Professional Documents
Culture Documents
k
FRANCE
- Information department: Three Bond Europe H&S department : msds@threebond.fr
o.u
Site : http://quickfds.com
- 1.4 Emergency telephone
number: ORFILA (France) - Tel : +33 (0)1 45 42 59 59 (24h)
Ireland - Tel : 00 353 1 8092568 - 00 353 1 8379964 (24h/24)
EU Tel : 112
GHS05 corrosion
tec
GHS07
Xi; Sensitising
R43: May cause sensitisation by skin contact.
- Information concerning
particular hazards for human
and environment: The product has to be labelled due to the calculation procedure
of the "General Classification guideline for preparations of the
EU" in the latest valid version.
- Classification system: The classification was made according to the latest editions of
the EU-lists, and expanded upon from company and literature
data.
- 2.2 Label elements
- Labelling according to EU
guidelines: Observe the general safety regulations when handling chemicals
(Contd. on page 2)
GB
(Contd. of page 1)
The product has been marked in accordance with EU Directives /
respective national laws.
- Code letter and hazard
designation of product:
Xn Harmful
- Hazard-determining
components of labelling: butan-2-one O,O',O''-(methylsilylidyne)trioxime
k
2-Butanone, O,O',O''-(ethenylsilylidyne)trioxime
2-butanone oxime
- Risk phrases: 40 Limited evidence of a carcinogenic effect.
o.u
43 May cause sensitisation by skin contact.
- Safety phrases: 37 Wear suitable gloves.
51 Use only in well-ventilated areas.
60 This material and its container must be disposed of as
hazardous waste.
- Special labelling of certain
preparations:
- 2.3 Other hazards
- Results of PBT and vPvB assessment
- PBT:
- vPvB:
Not applicable.
Not applicable.
il.c
Liberates butanone-oxime (MEKO) on exposure to humid air.
hs
SECTION 3: Composition/information on ingredients
- 3.2 Mixtures
- Description: Mixture of the substances listed below with nonhazardous
additions.
tec
- Dangerous components: (**) During curing, oxime type silicones gradually release butano-
oxime (MEKO) when exposed to humid air. Although not included
in the formula, this by-product which results from a secondary
reaction, represents over 1% of silicone volume.
CAS: 22984-54-9 butan-2-one O,O',O''-(methylsilylidyne)trioxime < 10%
EINECS: 245-366-4 Xi R36/38; Xi R43
w.
(Contd. of page 2)
k
- After eye contact Rinse opened eye for several minutes under running water. If
symptoms persist, consult a doctor.
- After swallowing Rinse out mouth and then drink plenty of water.
o.u
Call for a doctor immediately.
A person vomiting while lying on their back should be turned onto
their side.
- 4.2 Most important
symptoms and effects, both
acute and delayed No further relevant information available.
- 4.3 Indication of any
immediate medical attention
il.c
and special treatment needed No further relevant information available.
(Contd. of page 3)
See Section 13 for disposal information.
k
- 7.2 Conditions for safe storage, including any incompatibilities
- Storage
- Requirements to be met by
o.u
storerooms and receptacles: Store in a cool location.
Use only receptacles specifically permitted for this substance/
product.
- Information about storage in
one common storage facility: Store away from water.
- Further information about
storage conditions: Protect from humidity and water.
Protect from heat and direct sunlight.
workplace: The product does not contain any relevant quantities of materials
with critical values that have to be monitored at the workplace.
- Additional information: The lists that were valid during the creation were used as basis.
- 8.2 Exposure controls
- Personal protective equipment
- General protective and
hygienic measures The usual precautionary measures should be adhered to when
w.
handling chemicals.
Avoid close or long term contact with the skin.
Keep away from foodstuffs, beverages and feed.
Immediately remove all soiled and contaminated clothing
Wash hands before breaks and at the end of work.
ww
(Contd. of page 4)
- Body protection: Protective work clothing.
k
- Odour: Characteristic
- Change in condition
o.u
Boiling point/Boiling range: Not applicable
- Flash point: Not applicable
- Self igniting: Product is not selfigniting.
- Danger of explosion: Product does not present an explosion hazard.
- Density at 25°C: 1.05 g/cm³
- Solubility in / Miscibility with
Water:
- 9.2 Other information
Insoluble
il.c
No further relevant information available.
- Acute toxicity:
- LD/LC50 values that are relevant for classification:
96-29-7 2-butanone oxime
Oral LD50 3700 mg/kg (rat)
Dermal LD50 200-2000 mg/kg (rat)
Inhalative LC50/4 h 20 mg/l (rat)
- Primary irritant effect:
- on the skin: No irritant effect.
- on the eye: No irritating effect.
- Sensitization: Sensitization possible through skin contact.
(Contd. on page 6)
GB
(Contd. of page 5)
- Additional toxicological
information: The product shows the following dangers according to the
calculation method of the General EU Classification Guidelines
for Preparations as issued in the latest version:
Irritant
k
- Aquatic toxicity: No further relevant information available.
- 12.2 Persistence and
degradability No further relevant information available.
o.u
- 12.3 Bioaccumulative
potential No further relevant information available.
- 12.4 Mobility in soil No further relevant information available.
- Additional ecological information:
- General notes: Generally not hazardous for water.
- 12.5 Results of PBT and vPvB assessment
- PBT: Not applicable.
- vPvB:
- 12.6 Other adverse effects
Not applicable.
il.c
No further relevant information available.
- Uncleaned packagings:
- Recommendation: Dispose of packaging according to regulations on the disposal of
packagings.
Disposal must be made according to official regulations.
- Recommended cleansing
agent: Alcohol
w.
(Contd. of page 6)
k
SECTION 15: Regulatory information
o.u
- 15.1 Safety, health and environmental regulations/legislation specific for the substance or
mixture
- National regulations
- Water hazard class: Generally not hazardous for water.
- Other regulations, limitations and prohibitive regulations
- Substances of very high
concern (SVHC) according to
REACH, Article 57
- 15.2 Chemical safety
assessment:
Not applicable
il.c
A Chemical Safety Assessment has not been carried out.