Professional Documents
Culture Documents
1.0 INTRODUCTION
In today’s difficult economic times, with energy prices that have been rising slowly
but steadily for years, many homeowners are taking a serious look at alternative or
“free energy systems to reduce their home power bill. Solar panels and perhaps the
most popular followed by wind turbines, and then geothermal heat pumps. There’s
another clean, renewable power system, however, that few people have heard of
and that is extremely well suited to residential use. It’s a free power generator,
which uses perpetual motion generator, which uses also a perpetual motion magnet
to generate electricity. A perpetual motion generator is very much like any
electrical generator. Instead of using fossil –fuel powered steam turbines to turn the
rotor of the generator; however it uses the push pull effect of polar opposite
perpetual motion magnet to keep the voter spinning indefinitely. Free generators
are very versatile. They are relatively small roughly the size of a garbage can so
they don’t take up much space even in a home. Furthermore, perpetual motion
magnets are not affected by temperature, so magnetic generator can operate in
extreme conditions. Although it may not be allowed to be left outside exposed to
the wind, rain and snow, they all do just fine in an unheated or air conditioned
garage, basement, or attic. Unlike wind and solar power which only generate
electricity of certain times and under certain conditions, magnetic generators
operates continuously, moreover, the perpetual motion magnets produce a stable
constant stream of electricity at a rate of about 24kilowatts a day.
Although, this may not be enough to power our home entirely, it can reduce power
bills by (depending on the size of the house) between thirty and fifty percent.
Finally, the magnetic generators are completely safe. They do not burn fuel or
1
release greenhouse gases or any other toxic by product. They are safe for everyone
and the environment. The main aim of this work is to have free energy generator- it
is a self powered system which generates electricity, or we can say it recycles
electricity feed to it, for itself and outside the system, continuously
Nikola Tesla once said that, all people should have energy sources for free to fulfil
their daily needs. There is electricity everywhere presents in limitless quantities
and can drill the world’s equipment without the need of non-renewable sources
such as gas, coal or oil
Free energy means the zero cost energy. Mechanical energy which drills windmill
by using the blowing force of wind, or solar energy in solar cell which is converts
into DC current and store in batteries. Other energy obtained are from wind power,
water power and telluric power. Free energy generator is used to generate these
types of energy. Free energy suppression is the notion that corporate energy at
minimum cost. All other remaining untouched forces of nature which are well
familiar in the scientific literature, which includes earth batteries, atmospheric
electricity telluric currents, and pressure system changes. The energy conditions
motion is considered fantastical forces. These devices utilize quantum vacuum
energy, quantum vacuum perturbation, magnets.
Why motor company are not using magnet in both the rotor and in starter part so
that it automatically runs and operate at least small devices and which helps the
people where electric transmission is not. The most importance of this device is
that it generates electricity without the need for non-renewable energy source.
2
1.3 AIM OF THE PROJECT
The concept of free energy generator can be used for generating electricity without
using any fossil fuel, and any other mean, which means to generate free electricity
In this method a magnet is constructed with copper wire and nut and bolts. Which
is powered by magnetic spin thereby pushing, pulling electrons and electricity is
generated itself.
3
1.7BENEFIT OF THE PROJECT
Small size
Low maintenance
Durability
Continuous operation
Constant electrical output
Self powering
Safe to operate
Co-friendly
Can provide 30%-50% of home electricity
Financial constraint
Limited time frame
Breakdown are possible
Limited electrical output
Rare
Expensive
4
CHAPTER TWO
Despite the great importance in daily life, few people probably stop to think about
what life would be like without electricity. Like air and water, people tend to take
electricity for granted. However, people use electricity to do many jobs every day
from lightening, heating and cooling home to powering televisions and computers.
Before electricity became widely available, about 100 years ago, candles whole oil
lamps and kerosene lamp provided light ice box kept food cold; and wood burning
or coal-burning stoves provided heat
Scientist and inventors have worked to decipher the principles of electricity since
the 1600s. Benjamin Franklin, Thomas Edison and Nikola Tesla made notable
contributions to our understanding and use of electricity
Nikola Tesla studied engineering and physics in the 1870s without receiving a
degree, gaining practical experience in the early 1880s working in telephony and at
Continental Edison in the new electric power industry. In 1884 he immigrated to
the United States, where he became a naturalized citizen. He worked for a short
time at the Edison Machine Works in New York City before he struck out on his
own. With the help of partners to finance and market his ideas, Tesla set up
laboratories and companies in New York to develop a range of electrical and
mechanical devices. His alternating current (AC) induction motor and
related polyphase AC patents, licensed by Westinghouse Electric in 1888, earned
5
him a considerable amount of money and became the cornerstone of the polyphase
system which that company eventually marketed.
Before 1879, direct content (DC) electricity was used in all lights of outdoor. In the
late 1800s Nikola Tesla pioneered the generation, transmission and use of
alternating current (Ac) electricity which reduce the last of transmitting electricity
6
over long distance. Tesla invention brought about electricity into towns to power
indoor lighting and into factories to power industrial machines.
The free energy generator is the type of generator where we can generate energy
without using any input. Nothing in the globe is free of cost i.e. one needs to pay a
certain amount for using some units of energy. But a question arises. Does really
free energy can be made? Yes we can generate by using the property of magnet.
There are basically, two kind of magnet that are in usage. The electromagnet and
other permanent magnet.
The electromagnet is the one that gets energized or delivers a permanent magnet is
the one that has some inbuilt magnetic properties which are used in D.C motors
mainly PMOC motor.
There are so many technology of free energy in modern technology, raying from
wind generators to solar panels to pad charger to home earth heaters and so many
others, some would be considered below.
Free energy generator includes the magnetic motor, quantum energy generator,
black lights sun cell, Kiril Chukanov’s quantum free energy generator, solar
hydrogen trend hydrogen reactor. Magnetic motor device operates on neodymium
permanent magnet’s principle. The magnet does not exert any power instead; the
electric pulse that produces the magnet straightens the atoms within the iron
thereby creating a magnetic dipole which has the same effect. As the elective
dipole of a batteries. The difference between the ordinary motor and electric coils
is that electric coil generates the magnetic field. These coil water the power by
7
turning it into heat and the ordinary motor need continuous supply of electric
power In order to maintain the magnetic field. Whereas, the former has no coils
and thus, can be utilized as a free energy generator. in this case the forces
producing the moving movement of the retorts produced by using the permanent
magnetic field of the magnet
Casmir effect describes the concept of free energy (Elizaide and Romeo, 1991
Plunion et al, 1986). This effect ties to give a better understanding of why an
empty space seems to have energy that has the capacities to cause physical charge
on a road object. He considered two conducting plate that does not carry elastic
charge with space in between them. However the plates need to be very close to
each other for the effect to be seen. He realized that is the distance between the two
plates is kept small, electromagnetic waves with a wavelength larger than the space
between the plates will no longer be able to fit. In order to solve the pressure
created, the plate are being pushed together, therefore the smaller the distance
between the plates, the stronger the force exerted. This effect is said to have
supported the existence of fuel vacuum energy thematically (Razmi and Shirazi,
2015)
8
CHAPTER THREE
Magnet
Connecting wires (copper)
Nuts and bolts
Pliers
Electric bulb
Ammeter
Voltmeter
9
Electric Bulb – it converts electric energy to light. When electric current
flows through it, the bulb produces light. A switch stops and allows the
electricity to flow through the circuit.
Ammeter – is an instrument used for measuring either direct or alternating
electric current, in amperes. An ammeter can measure a wide range of
current values because at high values only a small portion of the current is
directed through the meter mechanism; a shunt in parallel with the meter
carries the major portion.
Voltmeter – also known as a voltage meter, is an instrument used for
measuring the potential difference, or voltage, between two points in an
electrical or electronic circuit.
Fig. 3.1
3.4METHODOLOGY
To achieve the aim and objectives of the work, the following are the steps involved
10
Draw a wining and circuit diagram
Test for continuity of materials and devices
Design and calculation for the device was carried out
Studying of various materials used in the project work
Finally, the whole device was used and final test was carried out
3.5METHOD/PROCEDURES
After placing the magnet on the plane surface, the two 13 nuts and bolt were
placed on top of their magnet perpendicularly in such a way that they will be a
contact between the neodymium magnet, the nut and bolts to create
electromagnetic field.
The copper wire is being coiled around the two 13 nuts and bolts sequentially to
create positive and negative terminal.
After the coiling of the wire around the nuts, soldering iron was used to soldered
the positive and negative terminal to the electric bulb correctly.
Then the extra magnet is being brought in contact with the set up construction to
create close contact of the open circuit which will automatically bring current in
the electric bulb.
Then the whole work is being put into correct test for result and conclusion of the
study work.
11
CHAPTER FOUR
4.1 RESULT
After many series attempt of changing the materials such as copper wire, 13 nuts &
bolts, different magnet types for the construction of free energy generator, the
result obtained was not in alignment with the project work.
4.2 DISCUSSION
This project work has come to the knowledge that more research needed to be done
to get the expected and accurate result. Design and construction of free energy
generator require much finance and availability of time to be accomplished. These
have become a challenge that needs more researches to proffer solution to this
particular topic by other scientist in this field of study. Because there is no error in
trying but at the end there must be a solution to every problem, if more knowledge
is put together by different researcher/scientist.
So it takes more time and financial balance to accomplish this work by researchers.
12
CHAPTER FIVE
5.1 SUMMARY
This study is the design and construction of free energy for offices and home
appliance which receives low electrical consumption. This becomes necessary
because of inadequate electricity supply from the grid, the vandalism of pipelines
that supplies gas to electricity, generating plant resulting to total blackout or power
shielding arbitral charges from electricity distribution company and the effect of
Co2 (carbon monoxide) emission from fossil fuels.
Then the whole construction work was done and being put into correct test for test
and conclusion of the study work.
5.2CONCLUSION
In this research, we have designed and constructed free energy generator for an
office on Science Laboratory Technology Department Benue State Polytechnic,
Ugbokolo Benue State. This became necessary because of inadequate electricity
supply from the grid, the vandalism of pipelines that supply gas to electricity
generating plant resulting to total blackout or power shielding arbitral charges from
electricity Distribution Company and the effect of Co2 emission from fossil fuels.
The constructed free energy generator was unable to produce the desired output
voltage due reasons which were not known as at time we were asked to complete
this project work. We have recommended thus;
13
5.3 RECOMMENDATION
At the end of the study there is need to try other ways of generating free electricity
using other method line turbines method or flywheel or more improvement on this
magnetic free energy generator to generate free electricity in the country should be
seriously put into consideration by other scientist in Nigerian since others have
worked on it and it works.
I recommend that more research should be done on this topic with availability of
time and financial support which will bring positive and improve results.
14
REFERENCES
James. A, (2005) “Introduction to Electric Circuit (5th ed)” New York Press.
Razmi and Shirazi (2015) “The existence of fuel Vacuum Energy Thematically”
15