6 cm on each side of each fitting and
hammering in place.
Mounting Clip
Automatic NOTE: Pull tubing slightly while applying each clip to avoid sagging in mist line.
Drain Valve
8. Reconnect system to water source and turn on water to pressurise
the system and begin misting.
Mist Fitting
7.6cm
Mounting Clip