Professional Documents
Culture Documents
Caluya
PARTY NO: ______________________
OBJECTIVES:
a. To determine individual pace factor.
b. To measure distance by pacing.
PROCEDURE:
COMPUTATIONS:
a. The ends of the assigned course should be marked with either hubs, chaining pins,
or by chalk if on pavement.
b. Range poles are held behind the end points to serve as guides during actual pacing.
c. A plastic tape should be used in laying out or in measuring the actual lengths of
courses assigned for pacing.
d. When taping, two measurements should be made for any line and the mean
recorded as it’s actual length.
e. The length of a single step is called a pace. It may be measured from heel to heel
or from toe to toe. Also, each two paces or a double pace is called a stride.
f. To keep one on the line while pacing, it is a good practice to fix one’s eye on a
distant object on the range behind the pole at the line being paced.
g. A partial distance at the end of the line should be figured out to the nearest one-
fourth pace.
h. The accepted precision for measuring distance by pacing usually varies from
1/200 to 1/500.
i. Reject measurements that vary from the mean by more than three percent.
j. If the computed relative precision of the set measurements is greater than one part
in two hundred , the measurements should be repeated.
PF = LENGTH / MEAN
Mean = 139 + 138+ 140 + 142 + 140 + 138
6
Mean = 139. 5 or 140
PF = LENGTH / MEAN
PF = 100 / 139.5
PF = 0.7168 or 0.717 m/pace
CONCLUSION:
In my conclusion, the paced distance and the taped distance are precise and accurate due to the
numbers. When I solved and determined the paced factor, they are almost the same. That’s why
my answer is almost the same in paced distance and taped distance.
DOCUMENTATION: