You are on page 1of 2

Heat Transfer and I.

C Engine worksheet

1. From the following which one correctly indicated lumped system temperature distribution?
A. T(x,y,z,t) B. T(x,y,z,) C. T (t) D. T(x,y,t)
2. A person prefers to sit near a fire during the cold winter months. Which of the following
heat transfer gives him the most heat?
A. Convection and radiation together B. Radiation will provide quick warmth
C. If it is near the fire, convection sounds good D. Conduction from the fire
3. All are the characterics of fluid flow in turbulent boundary layer except,
A. Smooth and well-defined flow B. Chaotic flow C. irregular
motion D. the velocity profile is flattened and more uniform
4. When a liquid is flowing through a pipe, the velocity of the liquid for no slip condition is
A. Maximum at the center and minimum near the walls
B. Minimum at the center and maximum near the walls
C. Zero at the center and maximum near the walls
D. Maximum at the center and zero near the walls
5. Heat exchanger may be classified as evaporator and condenser based on____
A. Design or Construction C. Physical state of fluid
B. Direction of flow D. Nature of heat exchange process
6. From the following dimensionless number which one is used to determine whether flow is
laminar or turbulent in a given boundary layer?
A. Prandtl No B . Reynolds no C. Nusselt No D. Mach No
7. All are assumption made for analysis of fin (extended surface) material except:
A. Steady and 1D flow C. Uniform h
B. No internal heat generation D. variable k
8. It is the ratio of work done or power developed by an engine to the rate of chemical energy
or heat supplied by burning of fuel in the engine.
A. Volumetric efficiency B. Thermal efficiency
C. Mechanical efficiency D. Relative efficiency
9. The heat transfer from coolant to air in the radiator of an automobile engine takes place by
A. Radiation only C. convection only
B. radiation and convection D. radiation, convection and conduction
10. An engine has a clearance volume of 100 cm 3 and a swept volume of 800 cm 3. The
compression ratio is A. 1:9 B. 9:1 C. 8:1 D. 1:8
11. To determine engine performance, the engine is run without fuel or spark, typically by
disconnecting the fuel injectors or spark plugs and parameters, such as oil pressure,
compression, and vacuum recorded during _________test.
A. Morse B. Motoring C. William D. Retardation Test
12. From the following engine managements system which one is kwon as “brains of the engine
management system,”?
A. Electronic fuel injection (EFI) systems, C. Engine control units (ECUs),
B. Onboard diagnostic (OBD) systems D. Ignition Control System
13. When you drive from Bonga to Jima your exhaust emission is completely Black as show
below. then if you ask the following technician and they forward their answer as below
which one is true? Technician A. its because of coolant leak into fuel. Technician B. its
because of your engine is burning oil. Technician C. its because of your fuel is rich (Over
fuel)
A. Technician A. B. Technician B. C. Technician C D. Technician A and B

You might also like