Professional Documents
Culture Documents
Product Specification
(Preliminary)
PREP
PRE PARED BY CHECKED BY APPROVED BY
PRODUCT CONTENTS
PHYSICAL DATA
ABSOLUTE MAXIMUM RATINGS
EXTERNAL DIMENSIONS
ELECTRICAL CHARACTERISTICS
TIMING OF POWER SUPPLY
ELECTRO-OPTICAL CHARACTERISTICS
INTERFACE PIN CONNECTIONS
COMMAND TABLE
INITIALIZATION CODE
SCHEMATIC EXAMPLE
RELIABILITY TESTS
OUTGOING QUALITY CONTROL SPECIFICATION
CAUTIONS IN USING OLED MODULE
NOTE:
Permanent device damage may occur if ABSOLUTE MAXIMUM RATINGS are
exceeded.
Functional operation should be restricted to the conditions as detailed in the operational
sections of this data sheet. Exposure to absolute maximum rating conditions for extended
periods may affect reliability.
E-mail: jack@liyuan-elec.com
EXTERNAL DIMENSIONS
5
Dots detail
Scale 10x
NOTES:
1. OPERATING TEMP:-40 ° C TO 70° C
2. STORAGE TEMP: -40 ° C TO 80° C
3. VIEWING DIRECTION:ALL
4. OLED DRIVE IC:SH1107G LiYuan Electronics Co.,Ltd.
5. DISPLAY COLOR: White
6. UNSPECIFIED TOLERANCES: ±0.2mm.
7. ( ) MEANS: DIMENSION FOR REFERENCE
LY112WG22-128128
8. THE PROTECTIVE FILM OF OLED MUST BE
REMOVED BEFORE ASSEMBLY BY CUSTOMER
1/1
LI YUAN ELECTRONICS CO., LTD.
LY112WG22-128128
LI YUAN ELECTRONICS CO., LTD.
ELECTRICAL CHARACTERISTICS
◆DC Characteristics
Condition(Unless otherwise specified): Voltage referenced to VSS VDD=1.65V to 3.5V Ta = 25℃
Items Symbol Min Typ. Max Unit
Supply Logic VDD 1.65 3.0 3.5 V
Voltage Operating VPP 7.0 11.0 16.5 V
Input High Voltage VIH 0.8 x VDD - VDD V
Voltage Low Voltage VIL VSS - 0.2 x VDD V
Output High Voltage VOH 0.8 x VDD - VDD V
Voltage Low Voltage VOL VSS - 0.2 x VDD V
tAS8 tAH8
CS tF tR
tCYC8
WR , RD tCCLW tCCHW
tCCLR tCCHR
tDS8 tDH8
D0~D7
(WRITE)
tACC8 tCH8
D0~D7
(READ)
tR Rise time - - 15 ns
tF Fall time - - 15 ns
tR Rise time - - 15 ns
tF Fall time - - 15 ns
RESB
tR
Internal circuit
status During reset End of reset
Power on sequence :
Display on
(AFH)
trpw=+/- no limit
VDD
VPP
t1=min. 10us
t2=min. 12us
COM/SEG
VPP t=100ms
Note:
1.L=80 cd/m2 is based on VDD=3.0V ,VPP=11.0V, contrast command setting 0xA0;
2. Contrast ratio is defined as follows:
Photo – detector output with OLED being “white”
Contrast ratio =
Photo – detector output with OLED being “black”
3. Life Time is defined when the Luminance has decayed to less than 50% of the initial
Luminance specification. (Odd and even chess board alternately displayed)
(The initial value should be closed to the typical value after adjusting.)
Table:1
BS[2:1] Interface
00 4-line SPI
01 I2C
11 8-bit 8080
10 8-bit 6800
Note: *Do not use any other commands, or the system malfunction may result.
*When the display OFF command(AEH) is executed, power saver mode(Sleep mode) will be entered.
This mode stops every operation of the OLED display system, and can reduce current consumption nearly to a
static current value if no access is made from the microprocessor. The internal status in the sleep mode is as
follows:
1) Stops the oscillator circuit
2) Stops the OLED drive and outputs Hz as the segment/common driver output.
3) Holds the display data and operation mode provided before the start of the sleep mode.
4) The MPU can access to the built-in display RAM.
Write_Command(0xAF); //Display ON
}
NOTE:
1.The VCOMH capacitor is recommended to use tantalum capacitor to reduce noise.
2. The capacitor and the resistor value are recommended value. Select the appropriate value
against module application.
Note:1) For each reliability test, the sample quantity is 3, and only for one test item.
2) The HTHHS test is requested the Pure Water(Resistance>10MΩ).
3) The test should be done after 2 hours of recovery time in normal environment.
A B C
2 The luminance and color coordinate inspection : By PR705 or BM-7 or the equal
equipments, in the dark room, under 25±5℃.
◆Inspection Criteria
1 Major defect : AQL= 0.65
Item Criterion
1. No display or abnormal display is not accepted
Function Defect
2. Open or short is not accepted.
3. Power consumption exceeding the spec is not accepted.
Outline Dimension Outline dimension exceeding the spec is not accepted.
Glass Crack Glass crack tends to enlarge is not accepted.
2 Minor Defect : AQL= 1.5
E-mail: jack@liyuan-elec.com 18 LY112WG22-128128
LI YUAN ELECTRONICS CO., LTD.
Item Criterion
Size (mm) Accepted Qty
Spot Area A + Area B Area C
Defect
Φ≦0.07 Ignored
(dimming
Y 0.07<Φ≦0.10 3
and
lighting 0.10<Φ≦0. 15 1 Ignored
X
spot) 0.15<Φ 0
Note : Φ= ( x + y ) / 2
Line L ( Length ) : mm W ( Width ) : mm Area A + Area B Area C
Defect / W≦0.02 Ignored
(dimming
L≦3.0 0.02<W≦0.03 2
and
L≦2.0 0.03<W≦0.05 1 Ignored
lighting
line) / 0.05<W As spot defect
Remarks: The total of spot defect and line defect shall not exceed 4 pcs. The
distance between two lines defects must exceed 1 mm
Polarizer Stain which can be wiped off lightly with a soft cloth or similar
Stain cleaning is accepted, otherwise, according to the Spot Defect and the
Line Defect.
1. If scratch can be seen during operation, according to the criterions
of the Spot Defect and the Line Defect.
2. If scratch can be seen only under non-operation or some special
angle, the criterion is as below :
Polarizer L ( Length ) : mm W ( Width ) : mm Area A + Area B Area C
Scratch / W≦0.02 Ignore
3.0<L≦5.0 0.02<W≦0.04 2
L≦3.0 0.04<W≦0.06 1 Ignore
/ 0.06<W 0
Size Area A + Area B Area C
Φ≦0.20 Ignored
Polarizer Y 0.20<Φ≦0.30 2
Air Bubble
0.30<Φ≦0.50 1 Ignored
X
0.50<Φ 0
x ≤ 1.5
y ≤ 1.5
z ≤t
(mm)
x ≤a/8
y ≤ 0.7
z ≤t
◆ Limited Warranty
Unless relevant quality agreements signed with customer and law enforcement, for a period of
12 months from date of production, all products (except automotive products) Li Yuan will
replace or repair any of its OLED modules which are found to be functional defect when
inspected in accordance with Li Yuan OLED acceptance standards (copies available upon
request). Cosmetic/visual defects must be returned to Li Yuan within 90 days of shipment.
Confirmation of such date should be based on freight documents. The warranty liability of
Li Yuan is limited to repair and/or replacement on the terms above. Li Yuan will not be
responsible for any subsequent or consequential events.