Professional Documents
Culture Documents
INITIAL SETUP:
Tools
Tool Kit, General Mechanics CATS (WP 3801, Item 287 [Maintenance Allocation Chart, Tool Kit,
General Mechanics CATS])
Torque Wrench (WP 3801, Item 313 [Maintenance Allocation Chart, Torque Wrench, 30 - 200 in.
lbs])
Materials/Parts
Adhesive (WP 3802, Item 30 [Expendable and Durable Items List, Adhesive])
Personnel Required
UH-60 Helicopter Repairer 15T (1)
References
WP 0613, APU Access Door
WP 0287, External Electrical Power
REMOVE
1. Remove electrical power from helicopter (WP 0287 [External Electrical Power]).
2. Open APU compartment access doors (WP 0613 [APU Access Door]).
3. Remove screws and washers from APU exhaust duct mounting flange (Figure 1 [Replace
APU Exhaust Duct]).
4. Remove bolts and saddle washers holding APU exhaust duct to airframe fairing.
5. Pull APU exhaust duct through fairing until mounting flange reaches airframe fairing.
Rotate APU exhaust duct until flange finger points forward. Remove APU exhaust duct.
END OF TASK
INSTALL
1. Remove electrical power from helicopter (WP 0287 [External Electrical Power]).
QA 2. With finger on mounting flange pointing forward, install APU exhaust duct through
airframe fairing (Figure 1 [Replace APU Exhaust Duct]).
3. Apply a bead of adhesive (WP 3802, Item 30 [Expendable and Durable Items List,
Adhesive]) to mounting flange, and install APU exhaust duct to rear shroud with screws
and washers.
QA 4. Install APU exhaust duct to airframe fairing with bolts and saddle washers. TORQUE
BOLTS TO 47 - 53 INCH-POUNDS.
5. Close APU compartment access doors (WP 0613 [APU Access Door]).
MOUNTING EXHAUST
AIRFRAME
FLANGE DUCT
FAIRING
FLANGE
REAR
SHROUD
APU
SCREW,
WASHER
D
FW
FIREWALL
AB5791
SA
END OF TASK