Professional Documents
Culture Documents
According to the following picture identify one of the five major stresses in figure
A:
A. Compression
B. Torsion
C. Shear
D. (X) Tension
2. According to the previous picture identify the five major stresses in figure B:
A. (X) Compression
B. Torsion
C. Shear
D. Tension
3. According to the previous picture identify the five major stresses in figure C:
A. Compression
B. (X) Torsion
C. Shear
D. Tension
4. According to the previous picture identify the five major stresses in figure D:
A. Compression
B. Torsion
C. (X) Shear
D. Tension
10. According to the RAC, How Much maintenance services of lines exist:
A. Three
B. Four
C. (X) Two
D. Five
11. The Three axis on airplane are:
A. Yaw
B. Roll
C. Pitch
D. (X) All are true
12. What type of flap System increases the wing área and changes the wing camber
A. (X) Fowler flaps
B. Slotted flaps
C. Split flaps
13.What type of lift supports an airplane in the air
A. Aerodynamic drag
B. (X) Aerodynamic lift
C. Aerodynamic resistance
D. All of them
14. La OACI es:
A. Organización de aviación comercial
B. Organización de aviación comercial interamericana
C. Organización de aeronáutica civil internacional
D. (X) Organización de aviación civil internacional
16. What are the two systems of fluid power used in aircraft
A. Electrical Systems
B. Pneumatic Systems
C. Hydraulic Systems
D. (X) B and C
17. Documento emitido por la autoridad del país de origen de un certificado tipo en el
cual se da a conocer una condición insegura y su acción correctiva
A. AC
B. (X) AD
C. SB
D. TC/STC
23. ¿Una medida de 2,5 pulgadas con una tolerancia de +/- 1/8, cuál será la mínima
medida permitida?
A. (X) 2,375”
B. 2,625”
C. 2,5
D. Ninguna de las Anteriores
24. ¿Porque algunos sistemas de combustible incorporan una unidad Fuel Heater?
A. Para Prevenir que el aceite se enfrié demasiado en el sistema de lubricación.
B. (X) Para Prevenir formación de hielo en los filtros de combustible.
C. Para generar calentamiento del aceite del sistema de lubricación.
D. Para crear vapor de combustible que genere una mejor combustión.
25. ¿Cuáles son las tres superficies primarias de control en una aeronave?
A. Spoilers, Elevadores y Flaps.
B. (X) Alerones, Elevadores y Rudder.
C. Slats, Flaps y Rudder.
D. Wing Tips, Speed Brakes y Alerones.
26. El Manual Técnico aprobado para una reparación estructural menor es:
A. AMM
B. Las Políticas OACI
C. (X) SRM
D. RAC
27. Cuál es la Medida en mm que indica la medición del Vernier
A. 10 mm
B. 10,8 mm
C. 18 mm
D. (X) 9,8 mm
29. Para que un Técnico autorizado pueda dar reléase a una Aeronave para iniciar
Vuelo, dicha Aeronave debe:
A. Tener el Certificado de Aeronavegabilidad a Bordo
B. (X) Cumplir con todos los Requisitos Técnicos y Legales
C. Tener el Certificado de Matricula a Bordo
D. Cumplir solo con el Certificado Tipo
32. Martillo
A. Heel Dolly
B. Smasher
C. (X) Hammer
33. Select the correct translation of the following sentence in Spanish: “Se encontró
una fractura sobre la Piel de la Parte superior izquierda del Fuselaje Delantero”
A. (X) On the FWD fuselaje L/H upper skin, a crack was found
B. On the upper fuselaje skin, a crack was found FWD fuselaje L/H
C. On FWD fuselaje L/H Top Skin, a scratch was found
34. Unit Display Lower
A. Unit Display Lower
B. (X) Lower Display Unit
C. Lower Unit Display
35. Door Cargo Fittings Lock
A. Cargo Door Lock Fittings
B. (X) Fittings Lock Cargo Door
C. Lock Fittings Cargo Door
36. Main Doors Gear
A. (X) Main Gear Doors
B. Main Doors Gear
C. Doors Main Gear
37. Receptacle Ground Door Access Power
A. Receptacle Door Access Power Ground
B. Ground Power Receptacle Access Door
C. (X) Ground Power Access Door Receptacle
48. If a circumference has a ratio of 1/2’’, What would be the circumference diameter?
A. 0,500” DIA
B. 1/2" DIA
C. (X) 1” DIA
D. 1.4” DIA
57. According to Ohms Law find the DC source value in the following picture.
A. 12VDC
B. 6 VDC
C. (X) 24VDC
D. 24VAC
58. What causes an aircraft tire to wear more on the shoulders than in the center of
the tread?
A. Deflated condition
B. (X) Underinflated condition
C. Overinflated condition
D. Wrong tires installed
59. What is meant by the viscosity of engine lubricating oil?
A. Temperature at the engine oil
B. (X) The resistance of the oil to flow
C. How thick is the engine oil
D. How much pressure can the oil resist?
61. El manual técnico aprobado para una reparación estructural menor es:
A. AMM
B. Las Políticas OACI
C. (X) SRM
D. RAC
62. What should be done if an aircraft is weighed with the fuel tanks completely full?
A. The technician must open all the thank Access and collect the fuel into a container.
B. The technician can mathematically add the weight of usable fuel, and account for its
arm and momento.
C. (X) The technician can mathematically subtract the weight of usable fuel, and
account for its arm and momento.
D. No additional calculations are necessary.
64. Which of the following turbine fuel filters has the greatest filtering action?
A. (X) Micron
B. (X) Small wire mesh
C. Stacked charcoal
D. Self relieving
65. If the volume of a confined gas is doubled (without the adition of more gas), the
pressure will (asume the temperature remains constant)
A. Increase in direct proportion to the volume increase
B. Remain the same
C. (X) Be reduced to one-half its original value.
D. The volume decrees double
66. En una medida de 31/64 de pulgada con una tolerancia de +/- 1/32, cuál será la
máxima medida permitida?
A. 32/32
B. 33/64
C. (X) 32/64
D. A y b son verdaderas
73. The standars that are not found in the standars manual shall be used approval of
Airbus Industry.
A. (X) TRUE
B. FALSE
74. The repair processes which are covered in other chapters of the AMM are covered
Also on:
A. (X) At he airframe standard practices chapter
B. Only on the AMM
C. Are not covered at all
D. Airframe standard practices (ATA 20)
75. The standards manual provide information about the Process?
A. TRUE
B. (X) FALSE
75. Grammar: Use the Follow sentence, and modified it in accordance with the
Grammar Parameters-short form is not valid: *USE: Paul assembles the brake*
Simple Tense
Affirmative: Paul assembles the brake
Negative: Paul does not assemble the brake (Doesn’t)
Interrogative: Does Paul assemble the brake?
Past Tense
Affirmative: Paul assembled the brake
Negative: Paul did not assemble the brake (Didn’t)
Interrogative: Did Paul assemble the brake
Future Tense
Affirmative: Paul will assemble the brake
Negative: Paul will not assemble the brake (won’t)
Interrogative: Will Paul assemble the brake