Professional Documents
Culture Documents
SODAMCO Emirates Factory for Building Materials W.L.L.Industrial City of Abu Dhabi
ICAD 3, Plot No. 65 NR29-P.O. Box 96082-Abu-Dhabi -
T +971 2 550 9994
F +971 2 550 9449
46.1.13
Page 2/13
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 13.05.2018 Version number 1 Revision: 13.05.2018
(Contd. of page 1)
T +966 12 668 3295 +966 12 261 2722
F +966 12 668 1498
GHS09 environment
Aquatic Chronic 2 H411 Toxic to aquatic life with long lasting effects.
GHS07
(Contd. of page 2)
Hazard pictograms
GHS07 GHS09
(Contd. of page 3)
SVHC Void
Additional information For the wording of the listed hazard phrases refer to section 16.
After swallowing
Do not induce vomiting; call for medical help immediately.
If symptoms persist consult a doctor.
Administer medicinal carbon
4.2 Most important symptoms and effects, both acute and delayed
No further relevant information available.
4.3 Indication of any immediate medical attention and special treatment needed
No further relevant information available.
(Contd. of page 4)
(Contd. of page 5)
(Contd. of page 6)
Material of gloves
Butyl rubber, BR
Chloroprene rubber, CR
The selection of the suitable gloves does not only depend on the material, but also on further marks of
quality and varies from manufacturer to manufacturer. As the product is a preparation of several
substances, the resistance of the glove material can not be calculated in advance and has therefore to
be checked prior to the application.
Penetration time of glove material
The exact break trough time has to be found out by the manufacturer of the protective gloves and has
to be observed.
Not suitable are gloves made of the following materials: Nitrile rubber, NBR
Eye protection: Tightly sealed goggles
Body protection: Protective work clothing.
(Contd. of page 7)
Bulk density: Not applicable.
Relative density Not determined.
Vapour density Not determined.
Evaporation rate Not determined.
Solubility in / Miscibility with
Water: Not miscible or difficult to mix
Segregation coefficient (n-octanol/water) log
Pow: Not determined.
Viscosity:
dynamic: Not determined.
kinematic at 20 °C: 22 s
Solvent separation test: Not determined
Solvent content:
EU-VOC 0.00 %
9.2 Other information No further relevant information available.
(Contd. of page 8)
CAS: 68609-97-2 oxirane, mono[(C12-14-alkyloxy)methyl] derivs
Dermal LD50 26,800 mg/kg (Rat)
Primary irritant effect:
Skin corrosion/irritation
Causes skin irritation.
Serious eye damage/irritation
Causes serious eye irritation.
Respiratory or skin sensitisation
May cause an allergic skin reaction.
CMR effects (carcinogenity, mutagenicity and toxicity for reproduction)
Germ cell mutagenicity Based on available data, the classification criteria are not met.
Carcinogenicity Based on available data, the classification criteria are not met.
Reproductive toxicity Based on available data, the classification criteria are not met.
STOT-single exposure Based on available data, the classification criteria are not met.
STOT-repeated exposure Based on available data, the classification criteria are not met.
Aspiration hazard Based on available data, the classification criteria are not met.
(Contd. of page 9)
Toxic for fish
Additional ecological information:
General notes:
Do not allow product to reach ground water, water course or sewage system.
Danger to drinking water if even small quantities leak into the
ground.
Also poisonous for fish and plankton in water bodies.
Toxic for aquatic organisms
12.5 Results of PBT and vPvB assessment
PBT: Does not contain PBT substances.
vPvB: Does not contain vPvB substances.
12.6 Other adverse effects No further relevant information available.
IMDG
Limited quantities (LQ) 5L
Excepted quantities (EQ) Code: E1
Maximum net quantity per inner packaging: 30 ml
Maximum net quantity per outer packaging: 1000 ml
UN "Model Regulation": UN 3082 ENVIRONMENTALLY HAZARDOUS
SUBSTANCE, LIQUID, N.O.S. (EPOXY RESIN,
EPOXY RESIN), 9, III
*
SECTION 16: Other information
This information is based on our present knowledge. However,
this shall not constitute a guarantee for any specific product
features and shall not establish a legally valid contractual
relationship.
Relevant phrases
H315 Causes skin irritation.
H317 May cause an allergic skin reaction.
H319 Causes serious eye irritation.
H411 Toxic to aquatic life with long lasting effects.
Department issuing SDS: R&D Department of Weber-Middle East
Contact:
Product Safety
T+97125509449
e-mail: DL-weber.productSafety-ME@Saint-gobain.com
(Contd. on page 13)
EUG
46.1. 13
Page 13/13
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 13.05.2018 Version number 1 Revision: 13.05.2018