So this day I decide to change the oil of my motorcycle. The first thing that I did is prepare the tools and things that we needed like drain pan, rags, funnel, strap wrench, and of course the oil and filter. If the bike is warmed up, you should cool it down so you’re not working with scalding oil then the motor cycle must be in center stand then I take the rag and wipe on the engine around the oil filter and the drain plug. Once the area cleaned up I put the drain pan under the engine and then loosen you drain plug slowly then I unscrew it by hand. Once the oil is drained out of the engine the next thing that I did is remove the oil filter and after we totally drained it I take the rag and wipe the sealing surface for the oil filter clean time to put the new oil filter. After oil filter is installed the next thing I did is to clean the drain plug then put it back. So after that it’s time to pour the new oil to the engine once it done I start the motor for 3mins and I turn it off I check the oil level and the filter and drain plug if there is a leak and finally I’m done September 20, 2021 CPU cleaning and Upgrading RAM This day we are going to clean and upgrade the cpu ram. First thing to do of course turn off and unplug it to power source. After which open up the side panel of the computer. Take note before touching anything in computer, all we have to do is touch a metal or wear an anti-static wrist wrap. we should equalize the static charge between you and the computer. Then I started the cleaning by grabbing the blower to blow dust build up out of computer vents, fans and accessories. We can also use cotton buds and dipped in alcohol to gently remove dust from fan blades then use a soft cloth to clean any dust of the back plate. After cleaning time for upgrading the ram, Some other boards have latches on both ends of each sticks while others have a latch on only one side unlocking these will begin popping the ram stick out of the slot and from there you simply grab the module and pull it straight on out. If you want to just add more to your system as opposed to replacing, the ram you currently have. ram modules can only install in a single direction so we need to align the notch in your new ram. And that’s it the process of upgrading RAM. September 11, 2021 Electric Fan Repair (button repair) So in this case the first thing we should do is check the fan in multiple outlets. It’s possible that the circuit breaker on an outlet was flipped and the fan simply wasn’t getting an electrical signal. After checking and if doesn’t really work. Unhook the blade guard or unscrew the pin, then Turn the blades or washer in the center of the fan counterclockwise to remove them. If there’s some plastic cover or case on front of the motor, unscrew the plate blocking the body of the motor. Flip your fan around and find the screws in the back. With your pin and front motor mostly exposed, turn your fan over to inspect the opposite side of the motor case. A dried out or sticky pin is one of the most common reasons for blades to stop spinning. If they spin easily and there’s no resistance, try turning your fan on and see if the pin spins. If it doesn’t, the problem isn’t the pin and there is probably a short in the motor. After which inspect the back of your motor case for dust or grime and wipe it off. Poor ventilation can cause dust and heat to get trapped inside the case of the motor. Plug your fan in and turn it on to see if the pin spins. A lot of standing and table fans don’t have a removable motor in the first place, which makes cleaning or adjusting it extremely difficult. Reassemble your fan by putting the blades, bolts, and case back together and we’re done repairing the fan.