Professional Documents
Culture Documents
1907/2006
DEMAND 2.5CS
Version 2 - This version replaces all previous versions.
Revision Date 24.06.2011 Print Date 24.06.2011
1.2 Relevant identified uses of the substance or mixture and uses advised against
Use : Insecticide
For the full text of the H-Statements mentioned in this Section, see Section 16.
Version 2 Page 1 of 12
SAFETY DATA SHEET according to Regulation (EC) No. 1907/2006
DEMAND 2.5CS
Version 2 - This version replaces all previous versions.
Revision Date 24.06.2011 Print Date 24.06.2011
Hazard pictograms
Hazard statements : H410 Very toxic to aquatic life with long lasting effects.
Supplemental information : EUH401 To avoid risks to human health and the environment,
comply with the instructions for use.
Symbol(s)
Dangerous
for the envi-
ronment
Additional Labelling : To avoid risks to man and the environment, comply with the instructions
for use.
Version 2 Page 2 of 12
SAFETY DATA SHEET according to Regulation (EC) No. 1907/2006
DEMAND 2.5CS
Version 2 - This version replaces all previous versions.
Revision Date 24.06.2011 Print Date 24.06.2011
3.2 Mixtures
Hazardous components
Chemical Name CAS-No. Classification Classification Concentration
EC-No. (67/548/EEC) (REGULATION (EC) No
Registration num- 1272/2008)
ber
lamb- 91465-08-6 T+, N Acute Tox.3; H301 2.4 % W/W
da-cyhalothrin 415-130-7 R21 Acute Tox.3; H311
R25 Acute Tox.2; H330
R26 Aquatic Acute1; H400
R50/53 Aquatic Chronic1; H410
General advice : Have the product container, label or Material Safety Data Sheet with you
when calling the Syngenta emergency number, a poison control center or
physician, or going for treatment.
Version 2 Page 3 of 12
SAFETY DATA SHEET according to Regulation (EC) No. 1907/2006
DEMAND 2.5CS
Version 2 - This version replaces all previous versions.
Revision Date 24.06.2011 Print Date 24.06.2011
Eye contact : Rinse immediately with plenty of water, also under the eyelids, for at least
15 minutes.
Remove contact lenses.
Immediate medical attention is required.
Ingestion : If swallowed, seek medical advice immediately and show this container or
label.
Do NOT induce vomiting.
4.2 Most important symptoms and effects, both acute and delayed
4.3 Indication of any immediate medical attention and special treatment needed
Medical advice : Do not induce vomiting: contains petroleum distillates and/or aromatic
solvents.
Treat symptomatically.
Do not use a solid water stream as it may scatter and spread fire.
Do not allow run-off from fire fighting to enter drains or water courses.
Cool closed containers exposed to fire with water spray.
Version 2 Page 4 of 12
SAFETY DATA SHEET according to Regulation (EC) No. 1907/2006
DEMAND 2.5CS
Version 2 - This version replaces all previous versions.
Revision Date 24.06.2011 Print Date 24.06.2011
Version 2 Page 5 of 12
SAFETY DATA SHEET according to Regulation (EC) No. 1907/2006
DEMAND 2.5CS
Version 2 - This version replaces all previous versions.
Revision Date 24.06.2011 Print Date 24.06.2011
The following recommendations for exposure controls/personal protection are intended for the manu-
facture, formulation and packaging of the product.
Engineering measures : Containment and/or segregation is the most reliable technical protection
measure if exposure cannot be eliminated.
The extent of these protection measures depends on the actual risks in
use.
If airborne mists or vapors are generated, use local exhaust ventilation
controls.
Assess exposure and use any additional measures to keep airborne
levels below any relevant exposure limit.
Where necessary, seek additional occupational hygiene advice.
Protective measures : The use of technical measures should always have priority over the use of
personal protective equipment.
When selecting personal protective equipment, seek appropriate profes-
sional advice.
Personal protective equipment should be certified to appropriate stan-
dards.
Respiratory protection : A combination gas, vapor and particulate respirator may be necessary
until effective technical measures are installed.
Protection provided by air-purifying respirators is limited.
Use a self-contained breathing apparatus in cases of emergency spills,
when exposure levels are unknown, or under any circumstances where
air-purifying respirators may not provide adequate protection.
Version 2 Page 6 of 12
SAFETY DATA SHEET according to Regulation (EC) No. 1907/2006
DEMAND 2.5CS
Version 2 - This version replaces all previous versions.
Revision Date 24.06.2011 Print Date 24.06.2011
Skin and body protection : Assess the exposure and select chemical resistant clothing based on the
potential for contact and the permeation / penetration characteristics of
the clothing material.
Wash with soap and water after removing protective clothing.
Decontaminate clothing before re-use, or use disposable equipment
(suits, aprons, sleeves, boots, etc.)
Wear as appropriate:
impervious protective suit
: 61.1 mN/m at 20 °C
: 52.7 mN/m at 20 °C
Version 2 Page 7 of 12
SAFETY DATA SHEET according to Regulation (EC) No. 1907/2006
DEMAND 2.5CS
Version 2 - This version replaces all previous versions.
Revision Date 24.06.2011 Print Date 24.06.2011
10.1 Reactivity
No information available.
None known.
Hazardous polymerisation does not occur.
Acute oral toxicity : Median lethal dose male and female rat, > 5,000 mg/kg
The toxicological data has been taken from products of similar composi-
tion.
Acute inhalation toxicity : Median lethal concentration rat, > 4.62 mg/l , 4 h
The toxicological data has been taken from products of similar composi-
tion.
Acute dermal toxicity : Median lethal dose male and female rat, > 5,000 mg/kg
The toxicological data has been taken from products of similar composi-
tion.
Respiratory or skin sensiti- : guinea pig: Not a skin sensitizer in animal tests.
zation The toxicological data has been taken from products of similar composi-
tion.
Version 2 Page 8 of 12
SAFETY DATA SHEET according to Regulation (EC) No. 1907/2006
DEMAND 2.5CS
Version 2 - This version replaces all previous versions.
Revision Date 24.06.2011 Print Date 24.06.2011
Carcinogenicity
lambda-cyhalothrin : Did not show carcinogenic effects in animal experiments.
Reproductive toxicity
lambda-cyhalothrin : Did not show reproductive toxicity effects in animal experiments.
12.1 Toxicity
Stability in water
lambda-cyhalothrin : Degradation half life: 7 d
Not persistent in water
Stability in soil
lambda-cyhalothrin : Degradation half life: 56 d
Not persistent in soil.
Version 2 Page 9 of 12
SAFETY DATA SHEET according to Regulation (EC) No. 1907/2006
DEMAND 2.5CS
Version 2 - This version replaces all previous versions.
Revision Date 24.06.2011 Print Date 24.06.2011
None known.
Sea transport(IMDG)
Version 2 Page 10 of 12
SAFETY DATA SHEET according to Regulation (EC) No. 1907/2006
DEMAND 2.5CS
Version 2 - This version replaces all previous versions.
Revision Date 24.06.2011 Print Date 24.06.2011
none
14.7 Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code
not applicable
15.1 Safety, health and environmental regulations/legislation specific for the substance or mix-
ture
GHS-Labelling
Hazard pictograms
Hazard statements : H410 Very toxic to aquatic life with long lasting effects.
Supplemental information : EUH401 To avoid risks to human health and the environ-
ment, comply with the instructions for use.
Further information
Full text of R-phrases referred to under sections 2 and 3:
R10 Flammable.
R21 Harmful in contact with skin.
Version 2 Page 11 of 12
SAFETY DATA SHEET according to Regulation (EC) No. 1907/2006
DEMAND 2.5CS
Version 2 - This version replaces all previous versions.
Revision Date 24.06.2011 Print Date 24.06.2011
The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and
belief at the date of its publication. The information given is designed only as a guidance for safe handling,
use, processing, storage, transportation, disposal and release and is not to be considered a warranty or
quality specification. The information relates only to the specific material designated and may not be valid
for such material used in combination with any other materials or in any process, unless specified in the
text.
Changes since the last version are highlighted in the margin. This version replaces all previous versions.
Product names are a trademark or registered trademark of a Syngenta Group Company.
Version 2 Page 12 of 12