# DESCRIPTION OF JOB LOCATION POTENTIAL HAZARDS RISK CONTROL MEASURES
# SEQUENCE OF JOB STEPS POTENTIAL HAZARDS RISK CONTROL MEASURES
Engine oil Reservoir filling Operator could be slip; fall and part of body could be touch with running Safety shoes, gloves, glasses, helmet to be used the equipment/ electric cable. filling .Deploy Only competent personal. 1. pipe could hold in part of equipment All electric wire should be properly insulated. Oil spillage to eyes of operator. Fire Filling pipe way should be clear. Filling pump could be cause by electric motor for should be properly insulated and explosion free filling pump Hydraulic oil filling Leakage cause of fire by touching Deploy Only competent personal. Tight the 2. with hot muffler tubing properly to prevent leakage. Pre lubricate the compressor by Personal injury Deploy Only competent personal. 3. hand pump Latch the crank motor Personal injury by touching withDeploy Only competent personal. Make distance 4. moving part of equipment from moving parts of equipments
OGF – HSEQ – 003(02)
5. Open plant air Noise Wear ear muff Adjust exhaust temperature of cylinder Deploy Only competent personal. 6. Electric shocks, burning Wear insulated gloves. Control the short circuit sparking Open/close suction/discharge V/L Deploy Only competent personal. 7. Personal injury
Off mobile phones, no lighter, Avoid spark, flame
electrical source, hot surface. Post area NO SMOKING or OPEN FLAME Depressurize the compressor Training to be conducted 8. Fire due to open vent of gas Only trained and experienced person is allowed to perform Gas mask to be used ,Follow wind socks Fire extinguisher to be ready by an operator 9. During performing job Negligence in following SOP causes fire, explosion, personal Proper training to be conducted injury or causality and damage of equipment 10. Compressor in running mode Personal injury could be due to damage of any part of equipment, Deploy Only competent personal. fire or explosion possibility due to leakages of gas or oil, excessive pressure or heat. 11. House keeping Slip, trip & fall ,fire Proper house keeping to be done
JOB SAFETY REQUIREMENTS YES/NO COMMENTS
SAFETY WATCH Yes Shall be the Trained Person WORK CLEARANCE Yes Properly Depressurization GAS DETECTOR Yes Calibrated[ REF: API RP 14C, API RP 14F & API RP 500]
PERSONAL PROTECTIVE EQUIPMENT YES/NO COMMENTS
Yes Eye protection, use clear glasses [REF: OSHA 1910.133 (a) SAFETY GLASSES (2)] COVERALLS Yes Safe working [REF: OSHA 1910.134 (e)(5)(i)(D)] HARD HAT Yes Use chin strap with Helmet. [ REF:OSHA 1910.135 (a) (1)] EAR PLUG / EAR MUFF Yes with suitable noise reduction rating (NRR)