Professional Documents
Culture Documents
Department of Education
Region VII, Central Visayas
Division of Bohol
DIAGNOSTIC TEST
TLE-8 EIM (Electrical Installation & Maintenance)
1. A tool used for removing insulation of medium sized wires ranging from gauge # 10 to gauge # 16
a. combination pliers b. side cutting pliers c. electrician’s knife d. wire stripper
2. A document generated by a store room personnel to notify the purchasing department items it needs to
order, their quantity and the time frame.
a. borrower’s form b. work order form c. purchase requisition form d. inventory form
3. Made out of metal with insulators in the handle. Used for cutting, twisting, bending, holding and gripping
wires and cables.
a. screwdrivers b. hammers c. wrenches d. pliers
4. A drilling machine with a chuck capacity of ¼ to 3/8. It is used in making holes on metal sheets and concrete
walls.
a. portable electric drill b. flat screwdriver c. hacksaw d. ballpeen hammer
6. This is used where the tap wire is under heavy tensile stress circuit
a. plain tap b. aerial tap c. rat tail d. knotted tap.
7. Is a span of flexible electrical power with a plug on one end and a multiple socket on the other end
a. extension reel b. extension cord c. flat cord d. power cable
10. It is the control to set into zero position the needle pointer before and after using the multi-tester to attain
correctness of value
a. direct current milliampere block d. range selector
b. resistance block c. zero ohms adjuster knob
12. Ohm’s law states that if the voltage increases the current will also _____ in which the resistance is
constant.
a. the same b. increase c. decrease d. constant
13. Small drawings or pictograms to represent various electrical devices in a diagram or plan of an electrical
circuit.
a. electrical signs b. electrical symbols c. electrical diagram d. electrical circuit
40. This happens when two wires L1 and L2 gets in contact with each other in which the current did not flow
along any load and in worse case it can cause fire.
a. open circuit b. close circuit c. short circuit d. grounded circuit