Professional Documents
Culture Documents
Draft saved
*Required
Email *
abku1994@gmail.com
Name *
ABHISHEK KUMAR
Roll No *
00115608220
Email *
abku1994@gmail.com
Which of the following represents the quality of straightness in precision *
engineering?
Straight edge
Spirit level
Autocollimator
Dial indicator
Maximum deviation from the middle point of straight line joining two extremities
Minimum deviation from the middle point of straight line joining two extremities
For checking straightness, straight edge is placed over a surface and these two *
are viewed against the light. Which of the following option true if colour of light
is red?
±10 mm
±5 mm
±2.5 mm
±20 mm
What is the tolerance on flatness for Type-A optical flats of sizes up to 100 *
mm?
0.05 m
0.05 mm
0.05 µm
0.05 cm
Crest diameter
Cone diameter
Full diameter
Outside diameter
Root diameter
Cone diameter
Virtual diameter
Inside diameter
Pitch in inches
T, T
F, F
F, T
Which of the following are main elements, error in any of these can cause *
rejection of thread?
Major diameter, minor diameter, effective diameter, angle of thread and pitch
What is the purpose of locating cylinder in the test of the true running of the *
main spindle?
Vertical direction
Horizontal direction
At an angle
Longitudinal
Transverse
Which of the following is done for testing the true running of headstock *
centre?
Feeler of dial indicator is pressed at obtuse angle to the taper surface of cent
Feeler of dial indicator is pressed at acute angle to the taper surface of cent
Which of the following is not used in testing the pitch accuracy of lead screw? *
A negative stop
Dial gauge
Length bars
Slip gauge
0.01mm/300 mm
0.01mm/100mm
0.02mm/100 mm
0.02mm/300 mm
More accurate
Tooth caliper
The minimum distance of any point on the profile of tooth form and normal to the
design profile when the two coincide at the reference circle
The maximum distance of any point on the profile of tooth form and parallel to the
design profile when the two coincide at the reference circle
The maximum distance of any point on the profile of tooth form and normal to the
design profile when the two coincide at the reference circle
The minimum distance of any point on the profile of tooth form and parallel to the
design profile when the two coincide at the reference circle
What is the standard value of clearance? (Where, m is module) *
0.182 x m
0.572 x m
0.821 x m
0.157 x m
Part of the surface of tooth which is in the middle of top and bottom of the pitch
surface
Part of the surface of tooth which is at the top of the pitch surface
What is the name of angle which is present between line of action and common *
tangent to the pitch circles?
Pressure angle
Pitch angle
Lead angle
Helix angle
What is the wear allowance recommended by BSI for solid ring and plug *
gauges?
0.01mm
0.5mm
0.001mm
0.05mm
This content is neither created nor endorsed by Google. Report Abuse - Terms of Service - Privacy Policy
Forms