Professional Documents
Culture Documents
York L
1 Substance/Product Identification
York International
631 S.Richland Ave.
York
PA 17403
2 Composition/Information on Ingredients
Hazardous Ingredients
This material has no known hazards under applicable laws.
3 Hazards Identification
Exposure Limits
Belgium
Not applicable.
EU
Not applicable.
Ireland
Not applicable.
UK
Not applicable.
Other Exposure Contains synthetic basestock. Under conditions which may
Limits generate mists, observe the OSHA PEL of 5 mg per cubic meter,
ACGIH STEL of 10 mg per cubic meter for mineral oil mists.
Ventilation
Use with adequate ventilation.
Procedures
Hand Protection Nitrile.
Eye Protection Safety Glasses.
Respiratory Under normal use conditions, respirator is not usually required.
Protection Use disposable dust/mist mask if the recommended exposure limit
is exceeded.
Clothing
Long sleeve shirt is recommended.
Recommendation
11 Toxicological Information
-- ACUTE EXPOSURE--
Eye Irritation Not expected to cause eye irritation. Based on data from similar
materials.
Skin Irritation Not expected to be a primary skin irritant. Based on data from
similar materials. Prolonged or repeated contact may cause
dermatitis.
Respiratory If material is misted or if vapors are generated from heating,
Irritation exposure may cause irritation of mucous membranes and the upper
respiratory tract similar to that observed with mineral oil. Based on
data from similar materials. Under good industrial hygiene
practices where all exposure limits are observed, respiratory
irritation should not be a problem.
Dermal Toxicity The LD50 in rabbits is > 2000 mg/Kg. Based on other data or data
on similar materials.
Inhalation Toxicity Not expected to be a toxic inhalation hazard. Based on data
available from components or similar materials.
Oral Toxicity The LD50 in rats is > 5000 mg/Kg. Based on data from similar
materials.
Dermal Not expected to cause skin sensitization. Based on data from
Sensitization similar materials.
Inhalation Not expected to cause respiratory tract sensitization. Based on data
Sensitization from similar materials.
-- CHRONIC EXPOSURE--
12 Ecological Information
-- ENVIRONMENTAL TOXICITY--
-- ENVIRONMENTAL FATE--
13 Disposal Consideration
14 Transport Information
15 Regulatory Information
16 Other Information
The information presented herein has been compiled from sources considered to be dependable
and is accurate to the best of The Corporation's knowledge; however, The Corporationmakes no
warranty whatsoever, expressed or implied of MERCHANTABILITY OR FITNESS FOR THE
PARTICULAR PURPOSE, regarding the accuracy of such data or the results to be obtained from
use thereof.The Corporation assumes no responsibility for injury to recipient or to third persons or
for any damage to any property and recipient assumes all such risks.