You are on page 1of 2

Trim Fold Fold Fold Fold Trim

Flat size: OPERATING INSTRUCTIONS WARRANTY


13 x 13.75 inches 8 3
330 x 350 mm 1 1. LED Lights STICKERS / DECALS Precision Sensors warrants this product to be free
Do not place decals or stickers, especially metal from defects in material and workmanship for one
2. Ergonomic Handle
decals or stickers on the sensor board, or on the year. This LIMITED WARRANTY does not cover prod-
Folded size: 3. “On” Button stud finder in any place. ucts that are improperly used, abused, or altered.
4. Battery Cover Defective products will be replaced or repaired. If a
2.625 x 6.875 inches 4 5. Detector Housing DISASSEMBLY / TEFLON PADS product is found to be defective within the
67 x 175 mm Do not disassemble the stud finder or remove the warranty period, Precision Sensors will, at its sole
PRECISION
6. Sensor Board
teflon pads that are on the bottom. The stud finder discretion, either repair or replace the defective
7. Bubble Level

SENSORS
2
6 will not operate correctly without the teflon pads product. This limited warranty does not apply to
8. Ruler properly in place.
7 products that are subjected to freight damage,
5
accident, abuse, alteration, misuse, improper
BATTERIES repair, etc. Precision Sensors and Precision Sensors’

ProFinder™ 5000 +
TO OPERATE: SENSING THROUGH DIFFERENT MATERIALS: The ProFinder 5000+ uses 2 AA batteries. Use authorized distributors shall bear no other liability
alkaline batteries only; do not use rechargeable or obligation under this warranty.
Moisture batteries. Replace both batteries at the same time.
The scanned surface should be clean and dry. Paint Precision Sensors does not authorize any person or
PROFESSIONAL and wallpaper need to be completely dry before REPLACING THE BATTERIES representative to assume or grant any other
STUD FINDER scanning for studs. It may take up to 2 weeks for • Remove battery cover, by warranty or obligation with the sale of this
wallpaper to dry enough to detect studs. sliding the cover to the product. Precision Sensors’ limited warranty is valid
left and lifting. Remove only if you retain proof of purchase from Precision
Curved Surfaces batteries and dispose of Sensors or a Precision Sensors authorized dealer
IMPORTANT: READ BEFORE USING. There is a minor degree of curvature in the walls of the batteries properly. Please recycle. for this product. If you purchase this product from
SAVE THESE INSTRUCTIONS. most homes and buildings. The curvature is small any other source, your purchase is “AS IS,” which
enough that it may not be noticed. The ProFinder • Replace with 2 new AA alkaline batteries. means Precision Sensors grants you no warranty,
Operating/Safety Instructions 5000+ can detect objects through curved surfaces and that you, not Precision Sensors, assume the
because the ProFinder 5000+ has a sensor board • Replace battery cover. Close battery cover by entire risk of the quality and performance of this
•H
 old the stud finder by the handle. Do not touch that bends slightly to match the contour of most sliding the cover to the right until it snaps product. The warranty period for any replaced and/
PRECISION SENSORS PROFINDER 5000+ the detector outside of the handle area while walls. Press the stud finder firmly against the into place. or repaired part under this warranty shall expire at
scanning. surface and the sensor board will match the the end of the original warranty period.
Congratulations on selecting the most advanced contour of the surface, and provide the best STORAGE
wall sensor on the market. Your PRECISION •P
 lace the ProFinder 5000+ firmly against the reading. Store the stud finder in a clean, dry place at room ALL EXPRESS AND IMPLIED WARRANTIES FOR THIS
SENSORS PROFINDER 5000+ incorporates surface and press the “on” button. Continue to temperature. Protect against direct sunlight and PRODUCT, ARE LIMITED IN DURATION TO THE
advanced technology that precisely senses the hold the “on” button down. Foil-Backed Insulation moisture. WARRANTY PERIOD, AND NO WARRANTIES,
surface in thirteen locations simultaneously, then Although foil covered insulation is not very WHETHER EXPRESS OR IMPLIED, WILL APPLY AFTER
instantly identifies the location(s) of hidden • L ED lights will immediately display the location of common, metal foil can cause inconsistent ENVIRONMENTAL CONDITIONS THIS PERIOD. THIS WARRANTY IS EXCLUSIVE AND
object(s). It is the easiest-to-use, fastest, and most any hidden objects. readings with all electronic stud finders, including IN LIEU OF ALL OTHER OBLIGATIONS, LIABILITIES
accurate stud finder on the market. the ProFinder 5000+. Storage Temperature 0°F to 120°F OR WARRANTIES. In no event shall Precision
• The “on” button may be pressed before or after (-18°C to 50°C) Sensors or its licensed distributors be liable or
SAFETY RULES FOR THE PROFINDER 5000+ placing the stud finder on the surface to be Metallic Content in Wallpaper responsible for INCIDENTAL OR CONSEQUENTIAL
scanned. The stud finder will detect studs without Wallpaper with metallic content can block the Operating Temperature 32°F to 110°F DAMAGES or for any other direct or indirect
WARNING: Read all instructions before use. sliding the stud finder across the wall, but will also detector’s signals. (0°C to 43°C) damage, loss, cost, expense or fee. Some states do
Failure to follow safety instructions may result operate correctly if it is slid across the wall. not allow the exclusion or limitation of incidental
in electric shock, fire, and/or serious injury Textured Walls and Acoustic Ceilings Storage Humidity 0% to 90% or consequential damages, so this exclusion or
and death. The ProFinder 5000+ is capable of detecting studs relative humidity limitation may not apply to you. This warranty
Fold through many textured surfaces. The stud finder (non-condensing) gives you specific legal rights and you may also
SAVE THESE INSTRUCTIONS should be placed firmly against the surface for best have other rights that vary from state to state.
results. Operating Humidity 0% to 90%
WARNING: It is possible that there may be wood, relative humidity US Patents 8,476,912 8,593,163 8,669,772
metal, wiring, or other objects behind the surface Lath and Plaster (non-condensing) 8,736,283 8,791,708 8,836,347 8,884,633
that are not detected. It is also possible that the Irregularities in plaster thickness and variations in US and Foreign Patents Pending.
stud finder may detect pipes, wires, or other construction materials can make it difficult to DISPOSAL
objects that the user may not want it to detect. The locate studs behind lath and plaster walls. Also, if Stud finders and packaging should be sorted
stud finder is designed to detect any inconsistency the plaster has a mesh reinforcement, the stud for recycling.
without identifying the nature of the inconsistency. finder may not be able to detect through the metal
The stud finder does not identify what type of mesh. Although many users have success with the FCC PART 15 CLASS B REGISTRATION
object it detects. The illuminated LEDs may ProFinder 5000+ on lath and plaster walls, there is WARNING
indicate the location of many different features • I f more than one hidden object is present, the no guarantee the ProFinder 5000+ will work on all This device complies with Part 15 of FCC rules.
including, but not limited to, studs, beams, water stud finder will show the location of more than lath and plaster walls. Operation is subject to the following two
pipes, gas pipes, wires, an inconsistency in the one hidden object. conditions:
surface material or paint, etc. Tile, Flooring, Roofing, and Outside of House 1. This device may not cause harmful
The ProFinder 5000+ works by measuring the interference, and
WARNING: TURN OFF all gas, water, and electric density of material behind the sensors to 2. This device must accept any interference
power before using any drilling or penetrating determine the location of studs. Due to the received, including interference that may cause
devices or equipment including drills, saws, variability in the density of materials in tile, undesired operation.
routers, hammers, nails, screws, etc. flooring, roofing, and on the outside of the house,

we do not recommend the ProFinder 5000+ for use


WARNING: The stud finder alone should not be in these applications. PS5000+E1 (09/15)

relied upon exclusively to locate objects behind a


scanned surface. Use other sources of information TROUBLESHOOTING
to help locate objects. Other sources of informa- CONDITION PROBABLE CAUSE SOLUTION
tion may include, but is not limited to, construction No LED lights come on. Weak battery. Replace with 2 new AA alkaline batteries.
plans, visible points of entry of pipes, location of
Stud finder only works momentarily. The “on” button isn’t being held down. Hold the “on” button down until you have completed your scan.
switches and outlets, and standard 16" and 24"
stud spacing practices. • L ED lights indicate the width of hidden object(s). The LED lights are indicating the location of The ProFinder 5000+ indicates the location of inconsistencies. Look for evenly placed studs on either side (16", 24", on center, etc.) Scan
pipes and wires, not just studs. The LED lights may indicate the location of a pipe, electrical above the location and below the location to confirm results. Use caution
wiring, other objects near the surface being scanned, or an before penetrating wall. See the SAFETY RULES FOR THE PROFINDER
FAILURE TO TAKE THESE AND OTHER inconsistency in the surface material or paint, etc. 5000+.
NECESSARY PRECAUTIONS COULD RESULT Difficulty starting a scan near doors and Double studs, triple studs and solid headers are often present Begin the scan away from the window or door, then move the stud finder to
IN ELECTRIC SHOCK, FIRE, AND/OR SERIOUS windows. around doors and windows. The stud finder requires the the area around the window or door. For best results, keep stud finder 3" away
presence of a region without studs to correctly identify studs. from wood trim, outlets, switches, etc.
INJURY AND DEATH.
Stud finder doesn’t work through new wall The moisture in the wall after wall papering can block the Wait until the wallpaper is dry. It may take up to 2 weeks for the paper to
paper. stud finder’s signal. dry sufficiently.
Clean
My house was built prior to about 1960. The Older houses that were built with lath and plaster, instead of Try using the stud finder at a higher point on the wall, or a lower point on
Before turning on, ensure that the stud finder is walls are lath and plaster. The stud finder sheet rock, often have too much inconsistency in the walls the wall.
clean and dry. If necessary, wipe the stud finder dry doesn’t work very well anywhere in my house. for the detector to work reliably.
using a clean cloth. If the detector is wet or dirty it Inconsistent readings. Curved surface. Press the stud finder firmly against the wall so that the contour of the
may not operate properly. sensor board matches the slight contour of the wall.
Anomaly in the surface material. Test at a higher location, or lower location on the wall.
Temperature
Sometimes after scanning the wall for a period of time the Release the button and press the button again.
If the stud finder is subject to a significant readings seem to be less consistent.
temperature change, allow it adjust to the ambient When I put my hand in front of the sensor The stud finder is designed for detecting features in walls, Place the stud finder on the wall to detect hidden features.
temperature before using. The entire area of the •O
 n some surfaces it may be helpful to slide the board, the readings are not what I would not hands.
sensor board should be at a similar temperature for stud finder up and down to confirm the location expect.
best operation. of a stud. The LED lights sometimes seem to light up Wires, pipes, or other construction inconsistencies can cause Test at points on the wall that are higher, or lower. The stud finder may also
sporadically or inconsistently. erratic or erroneous readings. Features on the opposite side work best if it is used more than 3 inches away from metal objects such as
of a wall may also be a source of inconsistent readings. outlets, light switches, etc.

09-15-costco-english-instructionsheet-PS5000+E1.indd 1 11/1/2015 10:09:23 AM


Trim Fold Fold Fold Fold Trim

Flat size: INSTRUCCIONES DE FUNCIONAMIENTO GARANTÍA


13 x 13.75 inches 8 3
330 x 350 mm 1 1. Luces LED ETIQUETAS Y ENGOMADAS Precision Sensors garantiza que este producto está
2. Agarradera Ergonómica Para no interferir con la capacidad de detección del libre de defectos de material y mano de obra durante
detector, no coloque etiquetas, pegatinas, o un año. Esta garantía limitada no cubre los productos
Folded size: 3. Botón
engomadas en cualquier parte del detector. que sean incorrectamente utilizados, abusados o
4. Cubierta de Pila
2.625 x 6.875 inches 4 5. Detector - Tapa
alterados. Productos defectuosos serán reemplaza-
ALMOHADILLAS DE TEFLÓN dos o reparados. Si un producto es defectuoso
67 x 175 mm
PRECISION
6. Tabla de Sensor No desmantele el detector, ni quite las dentro del plazo de garantía, Precision Sensors a su
7. Nivel almohadillas de teflón en la parte inferior. Si las entera discreción, reparará o reemplazará el

SENSORS
2 almohadillas de teflón no estan correctamente producto defectuoso. Esta garantía limitada no se
6
8. Regla
7 ubicadas el detector no funcionará. aplica a los productos que están sujetos a daños de
5
transporte de mercancías, accidente, uso indebido,
PILAS alteración, reparación indebida, etc. Precision

ProFinder™ 5000 +
PARA UTILIZAR: DETECCIÓN A TRAVÉS DE DIFERENTES MATERIALES: El ProFinder 5000+ utiliza 2 pilas AA. Utilice sólo las Sensors y distribuidores autorizados de Precision
pilas alcalinas. No utilice pilas recargables. Re- Sensors no llevarán a ninguna otra responsabilidad
Humedad emplace ambas pilas al mismo tiempumedado. ni obligación en virtud de esta garantía.
La superficie escaneada debe estar limpia y seca.
DETECTOR DE VIGAS Pintura y papel tapiz deben estar completamente REEMPLAZO DE LAS PILAS Precision Sensors no autoriza a cualquier persona o
PROFESIONAL secos antes del escaneo. Puede tomar hasta 2
semanas para que el papel tapiz se seque lo suficiente
• Quite la cubierta de pila representante a asumir o conceder cualquier otra
deslizándola hacia la garantía u obligación con la venta de este producto.
como para detectar las vigas. izquierda y levantándola. Garantía limitada de Precision Sensors es válida sólo
Retire las pilas y deseche si conserve el comprobante de compra de Precision
IMPORTANTE: LEA ANTES DE USAR GUARDE Superficies Con Curvas de las baterías correctamente. Por favor recicle. Sensors o de un distribuidor autorizado de Precision
ESTAS INSTRUCCIONES Hay un grado menor de curvatura en las paredes de la Sensors. Si usted compra este producto de cualquier
Instrucciones de Funcionamiento/Seguridad mayoría de hogares y edificios. Tal curvatura es lo • Reemplace con dos pilas alcalinas AA nuevas. otra fuente, su compra es “tal cual,” lo que significa
suficientemente pequeña para no ser percibida que Precision Sensors no le otorga ninguna garantía,
normalmente. El ProFinder 5000+ puede detectar • Coloque la cubierta de la pila. Cierre la cubierta de y que usted, no Precision Sensors, asume todos los
PRECISION SENSORS PROFINDER 5000+ • Sujete el detector por la agarradera. No toque el objetos a través de superficies con curvas debido a
pila deslizándola hacia la derecha, hasta que encaje riesgos de la calidad y el rendimiento de este
detector fuera de la agarradera durante el escaneo. que la tabla de sensor del ProFinder 5000+ es flexible
en su sitio. producto. El período de garantía por cualquier parte
Felicitaciones por haber seleccionado el sensor de permitiendo coincidir con el contorno de la mayoría
reparado o reemplazado bajo esta garantía expirará
vigas más avanzado en el mercado. Su PRECISION • Coloque el ProFinder 5000+ firmemente contra la de las paredes. Coloque el detector firmemente contra
ALMACENAMIENTO al final de la garantía original.
SENSORS PROFINDER 5000+ incorpora tecnología superficie y aprieta el botón. Mantenga la mano en la superficie y la tabla de sensor se coincidirá con el
Guarde el detector en un lugar limpio y seco a una
avanzada que detecta con precisión la superficie en el área de la agarradera con el botón apretado. contorno de la superficie para proporcionar el mejor
temperatura ambiente. Protégelo contra la humedad TODAS LAS GARANTÍAS EXPRESAS E IMPLÍCITAS
trece lugares simultáneamente e indicainmediata- resultado.
y la luz solar directa. PARA ESTE PRODUCTO, ESTÁN LIMITADAS EN
mente la posición del objeto u objetos ocultos. Es el • Las luces LED mostrarán inmediatamente la DURACIÓN A EL PERÍODO DE GARANTÍA, Y NINGUNA
detector más fácil de usar, más rápido, y más preciso Aislamiento con Respaldo de Aluminio
ubicación de cualquier objeto(s) oculto(s). CONDICIONES AMBIENTALES GARANTÍA, EXPRESA O IMPLÍCITA, SE APLICARÁN
en el mercado. Aunque aislamiento que esta cubierto de papel de
DESPUÉS DE ESTE PERÍODO. ESTA GARANTÍA ES
aluminio no es muy común, lámina de metal puede
• Se puede apretar el botón antes o después de Temperatura de Almacenamiento: EXCLUSIVA Y EN LUGAR DE TODAS LAS DEMÁS
NORMAS DE SEGURIDAD PARA PROFINDER 5000+ causar resultados inconsistentes con todos los
colocar el detector en la superficie. El detector 0°F to 120°F (-18°C to 50°C) OBLIGACIONES, O GARANTÍAS.
buscadores de vigas electrónicas, incluyendo el
detectará objetos ocultos sin deslizar el detector a
ADVERTENCIA: Lea todas las instrucciones antes ProFinder 5000+.
través de la pared, pero también funcionará Temperatura de Funcionamiento:  En ningún caso Precision Sensors o sus distribuidores
de usar. El no seguir las instrucciones de correctamente si se desliza a través de la pared.
Contenido Metálico en Papel Tapiz 32°F to 110°F (0°C to 43°C) autorizados serán responsables para daños
seguridad puede resultar en descarga eléctrica,
El papel tapiz metálico puede bloquear las señales del INCIDENTALES O CONSECUENCIALES o de otros daños
incendio, lesiones graves, o la muerte.
detector, si haya demasiado metal presente. Humedad de Almacenamiento: directos o indirectos, pérdida, costos, gastos, u otros.
0% to 90% humedad relativa (sin condensación) Algunos estados no permiten la exclusión o
GUARDE ESTAS INSTRUCCIONES
Paredes Con Textura Y Techos Acústicos limitación de daños incidentales o consecuentes, por
Fold Humedad de Funcionamiento: lo que esta exclusión o limitación no podría aplicarse.
ADVERTENCIA: Es posible que haya madera, metal, El ProFinder 5000+ es capaz de detectar vigas a través
de muchas superficies con textura. El detector debe 0% to 90% humedad relativa (sin condensación) Esta garantía le otorga derechos legales específicos y
cableado u otros objetos no detectados detrás de la
ser colocado firmemente contra la superficie para usted también puede tener otros derechos que
superficie. También es posible que el detector pueda
obtener mejores resultados. ELIMINACIÓN varían de estado a estado.
detectar tuberías, cables u otros objetos que el
Detectores deben clasificarse para el reciclaje.
usuario no puede detectar. El detector está diseñado
Listón y Yeso US Patents 8,476,912 8,593,163 8,669,772
para detectar cualquier discrepancia sin identificar su
Irregularidades en el espesor del yeso y las variaciones ADVERTENCIA DE FCC PARTE 15 8,736,283 8,791,708 8,836,347 8,884,633
naturaleza. El detector no identifica el tipo de objeto
en materiales de construcción pueden hacer difícil CLASE B REGISTRO Patentes Pendientes.
que se detecta. Las luces iluminadas LED pueden
encontrar vigas detrás de las paredes de listón y yeso. Este aparato cumple con las reglas Parte 15 de la
indicar la posición de muchas diferentes discrepan-
Además, si el yeso tiene un refuerzo de malla, es capaz FCC. Su operación testá sujeta a las siguientes dos
cias incluyendo, pero no se limita a vigas, tuberías de • Si haya más de un objeto oculto, el detector puede que el buscador no detectará las vigas a través de la condiciones:
agua, tuberías de gas, cables, una discrepancia en el mostrar la posición de más de un objeto oculto. malla metálica. Aunque muchos usuarios tienen éxito
material del superficie o pintura, etc.
con el ProFinder 5000+ en paredes de listón y yeso, no 1. Este aparato no puede causar interferencia
hay ninguna garantía de que el ProFinder 5000+ dañina, y
ADVERTENCIA: Desactive (apague) toda fuente de
funcionará en todos los paredes de listón y yeso. 2. Este aparato debe aceptar cualquier interferencia
gas, agua y energía eléctrica antes de utilizar
recibida, incluyendo la interferencia que pueda
cualquier producto o equipo de perforación Baldosas, Pisos, Techos, y en el Exterior de la Casa causar operación no deseada.
incluyendo taladros, sierras, enrutadores, martillos, El ProFinder 5000+ funciona mediante la medición de
clavos, tornillos, etc. la densidad del material detrás de los sensores para
determinar la ubicación de vigas. Debido a la
ADVERTENCIA: El detector por si solo no debe variabilidad en la densidad de material en baldosas
utilizarse exclusivamente para localizar objetos pisos, techos, y en el exterior de la casa, no recomen-
detrás de una superficie escaneada. Utilice otras damos el ProFinder 5000+ para su uso en estas
fuentes de información para ayudar a localizar aplicaciones. PS5000+S1 (09/15)
objetos. Otras fuentes de información pueden incluir,
pero no se limita a, planes de construcción, puntos SOLUCIÓN DE PROBLEMAS
de entrada de tuberías visibles, posición de LA CONDICIÓN CAUSA PROBABLE SOLUCIÓN
interruptores, y espaciado de vigas estándar de • Luces LED indican la anchura de los objetos ocultos. Las luces LED no se encienden. Pilas débiles. Reemplazar con 2 pilas alcalinas AA nuevas.
16 “ y 24”.
Detector sólo funciona momentáneamente. El botón no se mantiene presionado. Hasta que haya completado la análisis, mantenga apretado el botón.

EL NO TOMAR ESTAS Y OTRAS PRECAUCIONES Las luces LED indica que la ubicación de tuberías y El ProFinder 5000+ indicará la ubicación de cualquier incoherencia. Tenga cuidado antes de penetrar el pared. Consulte las NORMAS DE SEGURIDAD DEL
cables, además de vigas. PROFINDER 5000+.
NECESARIAS PUEDE RESULTAR EN DESCARGA
ELÉCTRICA, INCENDIO, LESIONES GRAVES, O LA
MUERTE. Dificultad iniciar una escaneo cerca de puertas y Vigas dobles, vigas triples, y encabezados sólidos a menudo están Comenzar el análisis lejos de la ventana o puerta y, a continuación, mover el detector al
ventanas. presentes alrededor de puertas y ventanas. El detector requiere la área alrededor de la ventana o puerta. Para mejores resultados mantenga el ProFinder
Limpiado presencia de una región sin vigas para identificar correctamente las 5000+ a siete centímetros de distancia de moldura de madera, tomas, switches, etc.
vigas.
Antes de activar, asegúrese de que el detector esté
Detector no funciona a través de papeles pintados. La humedad en la pared después de colocar papeles pintados puede Espere hasta que el papel pintado esté seco. Puede tomar hasta 2 semanas para secar
limpio y seco. Si es necesario, limpie el detector con bloquear señales del detector. suficientemente.
un paño limpio. Si el detector está mojado o sucio no
Mi casa fue construida antes de aproximadamente Las casas más antiguas que fueron construidas con el listón y yeso, en Pruebe a utilizar el detector en un punto más alto en la pared, o un punto más bajo en
se puede operar correctamente. 1960. Las paredes son de listón y yeso. El detector no lugar de la lámina de yeso , a menudo tienen demasiada incoherencia la pared.
funciona muy bien en mi casa. para el detector trabaje de forma fiable.
Temperatura Escaneos inconsistentes. Superficie curvada. Empuje el detector firmemente contra la pared para que la tabla de sensor coincida
Si el detector está sujeto a un cambio significativo de con el contorno leve de la pared.
temperatura, permite que se ajusta a la temperatura • Se puede deslizar el detector arriba y abajo para Anomalía en el material de la superficie. Pruebe en una posición superior, o en un lugar inferior en la pared.
ambiente antes de utilizarlo. La debe estar en una confirmar la posición de las vigas. A veces después de escanear por un tiempo el detector parece menos Suelte el botón y vuelve a apretar el botón.
temperatura similar para mejor funcionamiento. consistente.
Cuando coloco la mano en frente de la tabla de sensor, El detector está diseñado para detectar características en las paredes, Coloque el detector en la pared para detectar características ocultas.
el detector no funciona como yo esperaría. no de las manos.
A veces las luces LED iluminan en una forma que Cables, tuberías, u otras inconsistencias de construcción puede causar Prueba a puntos en la pared que son superiores o inferiores. También el detector puede
aparece inconsistente. las luces LED a iluminar en una forma que aparece errático. Cosas del funcionar mejor si se utiliza más de 10 centímetros de distancia de objetos de metal,
lado opuesto de un muro también pueden ser una fuente de como tomas de corriente, switches de luz, etc.
inconsistencias.

09-15-costco-spanish-instructionsheet-PS5000+S1.indd 1 10/29/2015 2:00:27 PM

You might also like