Professional Documents
Culture Documents
TRAINEE’s NAME: .
PRACTICAL ELEMENTS TRAINING BOOKLET FORM No: SATC/TF-23
Issue No: 01
Course Title: Airbus A318/A319/A320/A321 (CFM56) to Airbus Revision. No: 00
A319/A320/A321 (IAE V2500) B1/B2 Combined Differences Course- Issue Date: 04/01/2022
Practical Elements
LOCATION OF TRAINING
TRAINEE’S NAME
TRAINEE’S ADDRESS
1.3 GENERAL
This document provides evidence of practical element training to be conducted on the aircraft / engine types (as indicated).
The required tasks are to be carried out on an aircraft. The appropriate equipment is to be utilized to complete the task where required. A full
review of this booklet shall be undertaken upon its completion by the Practical Instructor (PI).
NOTE: TRAINEE SHOULD IDENTIFY/MENTION MEL AND TSM TASKS REFERENCE FOR EACH RELEVANT TASK IN BOOKLET.
i. Safety precautions.
ii. Manuals and relevant documentations.
iii. Procedures.
iv. Tools and test equipment, including special to task items.
i) Any testing procedures that may be required on completion.
j) All safety procedures are adhered to, at all times. All Trainees are to be made aware of any company safety regulations (as
applicable).
k) Personnel Protection Equipment will be provided to each trainee.
l) Question & Answer sessions and group discussions are encouraged throughout, to reinforce the training.
Note: Practical Instructor (PI) will ensure the accomplishment of all tasks practically on the aircraft as much as possible.
However, PI may utilize ‘Thorough Procedural Review’ for the task when its actual performance may not be possible on aircraft.
A/C Reg. or
Equipment
B1
Instructor
Signature
Signature
Eng. S/N
& Stamp
TASK
Trainee
S. No
Date
ATA
Parking/mooring,
01-01-2019
Storing and Return to
AP-XYZ
service STD, INST 1
10
Identify landing gear pin
A/C ABC
Parking/mooring,
01-01-2019
Storing and Return to
AP-XYZ
STD,
10 service
Install/Remove landing A/C ABC INST 1
NOTE:
The booklet is for B1 course only.
This example shows a B1 trainee who has completed the LOC and SGH tasks for ATA-10.
The equipment on which task is carried out, e.g. Standard (STD), Actual Aircraft with Engines (A/C).
The trainee has to complete the designated tasks ( ).
The aircraft registration number / engine serial number has been inserted.
The date of task completion has been inserted
The trainee has signed the trainee’s signature box to confirm that he/she has completed the task.
The trainee has to ensure that the Practical Instructor (PI) has initialed and stamped the instructor column.
T OT AL 47
PART.2
2.1 PRACTICAL TASKS:
Signature &
Equipment
A/C Reg. or
Signature
Instructor
Eng. S/N
B1 / B2
Trainee
Stamp
S. No.
TASK
ATA
Date
(IAE V2500 ENGINE)
LOC FOT SGH RIA MEL TSE
Signature &
Equipment
A/C Reg. or
Signature
Instructor
Eng. S/N
B1 / B2
Trainee
Stamp
S. No.
TASK
ATA
Date
(IAE V2500 ENGINE)
LOC FOT SGH RIA MEL TSE
POWER PLANT
Locate major engine sub-assemblies (Intake,
4 A/C,
71 Fan, Compressor, Combustor, Turbine,
Exhaust, Gearbox)
STD
AMM 70-00-00
POWER PLANT
5 A/C,
Opening and closing of engine FAN cowling
71
AMM 71-13-00-010-010-A
STD
AMM 71-13-00-410-010-A
POWER PLANT
Perform a troubleshooting procedure for EPR A/C,
6 71 Fluctuations on both Engines during Flight
(Review*)
STD
TSM:
Signature &
Equipment
A/C Reg. or
Signature
Instructor
Eng. S/N
B1 / B2
Trainee
Stamp
S. No.
TASK
ATA
Date
(IAE V2500 ENGINE)
LOC FOT SGH RIA MEL TSE
Signature &
Equipment
A/C Reg. or
Signature
Instructor
Eng. S/N
B1 / B2
Trainee
Stamp
S. No.
TASK
ATA
Date
(IAE V2500 ENGINE)
LOC FOT SGH RIA MEL TSE
Signature &
Equipment
A/C Reg. or
Signature
Instructor
Eng. S/N
B1 / B2
Trainee
Stamp
S. No.
TASK
ATA
Date
(IAE V2500 ENGINE)
LOC FOT SGH RIA MEL TSE
ENGINE IGNITION
16 Locate and identify ignition system components A/C,
74 AMM 74-00-00 PB 001 STD
ENGINE IGNITION
17 Perform operational check of igniter system A/C,
74 AMM 74-00-00-710-041-A STD
IGNITION SYSTEM
18 Perform MEL task for Ignition System “ A” A/C,
74 inoperative STD
MEL:
IGNITION SYSTEM
19 Perform a troubleshooting procedure for Failure A/C,
74 of the Ignition System A on Engine 1
TSM:
STD
Signature &
Equipment
A/C Reg. or
Signature
Instructor
Eng. S/N
B1 / B2
Trainee
Stamp
S. No.
TASK
ATA
Date
(IAE V2500 ENGINE)
LOC FOT SGH RIA MEL TSE
AIR
20 Locate and identify air system components
A/C,
75
AMM 75-00-00 PB001
STD
AIR
21 A/C,
General Visual Inspection of the Turbine
75
Cooling Air Tubes for Condition and Security
STD
AMM 75-23-00-200-010-A
AIR
A/C,
Perform Troubleshooting Procedure For A Loss
22 75
of Cooling Air System
STD
TSM:
AIR
A/C,
Hung Start/Hot Start/Stall - Effect of HPC Bleed
23 75
System on Engine Operation
STD
TSM:
Signature &
Equipment
A/C Reg. or
Signature
Instructor
Eng. S/N
B1 / B2
Trainee
Stamp
S. No.
TASK
ATA
Date
(IAE V2500 ENGINE)
LOC FOT SGH RIA MEL TSE
ENGINE CONTROLS
24 A/C,
Locate and identify main engine flight deck
76
control components
STD
AMM 76-00-00
ENGINE CONTROLS
A/C,
Perform MEL task for Thrust lever Position
25 76
Sensor inoperative
STD
MEL:
Signature &
Equipment
A/C Reg. or
Signature
Instructor
Eng. S/N
B1 / B2
Trainee
Stamp
S. No.
TASK
ATA
Date
(IAE V2500 ENGINE)
LOC FOT SGH RIA MEL TSE
ENGINE INDICATING
27 A/C,
77 Locate and identify engine indicating system /
ECAM panel
STD
AMM 77-00-00 PB001
ENGINE INDICATING
A/C,
30 Perform troubleshooting procedure for a High
77
N1 vibration indicated on engine 1
STD
TSM:
Signature &
Equipment
A/C Reg. or
Signature
Instructor
Eng. S/N
B1 / B2
Trainee
Stamp
S. No.
TASK
ATA
Date
(IAE V2500 ENGINE)
LOC FOT SGH RIA MEL TSE
ENGINE EXHAUST
31 A/C,
Locate and identify thrust reverser / exhaust
78
components
STD
AMM 78-00-00 PB001
ENGINE EXHAUST
32 A/C,
Opening of the Thrust Reverser Halves
78
AMM TASK 78-32-00-010-010-A
STD
AMM 78-32-00-410-010-A
ENGINE EXHAUST
Perform MEL task for Deactivation of the Thrust A/C,
33 78 Reverser System for Flight
AMM 78-30-00-040-013-A
STD
MEL:
ENGINE EXHAUST
Perform a troubleshooting procedure for Failure A/C,
34
78 of the Thrust Reverser on Engine 1 STD
TSM:
Signature &
Equipment
A/C Reg. or
Signature
Instructor
Eng. S/N
B1 / B2
Trainee
Stamp
S. No.
ATA
Date
TASK
LOC FOT SGH RIA MEL TSE
ENGINE OIL
35 Locate and identify oil system components A/C,
79 AMM 79-00-00 PB001 STD
ENGINE OIL
36 Check Oil Level and Replenish A/C,
79 AMM 12-13-79-610-011-A STD
ENGINE OIL
37 A/C,
Inspection of the Master Magnetic Chip
79
Detector
STD
AMM 79-00-00-200-014-A
ENGINE OIL
38 Perform MEL task for Oil Temperature
A/C,
Indication on the ENGINE SD page
79
MEL:
STD
ENGINE OIL
39 A/C,
Perform a troubleshooting procedure for Low
79
Oil Pressure and Low Oil Quantity on Engine 1
STD
TSM:
Signature &
Equipment
A/C Reg. or
Signature
Instructor
Eng. S/N
B1 / B2
Trainee
Stamp
S. No.
ATA
Date
TASK
LOC FOT SGH RIA MEL TSE
ENGINE STARTING
40 A/C,
Locate and identify starting system components
80
AMM 80--00-00
STD
ENGINE STARTING
41 A/C,
Drain and Replenish Starter Oil System
80
AMM 12-13-80-600-011-B
STD
ENGINE STARTING
Perform simulated aircraft MEL dispatch with a A/C,
42 80 failed starter shut off valve STD
MEL:
ENGINE STARTING
Perform troubleshooting procedure for a failed A/C,
43
80 starter shut off valve STD
TSM:
Signature &
Equipment
A/C Reg. or
Signature
Instructor
Eng. S/N
B1 / B2
Trainee
Stamp
S. No.
ATA
Date
TASK
LOC FOT SGH RIA MEL TSE
FUEL SYSTEM
44 A/C,
28 Locate and identify Fuel Diverter and
Return valve STD
AMM 73-10-00-00)
ICE AND RAIN
Perform simulated aircraft MEL dispatch with A/C,
45 Engine Anti-Ice Valve Inoperative in the STD
30
closed position
MEL:
PNEUMATIC
46 A/C,
36 Perform simulated aircraft MEL dispatch with
Engine Bleed Valve (PRV) inoperative. STD
MEL 36-11-02A
NACELLES/PYLONS
47 54 Locate pylon pressure relief doors A/C,
STD
AMM 54-52-00- PB 401