Professional Documents
Culture Documents
3 The discount factor used to convert future values (benefits and costs) to present value factor
present values is called _____.
4 A factor used to calculate the sum of money required at the end of each of capital recovery factor
a series of periods to regain the net investment of a project plus the
compounded interest on the unrecovered balance is called ______.
5 The two beams push downward on the girder with a force of 40 kN at C, A = 43.3 kN, B = 46.7 kN
and two other beams push downward with a force of 50 kN at D. Find the
reactions at A and B.
Solution:
6 Solve for the support reactions at A, B and C and moment at C. Ax = 0, Ay = 1 kN, Bx = 0, By = 0.8 kN, Cx
= 0, Cy = 3.5 kN, Mc = 12.9 kN-m
Solution:
7 A cylindrical vessel is 1.5 m diameter and 4 m long is closed at ends by rigid 0.75 mm
plates. It is subjected to an internal pressure of 3 N/mm². If the maximum
principal stress is not to exceed 150 N/mm², find the change in length of
the shell. Assume E = 2 x 10⁵ N/mm² and Poisson’s ratio = 0.25.
Solution:
9 The National Building Code of the Philippines is Presidential Decree No. 1096
_______.
10 A steel plate has a 2.000 cm diameter hole through it. If the plate is heated, It increases
what happens to the diameter of the hole?
11 Given a sphere of radius 0.15 m and weight of 2.5 kN. Find the forces on 2.24 kN and 0.67 kN
the inclined surfaces as shown.
Solution:
12 If |A x B| = |A×B|, then angle between vectors A and B will be: 45°
Solution:
13 The present worth of a sequence in time of sums of money when the discounted cash flow
sequence is considered as a flow of cash into and/or out of an economic
unit is known as ______.
14 The Philippine Electronics Code Book 3 is about ________. Cable Television System
15 Find the reactions developed at A and D as shown. Ay = 3463 #, Dx = 3000 #, Dy = 1733 #
Solution:
16 Light bulbs are typically rated in terms of their watts. The watt W is a The power dissipated.
measure of:
17 Determine the tension in AB and the force in AC. AB = 4.64k, AC = - 5.36k
Solution:
18 A cylinder of gas floats in a large tank of water. It has a frictionless but Isothermal
tightly sealed piston of mass M. Small masses are slowly placed onto the
top of the piston, causing it to slowly move downward. For the gas inside
the cylinder, what kind of process is this?
19 In a hollow circular shaft of outer and inner diameter of 20 cm and 10 cm 58.9 kN-m
respectively, the shear stress is not to exceed 40 N/mm². Find the
maximum torque which the shaft can safely transmit.
Solution:
20 A thin cylinder of internal diameter 1.25 m contains a fluid at an internal 2.08 cm
pressure of 2 N/mm². Determine the maximum thickness of the cylinder if
the longitudinal stress is not to exceed 30 N/mm².
Solution:
Solution:
22 The position on an object (measured in meters from the origin, where x = 0) 26 m/s
moving along a straight line is given as a function of time (measured in
seconds) by the equation x(t) = 4t² – 6t – 40. What is the object’s velocity
during the time that the object was at the origin?
Solution:
25 A graphic presentation of project activities shown by a time-scaled bar line bar chart
is called ______.