Professional Documents
Culture Documents
Contents
About us........................................................................................................................................2
I. Wheelbase Configuration.........................................................................................................3
II. Shifter Configuration..............................................................................................................3
2.1. LED Effects Customization...............................................................................................5
2.2. Calibrate the shifter...........................................................................................................6
2.2.1. Calibrate h-pattern.....................................................................................................6
2.2.2. Calibrate sequential....................................................................................................6
2.3. Set the shifter’s thresholds................................................................................................7
2.3.1. Set the h-pattern thresholds.......................................................................................7
2.3.2. Set the sequential thresholds......................................................................................8
2.4. Troubleshoot......................................................................................................................8
2.4.1. Cannot change the gear..............................................................................................8
2.5 Update firmware.................................................................................................................9
1
VNM SIMULATION JSC
About us
VNM Simulation JSC comes from Vietnam. We are a new simulation
equipment manufacture. We aim to deliver high simulation equipment and
help an active online DIY community where people can discuss how to
make high quality simulation equipment by themselves when using VNM
Simulation’s firmwares (these are free for personal use).
Download the lasted UI/Firmware on this repo:
https://github.com/hoantv/CarSimulatorFirmware
the repo includes:
Wheelbase firmware
Shifter firmware
UI
Will add pedal, handbrake, steering wheel soon.
2
VNM SIMULATION JSC
I. Wheelbase Configuration
Will be updated
There is 2 options Analog Mode and Inversion Mode that are used for the
first setup before the shifter is packaged. So please don’t modify 2 option.
3
VNM SIMULATION JSC
Calibration Groupbox:
o H-Pattern/Sequential combobox: Based on position of a switch,
behind the shifter. The UI detect which mode is in use.
o Calibrate button: Usually, you don’t need this option, it is used
for the 1st setup of the shifter when uploading firmware or
factory reset. It used to set minimum, maximum of each shifter
axises (X, Y axis).
o The grid shows the gear area. When the shifter’s rod is in an
area, the number in this area will turn green. It indicates that a
gear change to this gear number.
o Three circles 9, 10, 11: Cycles 9,10 indicate the positions of the
truck’s knob button if use. The cycle 11 indicate switch mode
position.
Stats Groupbox
o Select Report combox: use for configuring the thresholds (X1,
X2, X3, Y1, Y2) for each shifter gear. It must in “Select
Report” to make the shifter work. “Shifter Configuration” is
used to configure the thresholds.
o FW: shows the version of shifter firmware.
o Min-Max: show min value, max value of X, Y axis after
calibration.
4
VNM SIMULATION JSC
5
VNM SIMULATION JSC
When shifter reconnect, it will play new effects/color that you chose
before.
Step 5: Drag/drop the vertical white lines such that when the shifter at
a position, The green pot doesn’t That point does not overlap white
lines.
7
VNM SIMULATION JSC
8
VNM SIMULATION JSC
9
VNM SIMULATION JSC
10
VNM SIMULATION JSC
Remove usb A to usb A cable, connect USB B to PC. Open the GUI,
it displays the version equal to the version you have downloaded.
11
VNM SIMULATION JSC
12