Professional Documents
Culture Documents
潍柴动力WISE15C欧五针脚图
WEICHAI WISE15C Euro V Terminal Diagram 排放Emission: Euro4/Euro5 页码Page: 1 / 1
电源 -BAT-
X1-01 电源 +BAT+
X1-02
Battery - 电源 -BAT-
Battery +
电源 +BAT+
X1-04 X1-03 25A
电源 -BAT- 电源 +BAT+
X1-06 X1-05 T15
CAN0H
X1-42
T15 Ignition switch Ignition switch
CAN-1939 Communication(built in 120Ω) X1-59
CAN0L 5A
CAN-1939通讯(内置120Ω电阻) X1-43 T50 Starter switch
X1-58
Shielding wire
X1-44 PWM
X1-19 发动机转速输出Engine speed output ()
CAN1H
CAN-Diagnosis and flash(Built in 120Ω) X1-45 X1-68 巡航加 Cruise control (+)
CAN1L
刷写诊断CAN(内置120Ω) X1-46 X1-51
巡航减 Cruise control (-) ECU专用低功率继电器,请勿与其他负载公用
1 5V_APP1
X1-24 X1-63 ECU-specific low-power relay, do not share
2 APP1
巡航关闭 Cruise control (OFF) with other loads
X1-07
3 GND
X1-25
X1-64 巡航复位 Cruise control (RESUME)
Accelerator pedal(Double potentiometer) 5V_APP2
4 X1-28
双模拟量油门踏板 主刹车开关 Main brake switch
5 APP2
X1-08 X1-61
整
X1-60
远程油门踏板 4 支腿开关 Constant Engine Speed 1 X1-45 CAN1H(Flash)
X1-47
RmtAPP2 4 BAT- Battery-
车
5
X1-10 X1-56
二级缸内制动开关 Two stage cylinder brake switch
6 X1-42 CAN0H(Communication)
6
线
起动机继电器(集成在发动机上)
9 X1-46 CAN1L(Flash)
X1-22
Starter Relay(Installed in starter) 14 X1-43 CAN0L(Communication)
束
Signal 16 BAT+ Battery+
X1-13
Multiple state switch X1-72
CylinderBrake1 signal
18Pins 5# 一级缸内制动CylinderBrake1
多态开关 16P OBD connector & defination
Vehicle Plug
20
Drive signal A
X1-41
X1-21
T. feedback signal
24V
9
尿素泵驱动信号&温度反馈信号
T. feedback & Drive signal T. feedback & Drive signal
整车厂连接
10
Moter电机
5
发动机厂连接
Heater
Signal 尿素泵加热继电器
M
12
Signal
进气节流阀 O_T_ETHR-
X2-02 X2-39 12 12
Reverse valve换向阀
5V 5V
13
2
X2-28 13
Pressure Signal Pressure Signal P
14 14
3
V_V_5V_TPPF1 X2-69
+
X2-62
throttle plate position feedback sensor 1 GND GND
U
15 15
4
I_A_TPPF1
进气节流阀位置反馈传感器1 X2-08 X2-29
pressure sensor
G_R_TPPF1 压力传感器
X2-31
-
发 X2-24
24V, Current≤3A
1 1
24V, Current≤3A
动
24V, Current≤4A Current(X2_56+X2_74)≤6A 24V, Current≤4A Current(X2_56+X2_74)≤6A
X2-74 2 2
Urea tank heating valve
机
Urea tank heating valve 尿素箱水加热电磁阀
Urea tank heating valve
5V X2-75 6 6
X2-51
1
线
信号线 Signal
Fan speed sensor X2-43 4 4 接X1-38 Connect X1-38
3
地线 GND
风扇转速传感器(霍尔) Cylinder inside Brake realy2 二级缸内制动CylinderBrake2
X2-30
接X1-72 Connect X1-72
束
5 5
2
and temperature sensor X2-26 24V, Current≤4A, Current(X2_56+X2_74)≤6A 24V, Current≤4A, Current(X2_56+X2_74)≤6A
地线 GND 1、电控硅油风扇,ECU针脚直接与风扇接插件连接
2
器,ECU控制继电器。
t 信号线 Signal Fan relay1 Fan relay1 电控硅油风扇/(电磁风扇继电器1)
X2-27 X2-40 9 9
Coolant temperature sensor
1
U
X2-76 10 10 电磁风扇继电器2 connected with fan connector
P 5V 2. Electromagnetic clutch fan, the customer needs to
X2-52
3
Rail pressure sensor 信号线 Signal match the relay with continuous diode, ECU control relay.
X2-66
1 2
地线 GND
共轨压力传感器 U X2-55
P&t 5V
X2-63
3
24V output
Oil pressure and temperature sensor 压力信号线 Press. Signal X2-03 Metering Unit 18孔接插件,图中数字为接插件孔位实际序号
X2-67
温度信号线 Temp Signal Negative drive
流量计量单元 18-Pins connector, the figure in the map is the actual serial number of the
2 4
机油压力温度传感器 X2-25
X2-06
地线 GND
Inj1H
connector hole
X2-47
U X2-12
1
X2-13
Inj1L Injector 1, Bank 1
n
Crankshaft speed sensor 正端 Posive Inj2H
潍柴公端:
2
X2-59 X2-14
曲轴转速(打孔) 负端 Negative Inj2L Injector 2, Bank 1 接插件Connector: 1-1564526-1,盖子Cover:1670866-1;
X2-60 X2-15
1
U
屏蔽 Shield Inj3H 端子Terminal:1241380 -1 (0.5-1.0),1418884-1 (1.0-1.5);
X2-73 X2-16
Injector 3, Bank 1
Camshaft speed sensor n 正端 Posive X2-17
Inj3L 防水塞Waterproof plug:963530-1(0.5-1.0),964972-1 (1.0-1.5);
盲堵Blind block:963531-1;厂家Factory:泰科
2
X2-41
(Magnetoelectric ) 负端 Negative
X2-42 Inj4H
X2-18
凸轮轴转速(磁电式/凸齿)
1
U
屏蔽 Shield Inj4L Injector 4, Bank 2
X2-35 X2-19
Inj5H
二者选其一 X2-20
Inj5L Injector 5, Bank 2
Pick one of two n 5V
3
X2-53 X2-21
Camshaft speed sensor (Hall) 信号 Signal X2-22
Inj6H
X2-41 Inj6L Injector 6, Bank 2
凸轮轴转速(霍尔式/凸齿) Note注:
X2-23
2
接地 GND
X2-35
1