Professional Documents
Culture Documents
Before any operation, carefully check that the working area is free of
obstacles, individuals or machines being a potential source of danger.
Do not remove the protection and safety devices from the silo. Before start
up, make sure all protections are properly installed.
For carrying out any maintenance and cleaning operation on the machine
operators shall be equipped with the adequate personal protective equipment
(PPE): safety footwear, protective clothing, helmets, antistatic anti-cut gloves,
antiseptic face mask (in case of food, dangerous and potentially toxic
products).
SAFETY INFORMATION
All the staff working with the silo shall observe the following safety
regulations.
Disconnect power supply, block the main disconnector in open position using
the key during the whole intervention.
Isolate the silo from the plant and bring it back to atmospheric pressure.
Wait for the plant to reach room temperature.
1
Smont_ConoVib_Silo_Trevira_v1_0_GB
All fixing bolts and nuts removed during the intervention must be replaced
when remounting. Make sure not to mix up differing bolts.
2
Smont_ConoVib_Silo_Trevira_v1_0_GB
1. - Disconnect the extraction device (rotary valve) from product transport pipes
(Pic. t1-t2).
Pic. t1
Pic. t2
3
Smont_ConoVib_Silo_Trevira_v1_0_GB
2. - Loosen the two fixing collars of the extraction valve/vibrating cone separating
element (Pic. t3).
During the operation, hold the extraction valve to prevent it from accidentally
falling to the ground (suspended valve, without supporting feet).
Pic. t3
3. - Carefully remove the extraction valve and the separating element (Pic. t4).
Pic. t4
4. - Provide a support for the vibrating bottom (e.g. place it on the forks of a
forklift) to prevent it from falling to the ground during subsequent disassembly
operations.
5. - Loosen and carefully remove the joint ring of the vibrating cone bottom (Pic. t5).
4
Smont_ConoVib_Silo_Trevira_v1_0_GB
Between the joint ring and the fabric of silo body there is a steel shim next to
the lock screw. It is to avoid any fabric creases when tightening the joint ring.
Pic. t5
Along the flanged section of the vibrating bottom (Pic. t7) there is a white
seal. Should the latter be extremely worn out, remove and replace it with a
new one. Take care not to scratch the surface of silo vibrating bottom.
7. - It is now possible to enter the silo for its disinfestation through the opening on
the bottom (Pic. t6).
Pic. t6
5
Smont_ConoVib_Silo_Trevira_v1_0_GB
Pic. t7
Pic. t8
9. - Correctly mount back all remaining parts following the disassembling steps in
reverse order.
___________________________
6
Smont_ConoVib_Silo_Trevira_v1_0_GB