Professional Documents
Culture Documents
are your results. And you have not paid only for words, I have done full on analysis of your
result and produced those graphs in MATLAB to make it more comparative sense among all
your Six sets of Hydrogels. But if you only want word counts then that can also be added, which
I would not suggest because to make it lengthier there will be more unnecessary explanation and
result needs to be more precise. Always remember good explanation is given by quality words
not by more quantity of words.
Noted on this.
W t−W d
Swelling %= × 100
Wd
Where,
Wd = It is the weight of hydrogel after dissolving it in 50ml of water of desired pH ranging from
1.2 to 10 for 24 hours at room temperature.
Thank you
This is actually EDX results. Energy dispersive Xray Analyzer. Arent they different things?
Basically, XRD attempts to characterize the material by analyzing the crystal structure, and
comparing it against a database of known structures. Whereas EDX is an elemental analysis
technique. Here you stimulate your sample by electrons or high-energy photons, and detect the
spectrum of outgoing photons. Their resulting graph looks kind of similar so I misevaluated the
graph I will change the explanation as per your analysis and obtained EDX results.
Noted on this.
I will amend it and send the result and discussion file after all changes have been made as per
your requirements.
Thank you
What kind of information and table you want in it tell in more detail please. Yes, if you want
data into table to see the data, that can be added. Tell me which data table you want there.
Yes. just the obtained data. Like tensile, young’s modulus, elasticity, Tg, Tm
something like this.like an overall obtained result.
Thank you
For figure 4.11 you have data of glass transition and melting point temperature of hydrogel at the
results you have sent which I have just showed using graph. If you don’t want remove it.
No no. what i meant was ‘does it belong to tensile and elasticity sub topic?’ was it wrongly
placed there or purposely to explain something to the tensile or what. just like that. didnt mean it
wrong.
TG and TM polymers is that the TG of polymers describes the conversion of the glassy state into
rubbery state whereas the TM of polymers describes the conversion of the crystalline state into
an amorphous state. It tells how the mechanical property of material changes at what
temperature. I will explain this in results.
ya better to have a small a little discussion to it relating the tensile properties and all. thank you
very much
If any other things need to be changed or amended, please write below here: