Professional Documents
Culture Documents
1907/2006
1.2 Relevant identified uses of the substance or mixture and uses advised against
Use : Rodenticide
Not a dangerous substance or mixture according to the Globaly Harmonised System (GHS).
Version 2 Page 1 of 10
SAFETY DATA SHEET according to Regulation (EC) No. 1907/2006
3.2 Mixtures
Hazardous components
Chemical Name CAS-No. Classification Classification Concentration
EC-No. (67/548/EEC) (REGULATION (EC) No
Registration num- 1272/2008)
ber
brodifacoum 56073-10-0 T+, N Acute Tox.1; H300 0.005 % W/W
259-980-5 R27/28 Acute Tox.1; H310
R48/24/25 Acute Tox.1;
R50/53 Skin Sens.1; H317
STOT RE1; H372
Aquatic Acute1; H400
Aquatic Chronic1; H410
General advice : Have the product container, label or Material Safety Data Sheet with you
when calling the Syngenta emergency number, a poison control center or
physician, or going for treatment.
Eye contact : Rinse immediately with plenty of water, also under the eyelids, for at least
15 minutes.
Remove contact lenses.
Immediate medical attention is required.
Version 2 Page 2 of 10
SAFETY DATA SHEET according to Regulation (EC) No. 1907/2006
4.2 Most important symptoms and effects, both acute and delayed
4.3 Indication of any immediate medical attention and special treatment needed
Medical advice : This product contains anticoagulants with an effect similar to warfarin in
that they act by interfering with the synthesis of prothrombin.
The specific measure of effect is the prothrombin time. Note this may not
become prolonged until 12-18 hours after ingestion.
The specific antidote is vitamin K1 (Phytomenandione).
Antidote must be administered under medical supervision.
Initially, antidote should be given by injection (10-20mg, or 0.25mg/kg for
children), by slow intravenous infusion at a rate not exceeding
1mg/minute. In severe cases the use of fresh frozen plasma may be
required.
Maintenance treatment is given orally (40mg/day in divided doses for
adults; up to 20mg/day in divided doses for children).
The prothrombin time and the haemoglobin should be monitored. Patients
should be kept under medical supervision until the prothrombin time has
been normal for 3 consecutive days.
Oral treatment may need continuing for several months (20mg/day in
divided doses for adults and up to 20mg/day in divided doses for children).
(For animal cases the dose is 2-5mg/kg).
Do not use a solid water stream as it may scatter and spread fire.
Do not allow run-off from fire fighting to enter drains or water courses.
Version 2 Page 3 of 10
SAFETY DATA SHEET according to Regulation (EC) No. 1907/2006
: Physically and chemically stable for at least 2 years when stored in the
original unopened sales container at ambient temperatures.
Version 2 Page 4 of 10
SAFETY DATA SHEET according to Regulation (EC) No. 1907/2006
The following recommendations for exposure controls/personal protection are intended for the manu-
facture, formulation and packaging of the product.
Engineering measures : Containment and/or segregation is the most reliable technical protection
measure if exposure cannot be eliminated.
The extent of these protection measures depends on the actual risks in
use.
If airborne dust is generated, use local exhaust ventilation controls.
Assess exposure and use any additional measures to keep airborne
levels below any relevant exposure limit.
Where necessary, seek additional occupational hygiene advice.
Protective measures : The use of technical measures should always have priority over the use of
personal protective equipment.
When selecting personal protective equipment, seek appropriate profes-
sional advice.
Personal protective equipment should be certified to appropriate stan-
dards.
Version 2 Page 5 of 10
SAFETY DATA SHEET according to Regulation (EC) No. 1907/2006
pH : no data available
Melting point/range : no data available
Boiling point/boiling range : no data available
Flash point : > 61 °C
Evaporation rate : no data available
Flammability (solid, gas) : no data available
Lower explosion limit : no data available
Upper explosion limit : no data available
Vapour pressure : no data available
Relative vapour density : no data available
Density : 1.2 g/cm3
Solubility in other solvents : not soluble
in Water
Partition coefficient: : no data available
n-octanol/water
Autoignition temperature no data available
Thermal decomposition : no data available
Viscosity, dynamic : no data available
Viscosity, kinematic : no data available
Explosive properties : no data available
Oxidizing properties : no data available
10.1 Reactivity
No information available.
None known.
Hazardous polymerisation does not occur.
Version 2 Page 6 of 10
SAFETY DATA SHEET according to Regulation (EC) No. 1907/2006
Acute oral toxicity : Acute toxicity estimate male and female rat, > 5,000 mg/kg
Derived from components.
Carcinogenicity
brodifacoum : Did not show carcinogenic effects in animal experiments.
Teratogenicity
brodifacoum : Did not show teratogenic effects in animal experiments.
Reproductive toxicity
brodifacoum : Did not show reproductive toxicity effects in animal experiments.
Further information
brodifacoum : Excessive exposure slows blood clotting time and can cause bleeding,
shock and death.
12.1 Toxicity
Toxicity to aquatic inverte- : Daphnia magna (Water flea), > 100 mg/l , 48 h
brates Derived from components.
Version 2 Page 7 of 10
SAFETY DATA SHEET according to Regulation (EC) No. 1907/2006
Stability in water
brodifacoum : Degradation half life: ca. 300 d
Persistent in water.
Stability in soil
brodifacoum : Degradation half life: 157 d
Not persistent in soil.
Version 2 Page 8 of 10
SAFETY DATA SHEET according to Regulation (EC) No. 1907/2006
Sea transport(IMDG)
Not dangerous goods
none
14.7 Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code
not applicable
15.1 Safety, health and environmental regulations/legislation specific for the substance or mix-
ture
GHS-Labelling
Precautionary statements : P102 Keep out of reach of children.
P270 Do not eat, drink or smoke when using this product.
Version 2 Page 9 of 10
SAFETY DATA SHEET according to Regulation (EC) No. 1907/2006
Further information
Full text of R-phrases referred to under sections 2 and 3:
The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and
belief at the date of its publication. The information given is designed only as a guidance for safe handling,
use, processing, storage, transportation, disposal and release and is not to be considered a warranty or
quality specification. The information relates only to the specific material designated and may not be valid
for such material used in combination with any other materials or in any process, unless specified in the
text.
Changes since the last version are highlighted in the margin. This version replaces all previous versions.
Product names are a trademark or registered trademark of a Syngenta Group Company.
Version 2 Page 10 of 10